Professional Documents
Culture Documents
Dimensions: Dimension and Tolerance Symbols
Dimensions: Dimension and Tolerance Symbols
Dimensions
The boundary dimensions of Spherical Plain Bearings are standardized; dimensions plans are included in DIN and ISO standards. Details are given in the text preceding each table section.
2. Tolerances
In order to guarantee full interchange-ability, SLB Spherical Plain Bearings are made to the dimensional tolerances specified in the following tables, unless otherwise stated. The symbols used in the tables are explained below. The maximum and minimum values quoted for a mean diameter or single width or height are the permissible deviations from the nominal dimensions given in the bearing tables. The tolerances apply to bearings without surface treatment and valid for inch as well as metric sizes. Steel-onsteel Spherical Plain Bearings undergo a special surface treatment to enhance running properties and provide protection against corrosion, so that there may be slight deviations from the tolerance values quoted in the tables. These slight deviations have no influence on the mounting or function of the bearings. Bearings which have fractured have slightly out of round rings as result of the fracturing. When mounted in housings with bores which have accurate dimensions and form, and a sufficient wall thickness, the original roundness will be restored. Consequently, measurements performed on bearings before they are mounted will not give a true picture of the original accuracy of the outer rings.
181
1) The deviations given in the columns dmp ( corresponding to H7 ) and BS ( corresponding to h1 ) 2) Apply to Spherical Plain Bearings of series GEG
182
183
Values for the internal clearance of metric and inch-size steel-on-steel spherical plain bearings will be found in the below Fig. 3.1, SLB steel-on-steel Spherical Plain Bearings are manufactured as standard with C2 or C3 clearance can only be supplied from series GE.. E, GE.. ES and GE..ES-2RS; availability should be checked before ordering.
Fig. 3.1
184
Unit: 0.001 mm
C3 min. 68 82 100 120 142 165 192 214 max. 104 124 150 180 212 245 284 318
1) Bearings of series GEH with bore diameters d=35,60 and 90 have a radial internal clearance.
185
186