Professional Documents
Culture Documents
Winch Brake Holding Capacity Test
Winch Brake Holding Capacity Test
65
Vessel:
Coral Energy
Test Date:
M5-A
255
315
375
435mm
60mm
360kN
64mm
or
36.7 t
or
or
or
58.9 t
35.4 t
37.0 t
Line pull
450mm
Rope on the winch drum - diameter
MBL of the rope
60 % of MBL of the rope
Designed winch brake holding capacity for this rope
1350mm
Applied force :
or :
12.1 t
119kN
363kN
or
37.0 t
Note: Vessels with undivided winch drums should calculate the winch brake holding capacity for the usual number of layers on the drum.
The Mooring Equipment Guidelines chapter 7.4.6 describes that if the brake of an undivided drum is set to hold 80% MBL on
the first layer, it will hold approximately 65% on the third layer.
or
35.1 t or 60%
This value is to be used in case the winch is equipped with a tension drum
or
28.4 t or 48%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are only 2 layers on the drum
or
23.9 t or 41%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are 3 layers on the drum
or
20.6 t or 35%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are 4 layers on the drum
Issue 2011/B
60mm
578kN
347kN
363kN
12.1 t
12.1 t
the brake should be tightened or repaired and the jack pressure reapplied.
the brake setting should be adjusted so the brake can render.
65
Vessel:
Coral Energy
Test Date:
M5-B
255
315
375
435mm
60mm
360kN
64mm
or
36.7 t
or
or
or
58.9 t
35.4 t
37.0 t
Line pull
450mm
Rope on the winch drum - diameter
MBL of the rope
60 % of MBL of the rope
Designed winch brake holding capacity for this rope
1350mm
Applied force :
or :
12.1 t
119kN
363kN
or
37.0 t
Note: Vessels with undivided winch drums should calculate the winch brake holding capacity for the usual number of layers on the drum.
The Mooring Equipment Guidelines chapter 7.4.6 describes that if the brake of an undivided drum is set to hold 80% MBL on
the first layer, it will hold approximately 65% on the third layer.
or
35.1 t or 60%
This value is to be used in case the winch is equipped with a tension drum
or
28.4 t or 48%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are only 2 layers on the drum
or
23.9 t or 41%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are 3 layers on the drum
or
20.6 t or 35%
This value is to be used in case the winch is NOT equipped with a tension drum
AND there are 4 layers on the drum
Issue 2011/B
60mm
578kN
347kN
363kN
12.1 t
12.1 t
the brake should be tightened or repaired and the jack pressure reapplied.
the brake setting should be adjusted so the brake can render.