Professional Documents
Culture Documents
GMC Full Size Pickup 2002: Remote Start / Security / GPS
GMC Full Size Pickup 2002: Remote Start / Security / GPS
COM
GMC Full Size Pickup 2002
Installation type: Remote start / security / GPS
Wire/Function
PASSIVE ANTI-THEFT 12 VOLTS IGNITION IGNITION 2 ACCESSORY STARTER TACH LOCK UNLOCK DOORPIN DRIVER DOOR LATCH FACTORY ARM FACTORY DISARM BRAKESWITCH PARKLIGHTS HAND BRAKE HORN DRIVER WINDOW UP DRIVER WINDOW DOWN PASSENGER WINDOW UP PASSENGER WINDOW DOWN HEADLIGHTS DIMMER KEY SENSE
Colour
YES Red & Red/white Pink White (small gauge) Orange Yellow (small gauge) See notes* Blue White Tan & Blue/white*** Tan Tan**** Lt.green White Lt.blue Lt.blue Black Dk.blue Brown Dk.blue Brown White (small gauge) Green Lt.green
Location / Description
PASSLOCK II Ignition switch harness Ignition switch harness Ignition switch harness Ignition switch harness Ignition switch harness
Polarity
SEE NOTES + + + + +
At BCM below steering column** At BCM below steering column** At BCM below steering column*** At BCM below steering column**** At BCM below steering column**** At BCM below steering column**** At st. column or brake switch On back of light switch At back of handbrake lever At steering column At switch in driver's door At switch in driver's door At switch in passenger door At switch in passenger door On back of light switch On back of light switch Ignition switch harness
Vehicle note:
PLEASE NOTE: This vehicle is equipped with GM's PASSLOCK II passive anti-theft system. Please refer to the alarm diagram before any remote start installation. * The 4300 V6 engine still uses a single coil on the top of the engine, tach wire is WHITE. On the V8 engines, there is a coil for each cylinder, each with a 4-pin plug. Each plug contains a BLACK, BROWN & PINK, as well as a 4th wire which changes color on each coil. This 4th wire can be used as your tach reference, set your remote starter for a 1 cylinder signal. ** In the 24-pin plug on the far left. *** Tan (driver's door) is in the 16 pin plug on the far right and the Blue/white (pass. Door) in on the 24-pin plug in the center of the module. **** Located is 16-pin plug on far right. Pulse the TAN wire at the same time as the lock wire to arm the factory alarm. Pulse ground to the LT.GREEN wire to disarm the alarm.
Note: The information on this sheet is provided to you on an as is basis with no representation or warranty of accuracy whatsoever. It is the sole responsibility of the installer to check and verify any circuit before connecting to it. Only a computer safe logic probe or digital multimeter should be used. Wiremagic.com Corporation and/or any associated or unassociated individual or corporation who furnishes this document and/or software assumes absolutely no liability or responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in each and every case is the sole responsibility of the installer performing the work and Wiremagic.com Corporation and/or any associated or unassociated individual or corporation assumes no liability or responsibility whatsoever resulting from any type of installation, whether performed properly, improperly, or in any other way. The information supplied is a guide only. Copyright 1998-2001 Wiremagic.com Corporation. All rights reserved.
Page 1 of 1