Professional Documents
Culture Documents
Toyota Corolla Elcomplo.
Toyota Corolla Elcomplo.
1987 Toyota Corolla (FWD) For Electronics & Computers El Camino Real Santa Clara CA 95051
Copyright 1997 Mitchell International Wednesday, November 25, 1998 03:45AM
ARTICLE BEGINNING
1987 ELECTRICAL COMPONENTS LOCATIONS Toyota Electrical Components Toyota; Corolla 4WD
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component Locators
Behind right side of dash, near cruise control computer. In front left corner of engine compartment, near battery.
Inside passenger's door trim panel. Under dash, to right of steering column, behind ECU.
Headlight Relay
Heater Relay
Taillight Relay
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component Locators
Door
Heater
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component Locators
EFI Electronic Control Unit (ECU) Electronic Controlled Transmission (ECT) Computer
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
MOTORS
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
A/C Condenser Fan Motor Blower Motor Cruise Control Vacuum Pump Motors Behind right side of radiator. Behind glove box, on bottom of blower housing.
Component Locators
Except FX Models
FX Models Radiator Fan Motor Rear Window Wiper Motor Sun Roof Motor
In right rear corner of engine compartment. Behind left side of radiator. Inside left side of rear hatch. On front center of roof, near sun roof switch.
On right side of firewall. In front right corner of engine compartment, on washer reservoir.
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component Locators
Coolant Temperature Sensor Fuel Gauge Sending Unit Oxygen Sensor Vehicle Speed Sensors No. 1 . No. 2 .
On rear of engine, on engine coolant inlet. In fuel tank. In exhaust manifold. On back of instrument cluster. On right top side of transmission.
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
A/C Idle-Up VSV A/T Solenoids Lock-Up, No. 1 & No. 2 In front of front right shocktower. On transaxle valve body.
Component Locators
On throttle body.
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
SWITCHES
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
A/C Low Pressure Switch A/C High Pressure Switch Back-Up Light Switch (M/T) Brake Fluid Level Warning Switch Brake/Stoplight Switch Behind right side of dash, to right of evaporator. In left front corner of engine compartment. On right front side of transmission. At bottom of brake fluid reservoir cap. On brake pedal bracket.
Component Locators
Coolant Temperature Switch Clutch Start Switch (M/T) Cruise Control Clutch Switch (M/T)
On rear of engine, in coolant inlet housing. On clutch pedal bracket. On clutch pedal bracket.
On throttle body.
On throttle body.
Vacuum Switch
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
Component
MISCELLANEOUS
ccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
A/C Amplifier A/C Thermistor Behind glove box, attached to right side of cooling unit. Behind right side of dash, inside of cooling unit.
Component Locators
Except FX Models
FX Models
Junction Block No. 3 Diagnostic Test Connectors "CHECK ENGINE" ECT Oxygen Sensor
Behind left side of dash. Near right front shock tower. Near front right shock tower. In exhaust manifold.
cccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccccc
END OF ARTICLE