Professional Documents
Culture Documents
Ecboostingtotalratethd: Set Ufrc
Ecboostingtotalratethd: Set Ufrc
MO Parameter ID Parameter Name NE MML Command Meaning UFRC EcBoostingTotalRateThd The total rate threshold of HSUPA traffic for Boosting BSC6900 SET UFRC Total data rate threshold for an E-DPCCH Boosting-enabled UE. If the selected E-TFCI of an E-DPCCH Boosting-enabled UE exceeds the ETFCIec,boosting specific to E-DPCCH Boosting, the UE sends uplink data using E-DPCCH Boosting. Note that this E-TFCIec,boosting is related to the E-TFCI corresponding to the maximum transport block that does not exceed this threshold. This parameter is an advanced parameter. To modify this parameter, contact Huawei Customer Service Center for technical support. NO NO WRFD-010697 E-DPCCH Boosting Interval Type
GUI Value Range 0~110 Enumeration Number/Bit Unit Actual Value Range Default Value Recommended Value Initial Value Source Impact Parameter Relationship Not involved 100kbit/s 0~11000 10 10 Radio Planning (Internal planning) RAB None
Access
No (And no impact on the UE in idle mode) Service Interrupted After Modification Interruption Scope N/A Interruption Duration(Min) Caution Validation of Modification Impact on Radio Network Performance N/A None The parameter modification has no impact on the equipment. If this parameter is set to a very large value, only a small number of UEs whose uplink data rate exceeds the value of "EcBoostingTotalRateThd" can use E-DPCCH Boosting. In addition, the resource utilization of EDPCCH Boosting is low and the cell throughput cannot greatly increase. If this parameter is set to a very small value, a large number of UEs preempt limited resources of E-DPCCH Boosting. For UEs without such resources, the uplink transmission performance deteriorates and as a result uplink cell capacity decreases. BSC6900 V900R013 Radio
ERACHMinPDUSizeforEUL2
MO Parameter ID Parameter Name NE MML Command Meaning IsKey Mandatory Feature ID Feature Name UFRC ERACHMinPDUSizeforEUL2 ERACH Min RLC PDU Size Under UL Layer 2 BSC6900 SET UFRC Minimum MAC-d PDU size when both ERACH and UL Layer 2 Improvement are activated. NO NO None None
Value Type
Interval Type
GUI Value Range 4~402 Enumeration Number/Bit Unit Actual Value Range Default Value Recommended Value Initial Value Source Impact Parameter Relationship Access Not involved byte 4~402 42 42 Radio Planning (Internal planning) RNC None Read & Write
No (And no impact on the UE in idle mode) Service Interrupted After Modification Interruption Scope N/A Interruption Duration(Min) Caution Validation of Modification Impact on Radio Network Performance Introduced in Version Attribute N/A None The parameter modification has no impact on the equipment. When the parameter value is too large, the RLC retransmission ratio increases if the packet loss rate over the Uu interface is high. When the parameter value is too small, the header overhead at the RLC layer increases. BSC6900 V900R013 Radio