Professional Documents
Culture Documents
Quick Start Guide: Insteon In-Linelinc™ Dimmer, Dual-Band
Quick Start Guide: Insteon In-Linelinc™ Dimmer, Dual-Band
ON button
In the Box
- In-LineLinc Dimmer - Four (4) wire nuts
OFF button Status LED Set button
wall box (verify that power is off). Remove wallplate from fixture, unscrew fixture you are replacing and gently remove from wall. Disconnect wires from fixture. If the wires cannot be unscrewed, cut them where they enter the switch and strip of insulation off the ends. After ensuring wires are not touching, turn breaker back on. Use a voltage meter to identify the Line and Load wires In-LineLinc Wire Wall Box Wires connected to the fixture. Ground Identify Neutral and Ground wires. Bare copper (commonly bare copper, green wire or green screw) Turn power back off. Neutral Connect In-LineLinc Dimmer Dual-Band wires as shown in the White (commonly white wire bundle) table/diagram (confirm firm attachment with no exposed wire). Load Prior to reinstalling the fixture, turn power back on. Red (light, fan, etc.) Test In-LineLinc Dimmer Dual-Band by pressing the ON and Line OFF buttons. Black (100 - 277V to Ground) The load will turn on and off. Add In-LineLinc Dimmer Dual-Band as a responder with desired INSTEON devices. Turn power back off. Gently place In-LineLinc Dimmer Dual-Band into wall box, making sure nothing can accidentally press any of the buttons on its face. Reinstall the fixture. Turn power back on.
1 2
If the controller does not have a beeper, wait until its LED begins blinking Most models
INSTEON Limited Warranty INSTEON warrants to original consumer of this product for a period of 2 years from date of purchase, this product will be free from defects in material and workmanship and will perform in substantial conformity with its Owner's Manual. Warranty shall not apply to defects caused by misuse or neglect. Protected under U.S. and foreign patents (see www.insteon.com) Copyright 2012 INSTEON, 16542 Millikan Ave., Irvine, CA 92606, 800-762-7845