Professional Documents
Culture Documents
Match
Match
1. Cut all pieces. For floral holder, foil interior lines of front and
back sections with 3/16" or 7/32" foil. Solder front and
back.
2. Wrap the edges of completed sections and all other glass
pieces with 3/8" foil.
3. Place back section face up on table. For construction
purposes, this will be considered the base upon which all
pieces will be built, as in basic box construction. Place the
two side pieces and “bottom” piece on base. (Figure 1)
Fasten together well with masking tape. Tack solder, remove
tape, then completely solder all of box’s interior lines.
4. Tape front and front bin to box. Tack solder, remove tape.
Completely solder all remaining exposed foil, using an ample
amount of solder. (Figure 2)
5. The floral holder hangs from open hole at top. To hang plain
holder, loop a piece of #20 or heavier copper wire and solder
in place. (Figure 3) Tin wire to match solder.
6. Clean. Patina if desired.
7. Remove outer sleeve from large box of wooden matches.
Insert inner box with matches in place into holder. Matches
will dispense from below as needed.