LP340 Lamp Maint in Focus

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 3

Tech Tip

LP340/350 Lamp Maintenance In dirty or dusty environments, the dust filter screens on LP340/350 lamp modules can become plugged, causing excessively high temperatures inside the lamp module. The high temperatures can cause premature lamp failure. Routine maintenance to remove dust and dirt from the filter screens lowers the lamp operating temperature and lengthens lamp life. This Tech Tip describes how to clean the lamp module dust filter screens. Clean them every 200-250 hours when the projector is used in areas with high levels of airborne contaminants like lint, dust or smoke. You must remove the lamp from the projector to clean the dust filter screens. CAUTION! The lamp module gets very hot during operation. Allow the lamp to cool for 30 minutes before handling it. Removing the lamp module

 Remove the lamp door on the bottom of the projector by releasing the two tabs on the inside
edge of the door with your fingers. Then swing the door open.

If necessary, you can also use a coin. Take care not to scratch the finish on the projector.

LP340/340B/350 Lamp Maintenance

Page 1

Tech Tip
 Loosen the two captive screws that secure the lamp to the lamp housing.

 Grasp the orange tape in the middle of the lamp, then lift the module out of the projector.
Cleaning the lamp module dust filter screens

 After you remove the lamp module, examine the condition of the dust filter screens. Two screens
are located on each side of the lamp module. Dirt and dust accumulation on the screens must be removed.

LP340/340B/350 Lamp Maintenance

Page 2

Tech Tip
 Use a vacuum cleaner and a small brush to clean the screens on both sides of the lamp housing.
Then use a cotton swab dipped in isopropyl alcohol to lightly wipe each screen. When you've wiped each screen, use the vacuum cleaner again to remove any remaining contaminants.

Cleaning the lamphouse and replacing the lamp module

 Before you replace the lamp, use the vacuum cleaner to remove dust and dirt from the
lamphouse in the projector.

 Replace the lamp and lamp door.

LP340/340B/350 Lamp Maintenance

Page 3

You might also like