Professional Documents
Culture Documents
Quetion Bank Ecom Week Wise
Quetion Bank Ecom Week Wise
Week 1:
1 Explain need of modulation
2 Draw and explain block diagram of communication system
3 Define amplitude Modulation
4 Define Modulation index and percent modulation for an AM wave.
5 Advantages and disadvantages of analog and digital communication system
Week 2:
1 Explain series tuned circuit
2 Explain parallel tuned circuit
3 A coil has a series resistance of 5, a self capacitance of 7 pF, and an inductance of 1H.
Determine the effective inductance and effective Q-factor when coil forms part of series tuned
circuits resonant at 25MHz.
4 derive equation for Resonance frequency and Q-factor for the parallel tuned circuits.
5 Explain channel effect in detail with their resources. Also explain nyquist information rate and
channel capacity in detail
Week 3
1 The carrier amplitude after amplitude modulation varies between 4V and 1V. Calculate depth
of modulation.
2 A carrier current is 8A but it is increase to 8.93A when it is modulated Find,
(A) percentage modulation Index
(B) Antenna current when modulation index changes To 0.8
3 Explain Amplitude Modulation with required waveforms. Also give mathematical
representation of Amplitude modulated Wave.
4 Explain Frequency Modulation with required waveforms. Also give mathematical
representation of frequency modulated Wave.
5 State Carson rule.
Week 4
1 Define Single sideband suppressed carrier AM.
2 Explain DSB FC system
3 What are the disadvantages of conventional (or) double side band full carrier
system?
4 Define frequency deviation and deviation ration
5 Explain A FM voltage is represented by v=12sin(6 x 108 t + 5cos 1250t) Find Carrier
Frequency, Modulating Frequency, Modulation Index, Maximum Deviation, Power dissipation
across 10.
Week 5
1 What are the complexity remains in SSB ? List the methods of generation of SSB signal and
explain any two of them.
2 Explain High level and low level modulation
3 Draw the circuit diagram of Foster seely discriminator and explain its working.
4 Explain in detail about AM detector.
5 List all the basic FM demodulators, Draw and explain ratio discriminator in detail.
Week 6
1 Explain Armstrong method of FM generation with neat diagram
2 Derive the expression for AM wave. AM modulating signal 8sin (2 x 900t) is used to
modulate a carrier signal 18 sin (2 x 15000t). Find modulation index, percentage modulation,
frequencies of sideband components and their amplitude. Draw the spectrum of AM wave.
3 Draw and discuss schematic diagram for FDM system to combine 4 voice channels
each occupies a bandwidth of 6KHz. The common voice channel has a bandwidth of
24 KHz. (Band- 200 to 224 KHz).
4 Discuss the indirect method of generating the FM.
Week 9
1 What is Signal to Noise ratio ? Derived equation for Signal to noise
ratio for amplifier
2 Discuss the following:
(i) Energy spectral density
(ii) Power spectral density
(iii) Essential bandwidth of a signal
3 Two resistors 10 k and 25 k are at room temperature (290K) for a
bandwidth of 150kHz.Calculate thermal noise for each resistor, if two resistors
are in series and if two resistors are in parallel.
4 Describe briefly shot noise, partition noise and flicker noise. Why they are
generated?
5 For the periodic signal shown in fig. 1. Find compact trigonometric fourier series and
sketch amplitude spectra.