Professional Documents
Culture Documents
SKF 30306 Housing and Shaft Tolerances
SKF 30306 Housing and Shaft Tolerances
SKF General Conditions for technical assistance and advice (available at www.skf.com) shall apply to this report.
SKF accepts no variation of any of these conditions unless confirmed in writing by SKF.
SKF is a registered trademark of the SKF Group.
SKF Group 2013
The contents of this publication are the copyright of SKF and may not be reproduced, duplicated, copied, transferred, distributed, stored, modified, downloaded or otherwise exploited for any
commercial use without the prior written approval of SKF.
30.0 mm
72.0 mm
20.75 mm
56.1 kN
56 kN
1.1
Note: The drawing displayed is only for general representation and may not be identical to the selected bearing
variant.
Input Parameters
Guidance required to select the fits?
true
15 kN
6 kN
r
Radial load
a
Axial load
Operating conditions
false
Result
P
Equivalent dynamic bearing load
17.4 kN
Shaft tolerances:
Bearing bore tolerance class
Normal CL7C
+0.0 m / -12.0 m
h6
+0.0 m / -13.0 m
+2.0 m
+5.0 m
1
Diametrical smoothing value for bearing
bore
2
Diametrical smoothing value for shaft
outside diameter
Shaft fits
Maximum
interference (-)/ clearance (+)
Mean
Minimum
-12 m
0 m
+13 m
-8 m
0 m
+9 m
-5 m
+8 m
+20 m
+8 m
+16 m
Housing tolerances:
Bearing outer dia. tolerance class
Normal CL7C
+0.0 m / -16.0 m
P7
-21.0 m / -51.0 m
+2.0 m
+12.0 m
1
Diametrical smoothing value for bearing
outside diameter
2
Diametrical smoothing value for housing
bore diameter
Housing fits
Maximum
interference (-)/ clearance (+)
Mean
Minimum
-51 m
-28 m
-5 m
-45 m
-28 m
-11 m
-37 m
-14 m
+9 m
-31 m
-14 m
+3 m