Professional Documents
Culture Documents
Toner Concentration Check Sheet
Toner Concentration Check Sheet
Entering the SP values into Table 1 will determine the risk of Toner Scattering. Check procedure: Step 1) Input the current SP values into the cells colored in yellow in Table 1 below. (Either go into the SP mode or refer to the SMC printout.) Step 2) Values input in step 1 are calculated and will appear in Table 2 as "A" and "B". Compare the results against " Condition 1 " and "Condition 2 ".
Table 1
Consumption rate in Page Counter and Drive Distance
Table 2
7-945
Remarks: Accurate results cannot be obtained for colors in which the page counter (SP7945-xx) is below 5,000. Do this check procedure at another time when the page counter (SP7945-xx) has exceeded 5,000.
8-441
Condition 1
(A) is equal to or greater than 110% << Modify the toner refreshment amount in SP. >> Refer to TSB-037: Toner Scatter - Developer Removal Procedure ".
Condition 2
A4/LT converted
8-601
#DIV/0!
A4/LT converted: Average
(A) is equal to or greater than 150%, or (B) is equal to or smaller than 2.8% << Do the additional developer removal procedures.>> Refer to TSB-037: Toner Scatter - Developer Removal Procedure ".
8-921
2. Check the Vt value after replacing with a new developer. Check procedure:
Step 1) Check the SP values (Table 3 below) after replacing the developer. Step 2) Compare the results against the values described in "Condition 3 ". Input the SP values into the yellow cells
Condition 3
(C) is equal to or greater than the values described below. K: 8.5 C: 9.0 M: 9.5
Table 3
Control voltage of toner concentration 3-002 (Tc)
(C) Vtcnt(V)
01 K
02 C 03 M 04 Y