Professional Documents
Culture Documents
P.E.S. College of Engineering, Mandya - 571 401
P.E.S. College of Engineering, Mandya - 571 401
P08ME46
U.S.N
Note: Answer any FIVE full questions, selecting at least TWO full questions from each part.
PART - A
1. a. With a neat sketch discuss about single point cutting tool nomenclature.
b. A seamless tube is turned orthogonally on a lathe. Other data given are : - outside diameter of
the tube = 20 mm, Rake angle = 20, Speed = 300 rpm, Feed = 0.11 mm/rev, Cutting force ;
185 N, Feed Force = 75 N, Length of the chip after one revolution = 33.35 mm. Determine;
(i) Co-efficient of friction
12
10
b. In machining a mild steel work piece with carbide tool the Life of the tool was one hour and
twenty minutes at 40 mpm. Determine the tool life if it were to operate at a speed of 30%
higher than initial cutting speed. However when CBN tool was used to machine mild steel
10
work piece at 55 mpm tool life was same (one hour twenty minutes). Calculate the tool life
when speed is 20% lesser than the initial speed. Assume Taylors exponent n = 0.28.
3 a. Explain the desirable properties of cutting tool materials.
10
10
10
b. Explain tool layout for hexagonal headed bolt in a capstan and turret lathes.
10
PART - B
5 a. Differentiate between shaper and planer.
10
Page No... 2
P08ME46
6. a Sketch and explain Bench or sensitive drilling machine.
b. Show drill bit nomenclature with the help of a neat sketch.
10
5
c. A 10 mm hole is to be drilled through 25 mm thick plate. The cutting speed is 10 m/min and
the feed rate is 0.12 mm/rev. Estimate the machining time where over travel plus clearance
10
10
8
4
(ii) Honing.
****