Professional Documents
Culture Documents
E2-134 Questions & Answers
E2-134 Questions & Answers
E2-134 Questions & Answers
4: Dynamic Routing
Question 1 Task 2: Verify the static and dynamic routes.
Step 2. Examine the routing table on R1. Are there any static routes in the routing table? If so, what are the routes?
ANSWER
Yes. S S S S S 192.168.3.0/24 is directly connected, FastEthernet0/1 192.168.4.0/24 is directly connected, FastEthernet0/1 192.168.5.0/24 is directly connected, FastEthernet0/1 192.168.6.0/24 [1/0] via 192.168.2.2 192.168.7.0/24 [1/0] via 192.168.2.2
Question 2
Step 3. Ping from R3 to PC1. R3#ping 192.168.1.10 Was the ping successful?
ANSWER
Yes Sending 5, 100-byte ICMP Echos to 192.168.1.10, timeout is 2 seconds: U.U.U Success rate is 0 percent (0/5)
Question 3
Task 3: Enter a static route on R2 to reach R1's LAN.
Step 2. Examine the routing table on R2. Are there any static routes in the routing table? If so, what are the routes?
ANSWER
Yes. S 192.168.1.0/24 is directly connected, FastEthernet0/0
Question 4
Step 3. Ping from R3 to PC1. R3#ping 192.168.1.10 Was the ping successful?
ANSWER
Yes Sending 5, 100-byte ICMP Echos to 192.168.1.10, timeout is 2 seconds: ...!! Success rate is 40 percent (2/5), round-trip min/avg/max = 126/133/141 ms
Question 5
Task 4: View the RIP routing updates in simulation mode.
Step 3. Start the simulation.
ANSWER
There is no service running on this port so it drops the segment. 2