Professional Documents
Culture Documents
IR Sub Grade Construction
IR Sub Grade Construction
Unless otherwise approved,this inspection request form shall be submitted during the daily morning meeting among LTA,Contractor and QP(S) Contractor: SAMWOH CORPORATION PTE LTD SK E&C To: Project:
NO:
ER296-CONSTRUCTION AND COMPLECTION OF SENTOSA GATEWAY TUNNEL FROM TELOK BLANGAH ROAD TO KEPPEL ROAD / KAMPONG BAHRU ROAD/ LOWER DELTA ROAD AND ASSOCIATED ROAD WIDENING WORKS INTERCHANGE
Date: Time:
The work described below has been inspected by our Site engineer and is complete and ready for your inspection. A checklist is attached overleaf. Location Checked and Requested By: Chainage Activity Drawings Used for Construction Other Description
The meeting noted that the information provided by the Contractor is adequate/not adequate*. QP(S) may proceed *delete where appropriate Request Rejected
__________________________________________
QP(S) Name & Signature/Date work approved to start:___________________ LTA The above process for request for inspection of work by Contractor and approval by QP(S) is noted. ___________________________ LTA's Representative/Date/Time work completed on:__________________________
NO:
Location:
Description of Works
Chainage:
Checked by Contractor Confirmed by QP(S)
Send properly labelled soil samples for last 500mm of subgrade for the following tests 1.1 Maximum Dry Density 1.2 California Bearing Ratio (CBR)
2 3 4 5 6 7 8
Ensure soaked CBR conform to specifications Check formation levels of subgrade Provide proper drainage for subgrade surface Conduct field density tests (TABLE A) Continue mechanical compaction until in-situ test results conform to specifications Check sufficient temporary traffic devices if lane closure is required Others
TABLE A
1 2 3 4 5 6 7 8 9 10 11 12 13 14 Chainage : Wt of soil from hole Wt of sand (+ cylinder ) before pouring (M1) Wt of sand (+ cylinder ) after pouring (M4) Wt of sand in hole (M5 = M1 - M4 - M2 ) Ratio = Mw/M5 Bulk density of sand Pa Bulk density of soil P = (Mw/M5)xPa Moisture content (w) Dry density Pd = 100P/(100+w) Max. dry density Optimum moisture content % of compaction Remarks Calibration (* Cylinder*) *Mean of sand in core (of pouring cylinder) (M2) Volume of calibrating container (V) *Wt of sand (+ cylinder) before pouring (M1) *Wt of sand (+ cylinder) After pouring (M3) *Sand to fill calibrating container (Ma = M1 - M3 - M2) Bulk density of sand Pa = Ma/V Mg/m3 Mg/m3 % Mg/m3 Mg/m3 % m g g g g A B C D E F
g mL
g g g Mg/m3