Professional Documents
Culture Documents
Wonder Twin Necklace
Wonder Twin Necklace
Wonder-Twin
rings necklace
Use the new Twin beads
to stitch up versatile
ring components for
an elegant necklace
designed by Traci Otte
2012 Kalmbach Publishing Co. This material may not be reproduced in any form
without permission from the publisher.
materials
crystal
Make this under 1 hour
bracelet in
110
Issue
August 2012
We help you
choose
p. 13
resource
Braceleta!
bonanz
r look with
Liven up youcelet styles
9 great bra
c cuff
Stitch a classi
with Tila beads
shapes
Make great stitch
with brick
bezels
Make rivoli
with filigree
gemstone
Highlight a pearls
cab with
customize
3 ways to gs to
metal ndin
r project
match you
Thread or
beading wire?
lete beading
Your comp
it quite like
Nobody does
lead to
i! Follow her
Sherry Seran l bracelet, p. 36.
playfu
make this
$5.95
US
PLneck
lace
ky summer
t
Braid a chun lry with movemen
Design jewe ns: real or fake?
Vintage butto
6766
71896 4
com
AndButton.
www.Bead
stepbystep
Ring components
[1] On 1 yd. (.9 m) of Fireline, pick up
a repeating pattern of a color A Twin
bead and a color B Twin bead until
you have a total of 40 beads. Leaving
a 4-in. (10 cm) tail, tie the beads into
a ring with a square knot (Online
Beading Basics), leaving a little slack
between the beads. Sew through the
first few beads to exit an A, pull the
knot into the beads, and trim the tail.
[2] Sew back through the other hole of
the A your thread just exited (photo a).
[3] Pick up a B, and sew through the
remaining hole of the next A (photo b).
Repeat this stitch around the ring, and
Ring
diameter
in. (19 mm)
20
34
24
78
28
32
40
DESIGNERS NOTE:
You can also use the ring components in a
bracelet or earrings. For earrings, simply make
a ring beginning with at least 20 Twin beads, and
attach an earring finding with a loop of beads.
For a bracelet, the trickiest part is figuring
out how many rings of what sizes youll need.
See the Ring components sizes chart, p. 2,
to determine how many rings youll need to
make a bracelet to fit your wrist. Keep in mind
that each bridge adds about 316 in. (5 mm), and
dont forget to add in the length of your clasp.
If desired, add drop beads along the outer
edge of the rings: Exit one hole of a Twin bead,
pick up a drop, and sew through the opposite
hole of the next Twin bead. Repeat around,
adding drops in a zigzagging pattern around
the perimeter of the ring.
Assembly
[1] With the thread exiting an A in
the largest component, make a bridge:
Pick up a 150, an A, and a 150, and
sew through the A in the component
again (photo h). Retrace the thread
path through the connection at least
twice to secure.
[2] Sew through the outer edge beads