Professional Documents
Culture Documents
Codigos G y M de Fresa y Torno
Codigos G y M de Fresa y Torno
MANUFACURA AVANZADA
GRUPO
rapid traverse linear interpolation
FUNCION
clockwise circular interpolation counter clockwise circular interpolation Time dwell Select X-Y Plane Select X-Z Plane Select Y-Z Plane Imperial Units Metric Units Cancel cutter compensation Cutter compensation Left Cutter compensation Right cancel mirror imaging Mirror imaging Cancel datum shift Exact positioning on Exact positioning off Macro call Macro modal call Macro modal call cancel Canned cycle cancel
I,J,K = Centre of arc or R=radius I,J,K = Centre of arc or R=radius P Dwell time en miliseconds
Drilling/spot drilling cycle (X-Y Position of hole Z= depth R= retraction plane F= feed rate K=number of repeats) Drilling/counter boring cycle (X-Y Position of hole Z=depth R=Retraction plane F=Feedrate P=Dwell(miliseconds) K= number of repeats) Peck drilling cycle (X-Y=Position of hole, Z=depth, R=Retraction plane, F=Feedrate, Q=depth of each cut(incremental) K=number of repeats) Boring cycle (X-Y Position of hole, Z=depth, R=retraction plane, F=Feedrate, K=Number of repeats)
FUNCION
Programmed intermediate stop
FUNCION
Rapid traverse (Interpolacion lineal a maxima velocidad) Linear interpolation (Interpolacion lineal a velocidad controlada) Clockwise circular interpolation Interpolacion circular en sentido de las manecillas del reloj Counter clokwise circular interpolation Time Dwell (Temporarizacion) Imperial Units (Unidades del sistema Ingles) Metric Units (Unidades del sistema Metrico) Maximum spindle speed (Velocidad maxima de giro de la herramienta) Grooving cycle 1st line R= Peck Relief (radial) 2da Linea: X(U) Profundidad final Z(W)=Punto final en Z P=Peck(micrones en radio) Q=Movimiento en Z(Micrones) R=orilla de la profundidad en micrones F= Feedrate (Avance)
I,K=Centre of arc or R= Radius I,K=Centre of arc or R=radius (I,K= Centro del arco o R= radio) P=Dwell time (P= Tiempo en milisegundos)
THREADING CYCLE (subrutina de roscado) 1st line P=spring cuts:00:tool angle Q=min depth of cut (microns) R=depth of finishing cut 2nd line X=end depth of thread Z(W)=length of thread F=pitch P=Depth of thread (radius, microns) Q=first cut depth (microns) R=taper optional
10 1
Cancel canned cycle (fin de ciclo) Peck drilling cycle Z(W)=total depth Q=peck depth (microns) R=retraction point P=time dwell (miliseconds) Axial cutting cycle (X(U) end depth Z(W) end point R= taper amount in X) Radial cutting cycle Constant surface speed on (S= speed in meters per minute) Constant surface speed off (S= speed in revs per minute) Feed per minute Feed per spindle revolution
2 5
FUNCION
Programmed intermediate stop