Sun Fire (TM) V490 2100, Specification: Processor

You might also like

Download as doc, pdf, or txt
Download as doc, pdf, or txt
You are on page 1of 6

Sun Fire[tm] V490 2100, Specification

Processor
Number

Up to two dual-processor CPU/Memory Boards (2 or 4 CPUs)

Architecture

2.1GHz UltraSPARC IV+

Cache memory

Cache (L1): 64-KB data and 32-KB instruction per pipeline


Secondary (L2): 16 MB external (8 MB per pipeline), 2 MB on
chip L2 cache
Cache (L3): 32 MB external off-chip (UltraSPARC IV+
processor)

Main Memory
8 memory slots (DIMMs) per processor, 16 total slots per
CPU/Memory Board
Capacities

512MB, 1GB, or 2GB expansion (32GB maximum per


CPU/Memory board, 64GB maximum when configured with 4
processors)
All memory DIMM slots must be fully populated.

Standard Interfaces
Ethernet

Two 10/100/1000-Mbps Ethernet

Keyboard and mouse

USB

PCI

Six PCI slots compliant with PCI specification Revision 2.1:


Two slots (slots 0 & 1) operating at 66-MHz, 64 bits wide,
3.3 volts
Four slots operating at 33-MHz, 64 bits wide, 5 volts
Note: PCI slots 0, 1, and 2 are full length card slots (12 inch); PCI
slots 3, 4, and 5 are short length card slots (7 inch).

Remote System Controller

One ALOM Plus card plugs into a dedicated slot on the system I/O
board

Serial

One RJ45 serial port

USB

Two (compliant with USB Revision 1.1)

Internal Mass Storage


Disks

Two front-accessible, hot-pluggable, FC-AL disks, 146GB, 3.5-in.

x 1.0-in. 15,000 RPM, maximum total capacity of 292 GB


DVD-ROM

8X Slimline DVD-ROM / 24X CD-ROM drive

Sun Fire[tm] V490, RoHS:YL Server:


Hardware Specifications
Processor
Number

Up to two dual-processor CPU/Memory Boards (2 or 4 CPUs)

Architecture

1.35GHz UltraSPARC[tm] IV, 1.5GHz, or 1.8GHZ UltraSPARC


IV+

Cache memory

Cache (L1): 64-KB data and 32-KB instruction per pipeline


Secondary (L2): 16 MB external (8 MB per pipeline), 2 MB on
chip L2 cache
Cache (L3): 32 MB external off-chip (UltraSPARC IV+
processor)

Main Memory
8 memory slots (DIMMs) per processor, 16 total slots per
CPU/Memory Board
Capacities

512MB, 1GB, or 2GB expansion (32GB maximum per


CPU/Memory board, 64GB maximum when configured with 4
processors)
All memory DIMM slots must be fully populated.

Standard Interfaces
Ethernet

Two 10/100/1000-Mbps Ethernet

Keyboard and mouse

USB

PCI

Six PCI slots compliant with PCI specification Revision 2.1:


Two slots (slots 0 & 1) operating at 66-MHz, 64 bits wide,
3.3 volts
Four slots operating at 33-MHz, 64 bits wide, 5 volts
Note: PCI slots 0, 1, and 2 are full length card slots (12 inch); PCI

slots 3, 4, and 5 are short length card slots (7 inch).


Remote System Controller

One ALOM Plus card plugs into a dedicated slot on the system I/O
board

Serial

One RJ45 serial port

USB

Two (compliant with USB Revision 1.1)

Internal Mass Storage


Disks

Two front-accessible, hot-pluggable, FC-AL disks, 73GB or


146GB, 3.5-in. x 1.0-in. 10,000 RPM, or 146GB 15,000 RPM,
maximum total capacity of 292 GB

DVD-ROM

8X Slimline DVD-ROM / 24X CD-ROM drive

Power Supplies
Type

One required, two for redundancy fitted as standard, each with


independent power cord

Output

1448 W per power supply

RoHS Compliance Definition


The definition and aim of the RoHS directive is quite simple. The RoHS directive aims to restrict
certain dangerous substances commonly used in electronic and electronic equipment. Any RoHS
compliant component is tested for the presence of Lead (Pb), Cadmium (Cd), Mercury (Hg),
Hexavalent chromium (Hex-Cr), Polybrominated biphenyls (PBB), and Polybrominated diphenyl
ethers (PBDE). For Cadmium and Hexavalent chromium, there must be less than 0.01% of the
substance by weight at raw homogeneous materials level. For Lead, PBB, and PBDE, there must
be no more than 0.1% of the material, when calculated by weight at raw homogeneous materials.
Any RoHS compliant component must have 100 ppm or less of mercury and the mercury must
not have been intentionally added to the component. In the EU, some military and medical
equipment are exempt from RoHS compliance.
What does the 'Y' and 'YL' mean?

Y and YL are two of the possible Hazard Class Codes that Sun is using to help manage our parts
and systems. You may also see N, Z and 'blank' being used.

Y - Based on present information and belief, this equipment/part number complies with the
European Union RoHS Directive, 2002/95/EC, and amending and guidance documents, and does
not contain any restricted substances above the homogeneous materials' maximum concentration
values, except for selected exemptions allowed by law (EXCLUDING the exemption for lead in
solders for servers, storage and storage array systems, network infrastructure equipment for
switching, signaling, transmission as well as network management for telecommunications).
YL - Based on present information and belief, this equipment/part number complies with the
European Union RoHS Directive, 2002/95/EC, and amending and guidance documents, and does
not contain any restricted substances above the homogeneous materials' maximum concentration
values, except for selected exemptions allowed by law (INCLUDING the exemption for lead in
solders for servers, storage and storage array systems, network infrastructure equipment for
switching, signaling, transmission as well as network management for telecommunications).
N - Based on present information and belief, this equipment/part number does not comply with
the European Union RoHS Directive, 2002/95/EC, and may contain restricted substances above
the homogeneous materials' maximum concentration values.
Z - Based on present information and belief, the European Union RoHS Directive, 2002/95/EC,
does not apply to this equipment/part number.
blank - The applicability of the European Union RoHS Directive, 2002/95/EC, to this equipment
is presently unknown; this equipment/part number may contain restricted substances above the
homogeneous materials' maximum concentration values.
SUN DEFINITIONS:
RoHS-5 and RoHS-6 are used by Sun and are defined by Sun as:

RoHS-6 equals the Y definition


RoHS-5 equals the YL definition
http://www.shrubbery.net/~heas/sun-feh-2_1/Systems/SunFireV480/spec.html

Sun Fire[tm] V480 Server: Hardware


Specifications

Processor
Number
Architecture

Cache memory

Up to two dual-processor CPU/Memory Boards (2 or 4 CPUs)

900-MHz UltraSPARC III Cu


64-KB data and 32-KB instruction
Secondary: 8-MB external

Main Memory

Capacities

8 memory slots (DIMMs) per processor, 16 total slots per CPU/Memory


Board
256-MB, 512-MB, or 1-GB expansion (32 GB maximum)

Standard Interfaces
Ethernet

Two 10/100/1000BASE-T twisted-pair ethernet ports (RJ-45)

FC-AL

One Fibre Channel Arbitrated Loop (FC-AL) high-speed serial data


connector (HSSDC)

Keyboard and
mouse

USB (uses one of the two standard USB (Type A) port)

Six PCI slots compliant with PCI specification Revision 2.1:

PCI

Remote System
Controller

Two slots operating at 66-MHz, 64 bits wide, 3.3 volts (full


length slots)
One slot operating at 33-MHz, 64 bits wide, 5 volts (fulllength slot)
Three slots operating at 33-MHz, 64 bits wide, 5 volts (short
slot)

One RSC card plugs into a dedicated slot on the system I/O board
which includes integrated modem, serial and Ethernet interfaces.

One 56 Kbps modem port (RJ-11)


One EIA-232D serial port (RJ-45)

One 10 Mbps Ethernet port (RJ-45)

Serial

One RJ45 serial port

USB

Two standard Universal Serial Bus (USB) Type A connectors

Internal Mass Storage


Disks

Two front-accessible, hot-swappable, FC-AL disks, 36-GB and 73GB, 3.5-in. x 1.0-in. 10,000 RPM

DVD-ROM

8x DVD-ROM (IDE) drive

Power Supplies
Type

One required, two for N+1 redundancy, each with independent


power cord

Output

560 W per power supply

Environment

You might also like