Professional Documents
Culture Documents
2008, Safwat, A.,Filter Analysis Describes The History of Wear
2008, Safwat, A.,Filter Analysis Describes The History of Wear
http://www.oilanalysis.com/article_detail.asp?articleid=1770
Past Issues
Home Training/Events Newsletter Advertise Buyers Guide Message Boards Bookstore Dictionary Contact Us
Across-bar cooler is one of the main pieces of equipment in cement production. It is used for the transport and cooling of clinker, one of the ingredients of cement. Cement kilns operate with a cross-bar cooler which consists of four grates driven by a hydraulic station. Any pump failures cause downtime and stop cement production. Therefore, it is important for the pump to operate smoothly on continuous basis.
Hydraulic Circuit
Pilot Pump The pilot pump provides oil flow to the proportional valve which controls the position of the swash plate. It also controls the oil flow from the main pump (axial piston pump) at 22 liters per minute. Boost Pump The boost pump refills the main pump with the same amount of oil removed by the shuttle valve to cool the oil. Oil flow is 50 liters per minute. Main Pump The main pump consists of an axial piston pump with variable displacement and variable direction. It provides flow in two directions (174 to 214 liters per minute) and controls the movement of the grates. Closed-loop Circuit In a forward direction, the pump suction comes from Port B (low-pressure side). Oil flow from Port A (high-pressure side) flows forward across the grate. When the swash plate position is reversed, the pump suction from Port A (low-pressure side) changes the direction of oil flow. Oil flow from Port B (high-pressure side) moves across the grate in reverse direction.
Equipment Reliability Made Visual Solid-State Viscosity Sensors for Condition Monitoring Creating an Effective Plant Lubrication Program FluidScan Handheld Lubricant Condition Monitor
Practicing Oil Analysis Machinery Lubrication Reliable Plant Lube-Tips Reliable Plant Mail Lean Manufacturing
What Happened
During a routine filter change, the technician noticed a large amount of metal wear debris in the bowl filter. An internal inspection revealed a problem in the boost pump. Because it was a pressure-line filter of the boost pump, the technician collected all metal from the bowl and analyzed it visually using an optical microscope. Wear particles larger than 100 microns were observed (Figure 1), and an emergency warning was issued to change the pump and filter immediately before the failure caused the machine to stop.
How to Read an Oil Analysis Report
Figure 1. Surface striations caused by the severe abrasive wear mechanism before the particle was removed.
Results
The gear pump was replaced. To confirm that the defect actually existed, the pump was opened and visually inspected. Close-up photos of the housing and gear of the defective pump show severe wear damage
Oil Sampling Advice
1 of 3
4/22/2007 9:11 PM
http://www.oilanalysis.com/article_detail.asp?articleid=1770
(Figure 2).
Conclusion
Wear particles collected by the oil filter were inspected using a microscope. It was concluded that the filters contained wear particles which characterize the most significant mode of pump wear. The filters remove and store metallic particles generated from the rubbing surfaces. The size and morphology of wear particles collected in the oil filters are larger than those deposited by ferrography. The history of wear and early failure of the sliding surfaces can be seen by following the striation marks caused by abrasion (Figure 1). The varying colors of wear particle surfaces reveal specific information about the temperature of the sliding surface from which the wear particles were removed.
Ahmed Safwat, Cemex Egypt, "Filter Analysis Describes the History of Wear". Practicing Oil Analysis Magazine. November 2008 Issue Number: 200811 Practicing Oil Analysis Case Study
2 of 3
4/22/2007 9:11 PM
http://www.oilanalysis.com/article_detail.asp?articleid=1770
3 of 3
4/22/2007 9:11 PM