Professional Documents
Culture Documents
FPH 800 Epd
FPH 800 Epd
Environmental Product
Declaration
Issue: 1 Issue date: June 2011
A25000-A0800-A071-01-76P1
1 (20)
The information in this document is subject to change without notice and describes only the
product defined in the introduction of this documentation. This documentation is intended for
the use of Nokia Siemens Networks customers only for the purposes of the agreement under
which the document is submitted, and no part of it may be used, reproduced, modified or
transmitted in any form or means without the prior written permission of Nokia Siemens
Networks. The documentation has been prepared to be used by professional and properly
trained personnel, and the customer assumes full responsibility when using it. Nokia Siemens
Networks welcomes customer comments as part of the process of continuous development
and improvement of the documentation.
The information or statements given in this documentation concerning the suitability, capacity,
or performance of the mentioned hardware or software products are given as is and all
liability arising in connection with such hardware or software products shall be defined
conclusively and finally in a separate agreement between Nokia Siemens Networks and the
customer. However, Nokia Siemens Networks has made all reasonable efforts to ensure that
the instructions contained in the document are adequate and free of material errors and
omissions. Nokia Siemens Networks will, if deemed necessary by Nokia Siemens Networks,
explain issues which may not be covered by the document.
Nokia Siemens Networks will correct errors in this documentation as soon as possible. IN NO
EVENT WILL NOKIA SIEMENS NETWORKS BE LIABLE FOR ERRORS IN THIS
DOCUMENTATION OR FOR ANY DAMAGES, INCLUDING BUT NOT LIMITED TO
SPECIAL, DIRECT, INDIRECT, INCIDENTAL OR CONSEQUENTIAL OR ANY LOSSES,
SUCH AS BUT NOT LIMITED TO LOSS OF PROFIT, REVENUE, BUSINESS
INTERRUPTION, BUSINESS OPPORTUNITY OR DATA,THAT MAY ARISE FROM THE
USE OF THIS DOCUMENT OR THE INFORMATION IN IT.
This documentation and the product it describes are considered protected by copyrights and
other intellectual property rights according to the applicable laws.
The wave logo is a trademark of Nokia Siemens Networks Oy. Nokia is a registered trademark
of Nokia Corporation. Siemens is a registered trademark of Siemens AG.
Other product names mentioned in this document may be trademarks of their respective
owners, and they are mentioned for identification purposes only.
Copyright Nokia Siemens Networks 2011. All rights reserved.
In addition to above, this document is also intended for the use of Nokia
Siemens Networks recycling service providers responsible for the endof-life treatment of the product. The foregoing disclaimer shall also be
applicable and binding on all such recycling service providers.
2 (20)
Contents
Contents
1
Introduction ............................................................................................5
3
3.1
3.2
3.3
3.4
4
4.1
4.2
4.3
4.3.1
4.3.2
4.3.3
4.3.4
4.3.5
4.4
4.5
5
5.1
5.2
3 (20)
Summary of changes
NSN NWS Product Management MWT
4 (20)
17.04.2011
Introduction
Introduction
The purpose of this document is to provide environmentally relevant
information of a specific Nokia Siemens Networks product.
This document shall not be interpreted as a specification, modification or
amendment to the specification, or additional or other warranty of any
kind. In case of discrepancy between this document and the Product
specification or terms and conditions of the valid supply agreement
between Nokia Siemens Networks and the customer, the supply
agreement and Product specification shall always prevail over this
document.
5 (20)
Product description
Type of the product
6 (20)
Product name
Product configuration
3
3.1
3.2
7 (20)
products over their entire life cycle. Life-cycle thinking is used throughout
the products phases from raw material extraction, manufacturing
operations, use phase and end-of-life practices as well as logistics.
Continuous activities on these fields assure to minimize the
environmental impacts of our products.
3.3
3.4
8 (20)
4
4.1
30
25
low/no traffic
22
Comment
low/no traffic
Comment
10
low/no traffic
Comment
9 (20)
4.2
Data
kW
0,025
hour
15 x 365 x 24 = 131400
Area
Electricity emission
factor (kg CO2/kWh)*
World
EU
Asia(ex. China)
China
USA
Latin America
0.502
0.341
0.728
0.788
0.573
0.197
*) Emission factors are taken from A WRI/WBCSD GHG Protocol Initiative calculation
tool (2007). More information can be found from www.ghgprotocol.org.
4.3
4.3.1
Materials
Nokia Siemens Networks Substance List
Nokia Siemens Networks has compiled a Substance List based on
regulatory requirements and reasonable facts. The Substance List
identifies substances in two categories:
10 (20)
4.3.2
11 (20)
(Hazardous Substance)
(Item)
(Metal Parts)
(Circuit Modules)
(Pb)
(Hg)
(Cd)
(Cr6+)
(PBB)
(PBDE)
,,
:
This table shows where these substances may be found in the supply chain of Nokia Siemens Networks
electronic information products, as of the date of sale of the enclosed product. Note that some of the
component types listed above may or may not be a part of the enclosed product.
SJ/T 11363-2006
Indicates that the concentration of the hazardous substance in all homogeneous materials in the parts is
below the relevant threshold of the SJ/T 11363-2006 standard.
SJ/T 11363-2006
Indicates that the concentration of the hazardous substance of at least one of all homogeneous
materials in the parts is above the relevant threshold of the SJ/T 11363-2006 standard.
X
The reason for marking with X is: There are not alternative technologies or parts available.
4.3.3
Product end-of-life
Nokia Siemens Networks hereby supplies information supporting
environmentally sound, safe and economical End-of-Life (EoL)
12 (20)
4.3.4
Amount (g)
% Of total weight
65
3.25%
1200.5
2.3
682.2
48
1998
60.09%
0.12%
34.14%
2.40%
100.00%
Amount (g)
Stainless steel
10
Aluminum alloys
Polycarbonate materials
Mixed electronics (including PWB and Mcompo components)
Total weight
27
0.5
114
152
% Of total weight
6.91%
17.76%
0.33%
75.00%
100.00%
Amount (g)
10
27
0.5
114
152
% Of total weight
6.91%
17.76%
0.33%
75.00%
100.00%
13 (20)
4.3.5
14 (20)
Yes
No
Batteries
Chlorofluorocarbons (CFC),
hydrochlorofluorocarbons (HCFC) or
hydrofluorocarbons (HFC), hydrocarbons (HC)
Application /
Location
Beryllium Oxide
Beryllium compounds
Pressure
Liquids
Gases
15 (20)
4.4
Data
g.
1571.9
1998
Recyclability rate
Percentage (%)
78,67%
4.5
Material
Average Weight
(g)
Material recyclability
Unit Package
Corrugated board
760
100%
Inner part
PE
250
100%
Antistatic bag
PE
50
100%
Material
Average Weight
(g)
Material recyclability
Unit Package
Corrugated board
100
100%
Inner part
PE
50
100%
Antistatic bag
PE
30
100%
16 (20)
DIN 6120-1 and DIN 6120-2 standards (Marking of packaging and packaging
materials for recycling purposes - Plastics packaging and packaging materials)
17 (20)
5
5.1
18 (20)
5.2
19 (20)
Take-back information
Nokia Siemens Networks customers can contract with Nokia Siemens
Networks for environmentally responsible end-of-life treatment of
obsolete equipment. The purpose is to recover the material and energy
content of the obsolete products and to ensure safe treatment of
substances that can cause harm to people or the environment, if
disposed of untreated. In a life-cycle perspective, EoL treatment can
compensate for some of the environmental impacts of the earlier stages
of the products life cycle.
Nokia Siemens Networks Equipment Take Back Solution provides Nokia
Siemens Networks customers with an end-to-end service that includes
the removal of end-of-life products from the customers' network and
ensures end-of-life treatment in an environmentally responsible way.
The Nokia Siemens Networks Equipment Take Back Solution is offered
in several modules representing end-to-end work flow of the process:
Removal
Collection
Recycling
Project Management
20 (20)