Professional Documents
Culture Documents
Installation Manual - ADSS Suspension Set
Installation Manual - ADSS Suspension Set
,LIMITED
悬垂线夹的安装
4、 In the same way, finish winding the rest rods (leaving both
3、 According to the former step, wind the second structural ends of the rods relaxed)
reinforcing rod on the cable.
5、Finish winding both ends of the preformed rods with your 6、Set the aligning color mark as center , separate respectively two
hands, making sure that they are winded evenly and leveled. sets of the rubber nip blocks into two parts and strike them
outside the preformed rods and fix them with the rubber tape.
Right Installation
7、 Get an outer rod and align its center color Incorrect installation
mark with the center of rubber block (making
sure the surface of outer rod coincide with that of Do not wind the outer rod around the
rubber rod.). Wind the outer rod 2~3 circles on rubber set as picture shows.
the both sides of the rubber block.
12、Enchase the strap into the suspension from the 13、Connect the AGS Clamp to the connecting fittings and
bottom to up and strike it to the right position fasten up the bolt and the mouth-closed bolt.
with hands.
1.Choose the type of Suspension Set according to the specific situation such as the cable’s external
diameter , installation span and the turning angle of the line.
2.The suitable span shoud be longer than 200 meters.
3.Both of structural reinforcing rods and the outer rods of the suspension set must avoid the extrusion
4. The suspension set is a set fitting and rods and the preformed rods could not be used repeatedly.
5.In the process of winding the preformed rods, operate it with hand but not tool in the purpose of not
damaging the fiber optic cable.
6.If have any problems, please contact us.