Professional Documents
Culture Documents
Lilac UI
Lilac UI
Make Places
Screen setup
100ft deep
10ft gap
Lots are 10ft shorter than the square. Handles are in the middle of the sides.
Still 150ft
Modifier-click a handle and delete a side. When triangular, handles are on corners.
Still 150ft
Drag a triangular squares side out, and its the other two that change. (Need to give this more thought.)
Still 100ft
Modifier-click and drag a handle (up) into the lot, to curve the lot. Depth remains 100ft so sides curve.
Drag thinner. Below 2:1 ratio, end buildings disappear on the thinner end. (You can still bump another street up against the end to close off a side, if desired.)
Rotate
Change transect (somehow: shift click to cycle through? Or choose and paint transect?)
Dragging together
100ft
50%
50%
Connecting
Pick up T3 street
Cannot be dropped here: place overlaps lot, but only one corner connected
Can be dropped here: connection made. Moved lots shown behind destination lots. Round nodes indicate intersection. Arrow indicates dominant transect for corner lot.
Can be dropped here. Moved space reduced as its dragged under the destination space.
Place: Has four or three sides. May be rotated. Each side has a transect (T3 to T6). Each side may be curved out.
Lots: Slave to place side: cannot be independently moved, resized etc. Also get their transect from place side.
Brownfield Interaction
Existing building or planned civic building. Assigned transect colour to indicate approximate height / massing.
Approximate Goal
LILAC
Make Places