Professional Documents
Culture Documents
No. Object of Measurement Measuring Instrument Measuring Instructions Permissible Variation Measured Variation
No. Object of Measurement Measuring Instrument Measuring Instructions Permissible Variation Measured Variation
Object of measurement
figure
measuring instrument
steel wire max. 0.5 mm and gauges (set pins). Feeler gauge leveling telescopic
measuring instructions
permissible variation
measured variation
move cross- carriage 0.2 mm to to rear end of running 10 m length track. Carry the steel wire along the free part of the guide rall over the set pins and tension. Measure with set pins and feeler gauge at intervals of 1m. Then move cross carriage to the front end of running track. repeat measurement as before. Gauge length is at least twice the dead length of the machine
Spirit level with 0.1 mm/m scale interval, leveling instrument with coincidence bubble
Apply sprit level at intervals of 1 m along and across the rail surfaces. Attach prism block if necessary for prismatic rails move cross- carriage to rear end of running track. Carry the steel wire along the free part of the running rall over the set pins and tension. Measure with set pins and feeler gauge at intervals of 1m. Then move cross carriage to the front end of running track. Repeat measurement as before. Guage length is at least twice the dead length of the machine.
0.2 mm/m longitudinally but not more than 2 mm on running track lengths upto 50 m. 0.1 mm/m transversely For rails machined laterally 0.5 mm up to a length of 20 m. for rails not not machined laterally 3mm up to a length of 20 m.
steel wire max. 0.5 mm and gauges (set pins). Feeler gauge leveling telescopic
Spirit level with 0.1 mm/m scale interval, leveling instrument with coincidence bubble
Apply sprit level at intervals of 1 m along and across the rail surfaces. Attach prism block if necessary for prismatic rails
0.2 mm/m longitudinally and transversely but not more than 2 mmover total length of running track.
Horizontal position of guide rail and running rail in rotation to each other
hose level with Measure at the start 0.1 mm/m scale middle and end of interval, leveling the running track Instrument levelling telescope Steel measuring Measure at the start tape middle and end of the running track. The distance between the guide rail and running rail the track gauge shall be maintained according to the manufacturer's assembly plan.
No limitation, but running wheel shall be fully supported over the total length.
Steel measuring Travel torch height tape slides to highest and lowest position. Compare with dimensions on manufacturer's assembly plan. Steel measuring Move control device tape or cutting torch to Inner and outer position. Measure distance of travel and compare with manufacturer's machine assembly plan Steel measuring Move cross-carriage tape to forward and rear position. Measure distance of travel and compare with the manufacturer's machine assembly plan
working length
remarks
Figure
Object
Measuring instrument
Figure
Object
Measuring instrument
L 400 0.015
Verification of Parallelism of the table surface or of each pallet surface to : Its Movement on the saddle
630<L1000 0.04
If there are more than one pallet, readings shall be recorded for each pallet by giving number.
The stylus of the dial gauge is to be placed approximately at working position of the tool. The measurement may be made on a straight edge laid parallel to the table surface. If the spindle can be locked the dial gauge may be mounted on it. If spindle cannot be locked, the dial gauge shall be placed on the spindle cannot be locked, the dial gauge shall be placed on the spindle head slide. Y & Z axes to be locked, (if available)
1000<L>2000 0.06 L longer side of table or pallet NOTE : Error shall be flat to concave