Professional Documents
Culture Documents
Configuration of Dial Up Conenction On Windows XP
Configuration of Dial Up Conenction On Windows XP
4.2.3
4.2.3.1
The mdmitv01.inf file is on CD-ROM. In case of installation from floppy-disk, it is necessary to copy the file on a floppy-disk.. The window of Fig. 4.87 is displayed again. Click on OK to copy the mdmitv01.inf file. The window of Fig. 4.88 is displayed; click on Next to continue. The window of Fig. 4.89 is displayed. Select the communication port (usually: COM 1) and click on Next to continue. The window of Fig. 4.90 is displayed. click on Continue Anyway to continue. The window of Fig. 4.91 is displayed. Click on Finish to end the installation procedure for direct connection. The window of Fig. 4.92 is displayed where Radio Equipment Windows NT Direct Connection appears in the list of installed modems. Click on OK to end and exit.
4-50
Fig. 4.81
Fig. 4.82
4-51
Fig. 4.83
Fig. 4.84
Fig. 4.85
4-52
Fig. 4.86
Fig. 4.87
Fig. 4.88
4-53
Fig. 4.89
Fig. 4.90
Fig. 4.91
4-54
Fig. 4.92
4.2.3.2
4-55
For the connection to the new equipment (as SRA 4, SRAL XD or MicroHop), it is necessary to select 38400 as bit rate for the port. The system displays the window shown in Fig. 4.107. Set the properties of the connection as pointed out into the figure. Click on OK to end and confirm the settings. To close all the currently open windows.
Fig. 4.93
Fig. 4.94
4-56
Fig. 4.95
Fig. 4.96
Fig. 4.97
4-57
Fig. 4.98
Fig. 4.99
Fig. 4.100
4-58
Fig. 4.101
Fig. 4.102
4-59
Fig. 4.103
Fig. 4.104
4-60
Fig. 4.105
Fig. 4.106
4-61
Fig. 4.107
4-62