Professional Documents
Culture Documents
Uscts08 320
Uscts08 320
Uscts08 320
FOR EXTERNAL THREADS (lower case letter symbols) Tolerance Position "e" has a large allowance. The upper limit is below basic by a large amount. Tolerance Position "g" has a small allowance. The upper limit is below basic by a small amount. Tolerance Position "h" has no allowance and the upper limit is basic. FOR INTERNAL THREADS (capital letter symbols) Tolerance Position "G" has a small allowance. The lower limit is above basic by a small amount. Tolerance Position "H" has no allowance and the lower limit is basic. SELECTION OF TOLERANCE CLASSES Two factors determine the selection of a suitable tolerance class: 1. Length of thread engagement (short, normal or long) 2. Quality requirement (fine, medium or coarse) See table below for preferred tolerance classes
Tap Technical
External Thread (Bolts) Tolerance Position g Tolerance Position h (Small Allowance) (No Allowance)
Length of Thread Engagement
Internal Thread (Nuts) Tolerance Position G Tolerance Position H (Small Allowance) (No Allowance)
Short Normal
Long
Short 4H
6e
7e-6e
5g-6g
6g
7g-6g
5h-6h
6h
7h-6h
5G
6G
7G
5H
8g
9g-8g
7G
8G
NOTE: Tolerance Position "e" is not to be applied to pitches finer than 0.5 mm. Tolerance classes 6g and 6H are for commercial screw, bolt and nut threads.
THREAD DESIGNATIONS
Basic Designations: The letter "M" and the nominal size (basic major diameter in millimeters) followed by "X" and the pitch in millimeters, designates metric screw threads. For coarse series thread, the "X" and pitch may be omitted. Example: Coarse series threads; M6 other threads; M8 x 1 A complete designation comprises, in addition to the basic designation, the tolerance class symbol separated by a dash. When the pitch and crest diameter tolerance classes are identical, the symbol need only be given once. Example: M20 x 26H When the pitch and crest diameters have different tolerance classes, the pitch diameter symbol is followed by the crest diameter symbol. Example: M6 x 0.755g6g To indicate a specified thread fit between mating parts, the internal thread tolerance class symbol is followed by that of the external thread, separated by a slash. Example: M20 x 26H/5g6g When rounded root external threads are to be specified, the minimum root radius value shall be added to the tolerance class designation. Example: M65g 6g 0.100R
320
WWW.OSGTOOL.COM
800.837.2223