Two-stage Ejecting Structure is a structure in which it is possible to carry out the ejection operation twice at the time. This is very convenient in cases where the molded item cannot be taken out of the mold with only one ejection action.
Two-stage Ejecting Structure is a structure in which it is possible to carry out the ejection operation twice at the time. This is very convenient in cases where the molded item cannot be taken out of the mold with only one ejection action.
Two-stage Ejecting Structure is a structure in which it is possible to carry out the ejection operation twice at the time. This is very convenient in cases where the molded item cannot be taken out of the mold with only one ejection action.
www.misumi-techcentral.com/tt/en/mold/2013/02/142-two-stage-ejecting-structure.html 1/2 Category : Structural Components February22, 2013 Plastic Molding Tutorial #142 Two-Stage Ejecting Structure The two-stage ejecting structure is a structure in which it is possible to carry out the ejecting operation twice at the time of ejecting the molded article from the core. Although ejection is done only once in the usual injection mold, since in the case of the two-stage ejecting structure it is possible inside the mold to carry out ejection two times with a time gap between them, this is a mechanism that is very convenient in cases in which the molded item cannot be taken out the mold with only one ejecting operation. For example, in the case of the stripper plate ejecting structure such as that shown in Fig. 1, since the shape of the molded item is engraved on the stripper plate, it becomes difficult for the molded item to fall freely. In view of this, if a two-stage ejecting structure as shown in Fig. 2 is used, it is easily possible to make the molded article fall freely. On the other hand, in the structure shown in Fig. 3, a technique has been used in which a runner ejecting plate is provided within the ejector plate thereby making only the runner to be ejected earlier than the molded item. This has the effects of improving the gate cutting ability of the tunnel gate and of reducing the cutting scrap. Cavity Cost Maintenance Metallic Materials Misumi Products Guide Mold Materials Mold Preparation Accuracy Molding Defect Countermeasures Molding Technology Molding materials Runner, Gate Standard Specifications Structural Components Technical Calculations Technical Information Technical Topics #142 Two-Stage Ejecting Structure #141 Ejecting Stripper Plate Structure #140 Maraging Steel #139 Strength Calculation of the Thickness of the Side Wall of a Cavity (In the case of a rectangular cavity with bottom surface parting) #138 PET Plastic more Low Cost Automation Surface Finishing Press Dies Plastic Molding 1. #071 Pneumatic Circuits and Control Technique Basics - 1: Basic Pneumatic Circuits 2. #028 Molding Shrinkage Ratios of Major Plastic Materials 3. #008 Method of Preparing Compound Die Structures 4. #008 Hydrogen embrittlement - Plating embrittlement HOME > Plastic Molding Tutorial > #142 Two-Stage Ejecting Structure 27.10.13 #142 Two-Stage Ejecting Structure | Technical Tutorial - MISUMI www.misumi-techcentral.com/tt/en/mold/2013/02/142-two-stage-ejecting-structure.html 2/2 PREV Apart from this, it is also possible to carry out two-stage ejection using other mechanisms. This will be a useful hint for solving problems when techniques have to be devised for the molded article ejection, runner, cutting of the gate, etc. About MISUMI Terms of Use This site is maintained by MISUMI Corporation. Unauthorized reproduction is prohibited by all applicable laws and is subject to criminal prosecution. Please visit your Regional MISUMI website for additional information or to request our latest catalog. Empowering engineers around the world with an extensive product line of over 1 million products. Plus the tools & tutorials based on 40 years of engineering knowledge. USA Deutsch English Franais Italiano esky India South East Asia MALAYSIA Copyright 2013 MISUMI Corporation All Rights Reserved.