Professional Documents
Culture Documents
EC302 (Electronic Computer Aided Design) : Nurjalilah Binti Mohd Yaacob 16DEP10F1036
EC302 (Electronic Computer Aided Design) : Nurjalilah Binti Mohd Yaacob 16DEP10F1036
-END OF CHAPTER 6-
CHECK BY,
End of Chapter 6 Question: Draw the mixed signal schematic shown in Figure 6.1: and answer the following questions. You must answer by showing your lecturer every setup that you make.
e) Set the attributes of the pulse source, V1,to produce the signal below
f) Set the digital stimulus, DSTIM1 to generate a HIGH level from 0s to 0.5s and LOW for the rest of the stimulation
h) Graph: i) The digital output signal for the 7414 Schmitt trigger signal, Vo2, and the 74393 counter output signals, Qa, Qb, Qc, and Qd on a single plot
V+ U1 3 + 7 Vo1 OS2 OUT V2 uA741 4 VD1 R1 8k DSTM1 D1N750 OS1 5 R2 6 1 10k 1 Vclamp U3A 2 7414
V
V+
QA QB QC QD
CLR
V V
Qa Qb Qc Qd
V V
S1
R3 1k
V+
0
V3 V2 12Vdc 12Vdc
V-
ii)
The analog outputs Vo1 and Vclamp together on the second plot
V+ U1 3 + 7 Vo1 OS2 OUT V2 uA741 4 VD1 R1 8k DSTM1 D1N750 OS1 5 R2 6 1
V V
V+
10k
QA QB QC QD
CLR
V V
Qa Qb Qc Qd
V V
S1
R3 1k
V+
0
V3 V2 12Vdc 12Vdc
V-
CHECK BY,
End of chapter 5 Question: a) Draw and simulate a switch-tail counter given below.All flip flops must be cleared at the start of simulation and minimized on the number of IC s used.Set the clock to generate 1kHz waveform for 20 cycles and set the transient analysis for 20ms