Your machine has been fully adjusted at the factory and no further adjustment should be necessary. It has been wired in accordance with the red tag hanging on it. Make sure your power source conforms. To change blades, raise head slightly and close hydraulic to hold in position. Lift cover and move idle wheel to right by turning blade tension handle counter-clockwise until blade can be lifted off. Place new blade around wheels under flanges and insert between guide rollers. Turn motor on. Tighten blade until all
Your machine has been fully adjusted at the factory and no further adjustment should be necessary. It has been wired in accordance with the red tag hanging on it. Make sure your power source conforms. To change blades, raise head slightly and close hydraulic to hold in position. Lift cover and move idle wheel to right by turning blade tension handle counter-clockwise until blade can be lifted off. Place new blade around wheels under flanges and insert between guide rollers. Turn motor on. Tighten blade until all
Your machine has been fully adjusted at the factory and no further adjustment should be necessary. It has been wired in accordance with the red tag hanging on it. Make sure your power source conforms. To change blades, raise head slightly and close hydraulic to hold in position. Lift cover and move idle wheel to right by turning blade tension handle counter-clockwise until blade can be lifted off. Place new blade around wheels under flanges and insert between guide rollers. Turn motor on. Tighten blade until all