Professional Documents
Culture Documents
6035 205 Sample Questions
6035 205 Sample Questions
6035 205 Sample Questions
8. What is the most cost effective way to repair a stop valve that has the head gear jammed open? a. Replace the head gear only b. Replace the whole valve c. Leave in position, and install a new stop valve upstream d. Repack the glands around the spindle. 9. When decommissioning a system, the correct procedure is to: a. Turn off the water quickly to save any wasted water b. Drain the system down then inform the customer c. Inform the customer first then drain the system d. Use a pump to drain down quickly. 10. What is this item? a. Fullway gate valve b. Drain off valve c. Stop valve d. Spherical ball valve. 11. What type of valve is shown in this diagram? a. Spherical ball valve b. Fullway gate valve c. Stop valve d. Drain off valve. 12. When installing a new water service pipe to a property, it should normally be buried between what depths? a. 135mm to 1,750mm b. 350mm to 750mm c. 1,350mm to 1,750mm d. 750mm to 1,350mm. 13. Identify item C in the diagram. a. Warning pipe b. Grommet for open vent c. Screened vent d. Inspection flap. 14. Which of the following materials is not allowed to be installed on new cold water systems? a. Copper b. Stainless steel c. MDPE d. Lead. 15. What type of valve is designed to shut off the supply of water in a cistern at a predetermined level? a. Stop valve b. Fullway gate valve c. Float operated valve d. Isolation valve.
2013 City and Guilds of London Institute. All rights reserved. www.SmartScreen.co.uk Page 2 of 3
16. The fluid category that offers a slight health risk to a customer is: a. 1 b. 2 c. 3 d. 4. 17. The correct back flow protection device that would be installed prior to a shower mixer valve would be: a. Single check valve b. Double check valve c. RPZ valve d. Type AG air gap. 18. To protect category 1 water from category 3 water, what would need to be installed, according to the Water Regulations? a. Single check valve b. Double check valve c. RPZ valve d. Type AG air gap. 19. What would this item be used to test? a. Pressure b. Category of water c. Flow rate d. pH valve 20. If a customers tap is dripping, what tool can be used to correct the situation? a. Club hammer b. Stillsons c. Bradawl d. Re-seating tool.
2013 City and Guilds of London Institute. All rights reserved. www.SmartScreen.co.uk
Page 3 of 3