Professional Documents
Culture Documents
Pasmbatboxplan
Pasmbatboxplan
Pasmbatboxplan
SMALL
BAT HOUSE
LUMBER: BA ROOF SUPPORTS
4' X 4' X 1/2" CDX EXTERIOR PLYWOOD RO
OS
CK
10"
4. Attach 2 BAFFLE SPACERS to inside front corners BAFFLES
with two screws each, and screwed in from front of
9 1/16"
box. Space about 2 inches from top of box FRONT EXTERIOR STAINED BLACK AND ROOF
1/2" FOR BAT
1'-6"
with 3/4" dimension to sides. Lay assembled parts
1'-3 1/16"
FRONT down on table or floor. Vent MOVEMENT
2'-0"
1/2" Vent
5. Attach ROOST BAFFLE to spacers about 1"
down from top of sides. Use 2 screws on each side.
5"
6. Attach two BAFFLE SPACERS into new corners made
5 1/2"
5 1/2"
12. Lay ROOF in position and attach with at least three screws
on each SIDE, FRONT and BACK. Clean excess caulk.
1' 6" X 2' 4' X 4' X 1/2"
ROOST
BAFFLE CDX
1' 2"
13. Caulk back of roof top where it butts against the back.
Smooth with damp towel. Inspect all other caulked seams 1' 4 1/4" X 1' 2" EXTERIOR
and caulk exterior seams as necessary.
GRADE
TOP OF BOX MUST BE AIR TIGHT 40 degree Angle PLYWOOD
SO IT CAN HOLD HEAT. 9 1/16"
FRONT
14. Apply two to three coats of stain to exterior, including the (TOP)
landing plate.
1'6" X 9 1/16"
15. Cut section of black rolled roofing to fit on roof top. Apply thin
bead of caulk around top of roof edges. Set rolled roofing into
5 1/2" FRONT (BOTTOM)
position and staple down. Caulk back edge of rolled roofing
where it butts against box BACK. Caulk exposed staples on 1'6" X 5 1/2"
rolled roofing surface.