Download as pdf or txt
Download as pdf or txt
You are on page 1of 7

5.

1 channels sound card

SC-5.1-1

5.1 channels sound card

5.1 channels sound card

Disclaimer We spared no efforts to make sure that the information in this manual is correct and complete. However no liability is accepted for any errors or omissions. Gembird Electronics reserves the right to change the specifications of the hardware and software described in this manual without prior notice. No part of this manual may be reproduced, transmitted or translated in any language in any form, by any means, without the prior written permission of Gembird Electronics Ltd. Gembird Electronics makes no warranties for damages resulting from corrupted or lost data due to a mistaken operation or malfunction of the product, the software, personal computers or peripheral devices.

Gembird is a registered trademark of GMB Tech (Holland) bv. Other names or products not mentioned above may be registered trademarks or trademarks of their respective owners.

Copyright 2007 Gembird Electronics Ltd. All rights reserved.

5.1 channels sound card

SC-5.1-1 User manual


Introduction
Thank you for buying the Gembird 5.1 channels sound card! This manual will help you install and use it properly.

Features
2/4/6 channel speakers mode. Supports 2/2.1/4/4.1/5.1 speakers Full-duplex playback and recording Superior audio fidelity High quality headphone amplifier Enhanced microphone input sensitivity

5.1 channels sound card

Specifications
Supports 6 channel output Fully compliant with AC97 Revision 2.3 Superior audio fidelity Independent 20 bit ADC and 20 bit DAC Provide 96K/20 bit Multi-channel analog output High quality headphone amplifier Enhanced microphone input sensitivity 4-bit 3D depth control Channel swapping Supports EAPD control PCI Rev. 2.2 compliant with bus mastering modes ACPI compliant power down management Chipset VT1723+1617

5.1 channels sound card

System requirements
Windows 98SE/ME/2000/XP/Vista DirectX 8.1 or above

Sound card layout

5.1 channels sound card

The rear panel of card has the following jacks: 1. 2. 3. 4. 5. 6. Mic In Line In Line Out Surr Out CEN/LFE J10 Analog CD|IN Port (Signals: L-G-G-R)

5.1 channels sound card

Installation
Locate an available PCI slot on your computer, and insert the 6 Channel Sound Card into the slot. Fasten the card to the case using a screw Start your PC. Windows will detect the Sound Card, find a PCI Multimedia Audio Device or Multimedia Audio Controller device. Click the Cancel button to cancel the driver installation for the device at this moment Place the Driver CD into the CD-ROM drive and start setup.exe on it, if the installation is not started automatically Follow on-screen instructions to complete the software installation Restart your system

You might also like