Professional Documents
Culture Documents
Electrolysis Simulation
Electrolysis Simulation
Electrolysis Simulation
An electrolytic cell is a cell consisting of two electrodes (anode and cathode) immersed in an
electrolyte for carrying out electrolysis, a direct electric current is passed through the electrolyte
from an external source.
Molten salts and aqueous solution of ionic compounds are electrolyte commonly need in
electrolysis.
Anode is the electrode that connected to the positive terminal of the battery. At this electrode,
anions was release their electron.
Cathode is the electrode that connected to the negative terminal of the battery. At this electrode,
cation was received an electrons.
When more than one type of cation or anions is present in a solution, only one cation and anion
is preferentially selected for discharged. The selective discharge of ions depends on three factors.
b) The standard electrode potential of the ion (the position of the metal in the
electrochemical series)
1
Electrolysis is used for effluent treatment. Heavy metal ions from manufacturing process that are
found in effluent can be removed by electrolysis.
Spontaneous reaction is known as, if a reaction of its own accord when the reactants are mixed
at room temperature and pressure.
Non-spontaneous reaction is known as, if the reaction does not occur of its own accord at room
conditions.
ENGAGE
2
You are given the picture as shown below: Electric current was supply to the water.
EMPOWER
3
Steps
2. Electrolysis Cell is cell that use electric power through itself to produce chemistry
reaction.
7. Log on the web site to observe the animation to answer the question.
http://www.chem.iastate.edu/group/Greenbowe/sections/projectfolder/simDownload/inde
x4.html#electrochem
4
Results:
Electrolysis of Ni (NO3)2
5
Electrolysis of Fe(NO3)
Electrolysis of Cu (NO3)2
6
Electrolysis of Ag (NO3)2
Question
1. What the reaction at the anode and cathode in the process electrolysis of Nikel(II) Nitrate?
Answer:
2. Because the cation (Ni2+) was remove from the anode make the mass of electrode is reduce.
3. Because the cathode electrode was accepted the cation (Ni 2+).That make the mass off cathode
is increase.
7
ENHANCE
Figure 1
8
Activity 2
http://www.chem.iastate.edu/ChemEdGroup/GREENBOWE/sections/projectfolder/flashfiles/elec
troChem/electrolysis10.html
According to figure 1
a) Will nickel metal spontaneously react with aqueous nickel (II) nitrate?
b) Predict what will happen when the power is turned on?
c) Identify the metal used for each electrode?
d) Indicate the direction of the flow of electrons in the wire?
e) Indicate what will happen at each electrode?
f) Identify the anode and the cathode?
g) Write the halfreactions and fullreaction that will occur?
Figure 2
According to figure 2
a) Will nickel metal spontaneously react with aqueous iron (II) nitrate?
b) Indicate the direction of the flow of electrons in the wire?
c) Indicate what will happen at each electrode?
9
d) Identify the metal used for each electrode?
e) Identify the anode and the cathode?
f) Write the halfreactions and full reaction with the balanced chemical equation?
10