Professional Documents
Culture Documents
NAD 2140 Service Manual
NAD 2140 Service Manual
NAD 2140 Service Manual
CONTENTS
SPECIFICATIONS BLOCK DIAGRAM ALIGNMENT WIRING CIRCUIT & INSIDE VIEW
2
3 4 5 6 7 8 9 11 15
DIAGRAM DIAGRAM
PCB PARTS LOCATION ASSEMBL Y DIAGRAM ASSEMBL Y PARTS PARTS LIST PACKING DIAGRAM
SPECIFICATIONS
All specifications are measured in accordance with IHF Standard A-202 Continuous Average Power Output at B ohm 20-20K Channels Driven Rated Distortion, 20-20K Clipping Headroom Clipping Power Hz Hz both 50W
< 0.03%
+0.5 dB 57W BOW 90W
Dvnarnic Headroom at B ohm Dynamic Power at B ohm at 4 ohm at 2 ohm Transient Overload Recovery Time Slew Factory Slew Rate Damping Factor at 50 Hz (Ref. B ohm) TH D 20-20K Hz from 250 mW to 50 W
+ 1.B dB
BOW 130W 150W 1 usec 50 30 V/usec 150
% % %
SMPTE IMD (60 Hz + 7K Hz, 4 : 1) from 250 mW to 50 W IHF IMD (19K Hz + 20K Hz) at 50 W TIM (15K Hz Sinewave+ 3.1BK Hz Square Wave) at 50W Frequency Response,20-20K Hz
< 0.03%
±
0.05 dB Hz
10-30K
-2-
BLOCK DIAGRAM
R.CH·
NORMAL
()4._--IINFRASONI 12 db/oct C~ ......
--I
LAB
SPEAKER
(
I I
L. CH.
NORMAL INFRASONIC 12db/ocl
./
./
I
I I
SPEAKER
LAB
I I I
I
I I I I I I
~/
U7
./
POWER SUPPLY
~II~
REGU LATOR
REGULATOR
-25
-45
-3-
ALIGNMENT
IDLE
f.
>2. 4.
3. Set on the power for 1 minute pre-heating. Remove the cord on speaker terminals. to L channel speaker terminals "+" the other to point TP1 on main PCB, adjust VR-603 until 6 mV reading is reached, and this figure will keep on 5. Connect one probe of DC millivolt-meter
increasing, then wait for 1 minute later turn down the current until 6 mV is re-obtained. 6. Connect one probe of DC milli volt-meter to R channel speaker terminals "+" the other to point TP2 on main PCB, adjust V R-604 until 6 mV reading is reached, and this figure will keep on increasing, then wait for 1 minute later turn down the current until 6 mV is re-obtained. DC OFF-SET ALIGNMENT 1. Disconnect all sources input to the power amplifier. 2. Set on the power for 5 minutes pre-heating. 3. 4. For L channel alignment: connect prcae of DC millivolt-meter then adjust VR-601 then adjust VR-602 until zerovoltage reading is reached. to R channel speaker terminals, until zero voltage reading is reached. For R channel alignment: connect probe of DC millivolt-meter to L channel speaker terminals,
5.
Power Transformer.
8. Power Amplifier.
2. Main Supoly.
6. Heat Sink.
9. Speaker SW.
10. Power SVV.
3.
SlC Circuit.
7. Regulator.
4. Soft CI ipping.
WIRING
FOR: C 1 ( 12 OV)
DIAGRAM
U1 U2 (110V 120V
nov
240V)
VOLTAGE SELECTOR
SPEAKER
SPEAKER
----10
FOR: C 2 020V)
19-1136
GR .-----------TRANSFORMER
OR
Be
'29-2051-8
1321
P22
P23
37
PI6 WI RE B~RE QRY EGRBLGYWHCOLOR SLACK RED ORANGE. YELLOW GREEN BLUE GARy WHITE --------24 -ABBREVIA110NS
?
1
[1."
23
SPEAKER
_j
SPEAKER B
FOR: U4(230V)
FOR:
E1
rzzov:
~l
G~205j
I
VlJ
19_1132
-5-
CIRCUIT DIAGRAM
LCH
NOR IN POWER INPUT BUFFER POWER AMPLIFIER REGUlATOR
~-----~--------~----~
180 ZW 10K
ill
sw: , sO!=T
SW 3
<D
CLIPP1NG SWITCH. A
sWlTCH. 5'111TCH
SW 2 . SR, DGING SLC o SW 4 sW 5 SW6 UNcES" AUl FUSE FOR; SPEAKER SPEAKER PONER RESiSTOR flATTING E2. ARE
MOOE
swncu.
OTHERWISE
us.
U4.
r i. F2
RCH
ARE ARE
F3~F6ARE
1 BFl,Z3 8C556 BF4Z2
T2.SA/2SOV
eCS46
8C549
~'\
8(559 8E2L.3
CBE ECB
~
BCE F7
ECB
C666
E1
(nay)
F7
SW6a
U3 (220V)
C8~1
4700P
1 U2
C2
(120V)
~
SW6~
(110V120V 2LO".40V)
C823
zzoo>
250Y
=1
'-'
cszF7 T 2A 250V
L----~
1---1 f-j
2200P
2501,'
'oil
~=I liT)
c::::J
C824
--j~
2Z00P 25,01,'
-----d':"§.bEL ( 240V)
I
1
Z2QOP
2501,'
FOR !.'~
o--*---J
-Jill
I 4700P 1251,' SW6b
s"C823 I
r~
I
~O-"---;T L
SW6tl
E4 ( 220V) U4
--1
t
ez s
r-
2200P
25011
-6-
PCB PARTS
LOCATION
(BOTTOM VIEW)
. ..,...
u...
-7-
ASSEMBLY
DIAGRAM
I
I
.r
I I
..
----
-----.J
-8-
ASSEMBLY PARTS
ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 DESCRIPTION Front Panel Flat MA Screw 3x6 T RI Screw 3x8 Push Knob Tap Screw 3x6 Bottom Chassis MA Screw 4x 10 Washer 4x8 Rubber Feet LED Holder Chassis Front Retainer Chassis R ChassisCenter PCB Holder Chassis L Insulation Plate A Insulation Plate B Headphone Jack Power SW. Transformer PCB Fiber Washer 3x8 PCB Heat Sink Bracket for Heat Sink Socket 4P Cord Bushing 4N4 PART NO. 11-8179 S 1E03+106SZ-2 S5B03+10810SL-2 12-3090 S2B03+ 106SL-2 11-6060 Sl B04+11OSL-2 A04A08SL 0.8 28-1029 13-4056 11-6067-1 28-2086 11-6091 11-6074 11-2208 11-6073 13-4051 13-4052 12-2078 31-1129 29-2051 19-1132 A03A08F 0.5 19-1136 11-5053 11-2188 12-2092 14-5003 , Q'TV 1 3 3 3 11 1 12 4 4 1 1 2 1 2 1 1 1 1 1 1 2 1 8 1 1 1 1 1
-9-
ITEM 29 30 31 32 33 34 35 36 37 38 39 40 41 42
DESCRIPTION Power Cord Fuse Holder Push Knob Back Panel Ground Screw Cabinet Tap. Screw 3x8 Washer 4x10 Speaker Terminal Plastic Screw AC Outlet MA Screw 3x6 Special Screw Speaker Switch
PART NO. 14-5033 32-2005 12-3095 11-8180-1 15-2037 50-1023 S2B03+108SL-2 A04A10SLO 1 12-2095 15-2048 12-2006 S1B03+106SL-2 15-2051 31-1179
Q'TV 1 1 3 1 1 1 30 8 2 4 2 7 6 1
-10-
PARTS
REF. NO.
LIST
PART NO. CAPACITORS DESCR IPTION NOTE
C601-C604 CS05 C606 CS07 C608 C609 C610 CS11 C612 CS13-C616 CS17 C618 C619 C620 C623 C624 C627-C630 CS31-C634 C645 C646 C647- C650 C651 C652 C653 C654 C655 C656 C657 C660 C661 C662 C663 C665 C666 C801-C804 C805 C806 C807-C809 C810 C811 C812 C813 C814 C815 C816 C819 C820 C697 C698 C823 C824
17-1.6R105K 17-5FR332J 17-5FR102J 17-50R220M 17-0.63E 108Y 17-50R470M 17-50R104M 17-5ER105Y 17-50R104M 17-50R104M 17-3.5ER476Y 17-50R220M 17-1ER476Y 17-50R221M 17-50R104M 17-5ER476Y 17-50R101M 17-50R102M 17-5ER476Y 17-5FR102J 17-5P478Y 17-6.3E4 77Y 17-3.5E R106Y 17-6.3ER106Y 17-50R104M 17-3.5E R476Y 17-5FR102J 17-6.3ER106Y 17-3.5ER106Y 17-6.3ER106Y 17-5ER 106Y 17-2008
Electrolytic Solid Mylar Mylar Ceramic Electrolytic Ceramic Ceramic Electrolytic Ceramic Ceramic Electrolytic Cearmic Electrolytic Ceramic Ceramic Electrolytic Ceramic Ceramic Electrolytic Mylar Electrolytic Electrolytic Electrolytic Electrolytic Ceramic Electrolytic Mylar Electrolytic Electrolytic Electrolytic Electrolytic Capacitor DIODES
1uF+-i10% 3300PF+-5% 1000PF+-5% 22PF+-20% 1000uF+50-1001o 47PF+-20% 0.1 uF+-2001o 1uF+50-1 0010 0.1uF+-20% 0.1uF+-20% 47uF+50-1001o 22PF+-20% 47uF+50-1001o 220pF+-20% 0.1uF+-20% 47uF+50-1001o 100PF+-20% 1000PF+-20% 47uF+50-10% 1000pF+-5% 4700u F+50-1 0% 470uF+50-10% 1OuF+50-1 0010 1OuF+50-1 0010 0.1 uF+-20% 47uF+50-10% 1000PF+-5% 1OuF+50-1 0% 1OuF+50- 10010 10uF+50-10% 1OuF+50-1 0010 2200PF 250VAC
16V 50V 50V 50V 6.3V 50V 50V 50V 50V 50V 35V 50V 10V 50V 50V 50V 50V 50V 50V 50V 50V 63V 35V 63V 50V 35V 50V 63V 35V 63V 50V
0601-0606 0609-0612 0613 0614 0801-D804 0805 0806-0810 0811 0812 0813
BAW62/BAW76 BAW62/BAW76 Zener 22V 0.5W G3B Rectifier 200V 1.5A W02 BAW62/BAW76 Zener 22V 0.5W Rectifier 100V 1A 1N4002/1001
-11-
DESCRIPTION LED Red LT3211 R LED Green LT3231 G LED Yellow LT3251Y TRANSISTORS
NOTE
0601 0605 0607 0609 0615 0617 0623 0625 0633 0635
0602 0606 0608 0610 0616 0618 0624 0626 0634 0636
30-2084-3 30-2096 30-2238 30-2087 30-2259 30-2260 30-2251 30-2252 30-2090-2 30-2096
BC549C BC556A BF423 2SD381 2SB649 2SB669 MJ15003 MJ15004 BC546B BC556A RESISTORS
R601 R603 R609 R611 R613 R615 R617 R619 R621 R623 R625 R627 R629 R633 R635 R637 R639 R641 R643 R655
R602 R604 R610 R612 R614 R616 R618 R620 R922 R624 R626 R628 R630 R634 R638 R640 R642 R644 R656
16-1/4CA 184J 16-1/4CA562J 16-1/4CA222 16-1/4CA223J 16-1/4CA471J 16-1/4CR 153J 16-1/4CR102J 16-1/4CA331J 16-1/4CA 102J 16-1/4CA27OJ 16-2A681J 16-1/4CA222J 16-1/4CA561J 16-1/2A 101J 16-2A 122J 16-1/2A3R3J 16-1/4CA47OJ 16-1/4CA332J 16-1/4CA 102J 16-2A 152J 16-1/2CP181J
Carbon Carbon Carbon Carbon Carbon Carbon Carbon Cal::bon Carbon Carbon Metal Oxide Carbon Carbon MetalOxide Metal Oxide Metal Oxide Carbon Carbon Carbon Metal Oxide Carbon
1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2W 1/4W 1/4W
180K 5K6 2K2 22K 470 15K 1K 330 1K 27 680 2K2 560 100 lK2 3.3 47 3K3 lK lK5 180
Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm
+-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5%
R605-R608
ll2W
2W 1/2W 1/4W 1/4W 1/4W 2W 1/2W
-12-
REF. NO. R657-R660 R66l R663 R665 R667 R669 R677 R679 R685 R687 RC93 R697 R699 R6l01 R6102 R6103 R6l04 R6105 R6l06 R6111 R6112 R6l13 R6119 R6120 R803 R805 R806 R807 R808 R809--R811 R812 R813 R814 R815 R8l6 R8l7 R818 R819 R804 R662 R664 R666 R668 R670 R678 R680 R686 R688 R694 R698 R6100
PART NO. 16-1003 16-1Al OOJ 16-1/2A3R3J 16-2A471J 16-1017 16-1/4CA681J 16-1/4CR332J 16-1/4CA151J 16-1/4CA 102J 16-1/4CA151J 16-1/4CR332J 16-1/4CA 182J 16-1/4CA223J 16-1/4CA562J 16-1/4CA332J 16-1/4CA332J 16-l/4CA 184J 16-1/4CA 184J 16-1/4CA331J 16-l/4CA331J 16-1/4CA562J 16-l/4CR562J 16-2A681J 16-1/4CA 102J 16-1/4CA102J 16-1/2A5 R6J 16-1/4CA 103J 16-1/4CA 101J 16-1/4CR472J 16-1A 151J 16-1/4CA 103J l6-2A l81J 16-1/4CA273J 16-1/4CR563J 16-1/4CA 102J 16-1/2A 1OlJ 16-1/4CA101J 16-1/4C R102J 16-1/4CR153J Metal Plate Metal Oxide Metal Oxide Metal Oxide Metal Plate Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Carbon Metal Oxide Carbon Carbon Metal Oxide Carbon Carbon Carbon Metal Oxide Carbon Metal Oxide Carbon Carbon Carbon MtealOxide Carbon Carbon Carbon
DESCRIPTION 5W lW 1/2W 2W 5W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2W 1/4W 1/4W 1/2W 1/4W 1/4W 1/4W lW 1/4W 2W 1/4W 1/4W 1/4W 1/2W 1/4W 1/4W 1/4W 0.22 10 3.3 470 0.22 680 3K3 150 lK 150 3K3 lK8 22K 5K6 3K3 3K3 l80K 180K 330 330 5K6 5K6 680 lK lK 5.6 10K 100 4K7 150 10K 180 27K 56K lK 100 100 lK 15K Ohm Ohm Ohm Ohm Ohm Ohm Omh Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm Ohm +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +·-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5% +-5%
NOTE
R68l -R684
-13 -
REF. NO. R820 R821 R822 R823 R825 R6123 R6124 L601 L602 VR603 VR604 R824
PART NO. 16-1/4CA822J 16-1/4CR 102J 16-1/4CR 104J 16-2A 181J 16-1/4CR183J 16-1/4CA 102J 16-1/4CA 102J 29-1036-1 29-4055 29-4055 Carbon Carbon Carbon Metal Oxide Carbon Carbon Carbon
DESCRIPTION 1/4W 'l/4W 1/4W 2W 1/4W 1/4W 1/4W 8K2 lK lOOK 180 18K lK lK
\
NOTE Ohm Ohm Ohm Ohm Ohm Ohm Ohm +-5% +-5% +-5% +-5% +-5% +-5% +-5%
-14
PACKING
DIAGRAM
ITEM 1. 2. 3. 4. 5.
Q'TV 1 1 2 1 1
-15