Professional Documents
Culture Documents
The Operational Amplifier
The Operational Amplifier
The Operational Amplifier
Summary of Results
90% Correct of 40 Score d ite m s:
36 C orre ct: 4 Incorre ct: 10% 90%
1.
Figure 12-1
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html 1/8
30/3/2014
2.
Refer to Figure 12-1(b). This amplifier is known as Your Answer: a non-inverting amplifier.
3.
Refer to Figure 12-1(c). This amplifier is known as Your Answer: an inverting amplifier.
4.
Refer to Figure 12-1(a). A dc voltage of 1.2 V is applied. VC C = 12 V. What is the output voltage? Your Answer: 1.2 V
5.
Refer to Figure 12-1(b). The voltage gain of this amplifier is Your Answer: 21.
6.
Refer to Figure 12-1(c). If an input signal of 0.5 V were applied, determine the output voltage. Your Answer: 5 V
7.
Refer to Figure 12-1(c). The input impedance of this circuit is Your Answer: 500 k Correct Answer: 50 k . .
8.
Refer to Figure 12-1(c). You need an amplifier with an input impedance of 12 k You must not change the amplifier voltage gain. The new value of Ri would be _____ and the new value of Rf would be _____. Your Answer: 12 k , 120 k
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
2/8
30/3/2014
9.
Refer to Figure 12-1(b). A dc input signal of 50 mV is applied. You would measure _____ from the inverting input to ground. Your Answer: 50 mV
10.
11.
12.
Refer to Figure 12-2. The purpose of R4 is Your Answer: for input offset voltage compensation.
13.
Refer to Figure 12-2. The purpose of R3 is Your Answer: for bias current compensation.
14.
Refer to Figure 12-2. If the value of R1 decreases, the voltage gain will _____ and the input impedance will _____. Your Answer: increase, decrease
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
3/8
30/3/2014
15.
A voltage-follower amplifier comes to you for service. You find the voltage gain to be 5.5 and the input impedance 22 k . The probable fault in this amplifier, if any, is Your Answer: none of these.
16.
An op-amp has an open-loop gain of 100,000 and a cutoff frequency of 40 Hz. Find the open-loop gain at a frequency of 30 Hz. Your Answer: 100,000
17.
An op-amp has an open-loop gain of 75,000 and a cutoff frequency of 100 Hz. At 1 kHz the open-loop gain is down by Your Answer: 20 dB.
18.
and C = 0.22
19.
20.
A certain op-amp has an open-loop voltage gain of 150,000. What is this gain expressed in dB? Your Answer: 103.5 dB
21.
The midrange open-loop gain of an op-amp is 135 dB. With negative feedback this gain is reduced to 72 dB. The closed-loop gain is Your Answer: 72 dB.
22.
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
30/3/2014
23.
Refer to Figure 12-3(b). Find the midrange gain of this op-amp amplifier. Your Answer: 11
24.
Refer to Figure 12-3(c). The midrange voltage gain of this amplifier is Your Answer: 1.
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
5/8
30/3/2014
25.
Refer to Figure 12-3(a). The op-amp has a unity-gain bandwidth of 3 MHz. Determine the BW of the circuit. Your Answer: 112.4 kHz
26.
Refer to Figure 12-3(b). The op-amp has a unity-gain bandwidth of 1.7 MHz. Find the bandwidth of the circuit. Your Answer: 155 kHz
27.
Refer to Figure 12-3(c). The unity-gain bandwidth of this op-amp is 10.4 kHz. What is the bandwidth of the circuit? Your Answer: 10.4 kHz
28.
29.
Refer to Figure 12-4(b). Calculate the bandwidth. Your Answer: 83.3 kHz
30.
Negative feedback added to an op-amp _____ the bandwidth and _____ the gain. Your Answer: increases, decreases
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
6/8
30/3/2014
31.
A practical op-amp has very _____ input impedance, very _____ output impedance, very _____ open-loop voltage gain, and a _____ bandwidth. Your Answer: high, low, high, wide
32.
The input offset voltage drift is a parameter directly related to VO S and _____. Your Answer: temperature
33.
The maximum rate of change of the output voltage in response to a step input voltage is the _____ of an op-amp. Your Answer: slew rate
34.
A(n) _____ amplifier configuration has a higher input impedance and a lower output impedance than the op-amp itself. Your Answer: non-inverting
35.
A(n) _____ amplifier configuration has an input impedance approximately equal to the input resistor Ri and an output impedance approximately equal to the output impedance of the op-amp itself. Your Answer: inverting
36.
The _____ amplifier configuration has the highest input impedance and the lowest output impedance of the three basic op-amp configurations. Your Answer: voltage-follower
37.
Open-loop voltage gain of an op-amp can range up to _____. Your Answer: 100,000 Correct Answer: 200,000
38.
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
7/8
30/3/2014
39.
A three-stage op-amp can have a maximum phase lag of _____. Your Answer: 90 Correct Answer: 270
40.
For operational amplifiers, noise level is normally shown in units of ________. Your Answer: Correct Answer:
Copyright 1995 - 2012 Pearson Education . A ll rights reserved. Pearson Prentice Hall is an imprint of Pearson . Legal Notice | Privacy Policy | Permissions
http://wps.prenhall.com/chet_floyd_electronic_9/198/50746/12991084.cw/index.html
8/8