Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 3

TM-2129 Reservoir Mechanics Fall 2011 Institut Teknologi dan Sains Bandung

Homework 1 Reading Assignment: Petrophysics, Djebbar Tiab page 7-14, 29-53 While reading try to make a note and give a brief explanation about the following: 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. Igneous Rock Metamorphic Rock Sedimentary Rock Sandstone Carbonates Plate Tectonic Theory Basins Hydrocarbon Traps Primary Migration Secondary Migration

Homework 2 Reading Assignment: Petrophysics, Djebbar Tiab page 87-99 Try to make a brief explanation about: 1. Factors affecting porosity 2. Porosity classification

Homework 3 A reservoir assumed as homogeneous has some estimated data as following: Acreage : 1500 acre, Thickness : 20 ft, Porosity : 15 %,Fomation volume factor : 1.21 bbl/STB. Irreducable water saturation : 20% Calculate the Initial Oil In Place (in STB)

Homework 4 1. Calculate Absolute Porosity from the following Lab Data Pynometer volume : 10 cm3, pycnometer mass = 16.57 g, the mass of pycnometer after filled by liquid : 26.33, the mass of pycnometer after filled by a sample of crushed rock (about pycnometer volume) : 21.22 g, the mass of pycnometer after filled by sand grains and liquid : 29.225 g, the mass of dried core : 35.552 g the mass of immersed core : 24.321 g, the mass of saturated core : 42.342 g Reference : Petrophysics, Djebbar Tiab page 787 - 790

2. Calculate Water Saturation, Oil Saturation and Gas saturation from the following Lab Data : Porosity : 0.21, Bulk Volume : 30 ml, Oil density : 0.83 g/ml, mass measurement after the core is saturated : 58 g, mass measurement after the core is dried : 54 g, volume of water (collected after condensation : 1.1 ml Reference : Petrophysics, Djebbar Tiab page 769 771

3. Calculate absolute permeability using a liquid as follows Fluid viscosity : 0.876 cP at 25C, volume of fluid 11 cm3, length of core sample : 2.1 cm, crosssectional area of the core : 2.91 cm2, pressure gradient across the core : 2.2 atm, time required to paasage of 11 cm3 of fluid : 32 seconds Reference : Petrophysics, Djebbar Tiab page 813 - 815

Homework 5 Reading Assignment 1. Petrophysics, Djebbar Tiab 787 794 Porosity Measurement from grain volume Porosity Meassurement by gas compression 2. Petrophysics, Djebbar Tiab page 769 771 Measurement of saturation by extraction 3. Petrophysics, Djebbar Tiab page 97 105, 813 - 825 Permeability Classification of permeability Factor affecting magnitude of permeability

Absolute permeability measurement using liquid and gas Klinkenberg effect 4. Petrophysics, Djebbar Tiab page 203 206, 229 Formation Resistivity Factor Archie Formula

You might also like