Qi Charger Magnet Tests - TEST

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

<< All tests are measured from 20% to 90% battery amount.

>>

Test conditions are:
Wifi Off
Airplane Mode
AutoRotation Off
Location Off
NFC off
GPS off
Sync Off
Display Off
+ 2A Adapter
Original charger
with no magnets.
Using twelve 6 x 2mm magnets
with original rubber pad.
Using eight 5mm x 5mm x 2mm
(Magnet is fitted to rubber gutter,
and ~1mm above top qi plate)
Using eight 5mm x 5mm x 2mm
with NFC tag sticker.
Using eight 5mm x 5mm x 2mm
and four 6 x 2mm magnets
(because I had only 8 rectangluar
magnets)
Using eight 5mm x 5mm x 2mm
and four 6 x 2mm magnets
with NFC tag.
Using eight 5mm x 5mm x 2mm
and eight 6 x 2mm magnets.








WCP-405
input: 5V, 1.8A
Output: 5V, 1A
T1 (test #)
2 hours (charing time)
37.1 C (avg. temp.)
T3
2hours
37.9 C










Chinese Qi Charger
Input: 5V, 1.5A
Output: 5V, 0.5~1A
T4
2hours
38.7 C
T2
2h 42m
37.8 C

T5
2h 44m
38.3 C
T6
2 hours
38.1 C
T7
2h 6m
41 C
T9
2 hours
38.6 C
T10
2h 1m
42 C
T12
2h 3m
38.9 C
My Simple Conclusion
1. NFC tag attached
One or two degree temperature rise in airplane mode, but in normal use condition, this rise may be higher.

So I attached NFC tag to other place(driving wheel center).
2. Magnet influence
2.1
If magnets are close to Qi-charger coil part, charginng time increases. (T2, T3, T5)
In this area, more magnets may cause more heat and incresed chargin time.
2.2
If magnets are a little distant from coil part, number of magnets doesnt influence on charging time.
In my test cases, that distance may be qi-charger's rubber gutter position.
2.3
Very justly, more magnets, more attracting force. I have no method to measure that force quantitatively.
So prepare enough 2mm thick (square) magnets, and using a tape, increase magnet number and feel the force.
With your phones case or something, that satisfying force will be different. Number of magnets are up to your situaton.

I used totally sixteen(8 circle one + 8 square one) magnets. That is just from the fact I had only 8 square magnets.
So in one corner, 2 square plus 2 circlular magets are glued. But probably if you use only one type magnet( square? ), 12
magnets may be enuogh...
Like this.
2.4
Above magnets numbers are from the assumption that the phone is to be put onto my car mount system, which prohibits
vertical downward slip force.
In normal magnetic car mounting system, above discussion may be wrong.
AND above tests are done with chinese cheep(has no brand name) qi charger. Chargers electric characteristic and coil
size might influenced the results.

You might also like