Professional Documents
Culture Documents
3.updating Linux Kernel Image For Calixto
3.updating Linux Kernel Image For Calixto
*****************************
*
*
*Document
: Updating Linux Kernel Image (uImage) on Calixto Hardware.
*
*Prerequisites : nandflashing & Binary files should be installed properly.
*
********************************************************************************
****************************/
1. Copy 'uImage' named file from folder tftpboot_updated at location mentioned w
here tftpboot_firsttime is copied during nandflashing. Eg. at location /tftpboot
.
2. Now connect serial cable & start minicom session. To start minicom, refer min
icom_session document. Poweron the board & enter into uboot mode by pressing any
key when display shows following screen:
################################################################################
################################################################################
#
4. Connect 'Cross' LAN cable from PC to Calixto board. Then enter following comm
and:
uboot>tftp c0700000 uImage
Display will show following screen:
U-Boot > tftp c0700000 uImage
Using device
TFTP from server 192.168.1.35; our IP address is 192.168.1.37
Filename 'uImage'.
Load address: 0xc0700000
Loading: *#################################################################
#################################################################
#################################################################
#################################################################
#################################################################
#############################################################
done
Bytes transferred = 1975468 (1e24ac hex)
################################################################################
################################################################################
#
8. Check the date of the updated kernel. It should be Thu Jul 5 14:45:22 IST 201
2. Location is given below:
I2C:
ready
DRAM: 128 MB
NAND: 128 MiB
MMC: davinci: 0
Bad block table found at page 65472, version 0x01
Bad block table found at page 65408, version 0x01
In:
serial
Out: serial
Err: serial
ARM Clock : 300000000 Hz
DDR Clock : 150000000 Hz
Net: Ethernet PHY: GENERIC @ 0x00
Hit any key to stop autoboot: 0
uboot>
.
.
.
################################################################################
################################################################################
######
################################################################################
################################################################################
####
11. Poweroff the board.
host$poweroff
Display will show following screen Wait till it displays 'system halted'.
Broadcast message from root (ttyS2) (Wed Jan 26 00:17:06 2011):
The system is going down for system halt NOW!
INIT: Switching to runlevel: 0
INIT: Sending processes the TERM signal
Stopping telnet daemon.
Stopping system message bus: stopped process in pidfile '/var/run/dbus/pid' (pid
943)
dbus.
Stopping Dropbear SSH server: [953] Jan 26 00:17:08 Premature exit: Terminated b
y signal
dropbear.
Stopping thttpd.
ALSA: Storing mixer settings...
Deconfiguring network interfaces... done.
Stopping syslogd/klogd: stopped syslogd (pid 1048)
stopped klogd (pid 1050)
done
Sending all processes the TERM signal...
Sending all processes the KILL signal...
Unmounting remote filesystems...
Deactivating swap...
Unmounting local filesystems...
System halted.
################################################################################
################################################################################
####
--------------------------- **************** Here ends installation procedure **
*************** ---------------------------------