Professional Documents
Culture Documents
Skinny Tie Tutorial
Skinny Tie Tutorial
Skinny Tie Tutorial
Pin them together, matching the edges. One side of the tie will bunch up
a little bit since it is bigger than the other side. This will make it
so the seams doesn't show on the front when you iron it flat.
Instead of trimming one piece, you can also just pin one side up 1/8"
and it will have the same effect.
Using your collar measurement as the length, cut a strip 2 1/2" wide.
Press over 1/4" on the short ends of your strip. Press over another 1/4"
and pin in place.
Sew up the edges using a 1/4" stitch.
If you think turning little tubes is boring you can make the neckband
this way instead:
Make your piece 3" wide instead of 2 1/2". Press over 1/2" on each of
the long edges.
Time to assemble.
Fold your tie to the length you would like it and loop it around the
neckband.
Pull the other end of the tie through itself like a slip knot. Pull it
taut and adjust the knot.
You can readjust the length later when your kiddo gets taller.
And now your skinny little guy has a
skinny little tie!