Professional Documents
Culture Documents
Esterification Reactions
Esterification Reactions
Background
Carboxylic acids are structurally like aldehydes and ketones in that they contain the
carbonyl group. However, an important difference is that carboxylic acids contain a
hydroxyl group attached to the carbonyl carbon.
O
C
OH
This combination gives the group its most important characteristic; it behaves as an acid.
As a family, carboxylic acids are weak acids that ionize only slightly in water. As
aqueous solutions, typical carboxylic acids ionize to the extent of only one percent or less.
O
R
O
OH + H2O
O + H3O+
COOH + NaOH
Benzoic acid
Sodium benzoate
Insoluble
Soluble
Sodium carbonate, Na2CO3, and sodium bicarbonate, NaHCO3, solutions can neutralize
carboxylic acids also.
Harcourt, Inc.
Experiment 32
337
CH3CH2CH2C OH + CH3CH2OH
Butyric acid
Ethyl alcohol
Esterification
Hydrolysis
The reaction typically gives 60% to 70% of the maximum yield. The reaction is a reversible
process. An ester reacting with water, giving the carboxylic acid and alcohol, is called
hydrolysis; it is acid catalyzed. The base-promoted decomposition of esters yields an
alcohol and a salt of the carboxylic acid; this process is called saponification.
Saponification means soap making, and the sodium salt of a fatty acid (e.g., sodium
stearate) is a soap.
O
CH3CH2CH2C
O
OCH2CH3 + NaOH
CH3CH2CH2C
O Na+ + CH3CH2OH
Saponification
Objectives
1. To study the physical and chemical properties of carboxylic acids: solubility,
acidity, aroma.
2. To prepare a variety of esters and note their odors.
3. To demonstrate saponification.
338
Experiment 32
Harcourt, Inc.
Procedure
Carboxylic Acids and Their Salts
Characteristics of acetic acid
1. Place into a clean, dry test tube (100 13 mm) 2 mL of water and 10 drops of glacial
acetic acid. Note its odor by wafting (moving your hand quickly over the open end of the
test tube) the vapors toward your nose. Of what does it remind you?
2. Take a glass rod and dip it into the solution. Using wide-range indicator paper
(pH 112), test the pH of the solution by touching the paper with the wet glass rod.
Determine the value of the pH by comparing the color of the paper with the chart on
the dispenser.
3. Now, add 2 mL of 2 M NaOH to the solution. Cork the test tube and sharply tap it with
your finger. Remove the cork and determine the pH of the solution as before; if not
basic, continue to add more base (dropwise) until the solution is basic. Note the odor
and compare to the odor of the solution before the addition of base.
4. By dropwise addition of 3 M HCl, carefully reacidify the solution from step no. 3
(above); test the solution as before with pH paper until the solution tests acid. Does the
original odor return?
Characteristics of benzoic acid
1. Your instructor will weigh out 0.1 g of benzoic acid for sample size comparison. With
your microspatula, take some sample equivalent to the preweighed sample (an exact
quantity is not important here). Add the solid to a test tube (100 13 mm) along with
2 mL of water. Is there any odor? Mix the solution by sharply tapping the test tube with
your finger. How soluble is the benzoic acid?
2. Now add 1 mL of 2 M NaOH to the solution from step no. 1 (above), cork, and mix by
sharply tapping the test tube with your finger. What happens to the solid benzoic acid?
Is there any odor?
3. By dropwise addition of 3 M HCl, carefully reacidify the solution from step no. 2
(above); test as before with pH paper until acidic. As the solution becomes acidic, what
do you observe?
Esterification
1. Into five clean, dry test tubes (100 13 mm), add 10 drops of liquid carboxylic acid or
0.1 g of solid carboxylic acid and 10 drops of alcohol according to the scheme in Table
32.1. Note the odor of each reactant.
Harcourt, Inc.
Experiment 32
339
Table 32.1
Carboxylic Acid
1
2
3
4
5
Formic
Acetic
Acetic
Acetic
Salicylic
Alcohol
Isobutyl
Benzyl
Isopentyl
Ethyl
Methyl
2. Add 5 drops of concentrated sulfuric acid to each test tube and mix the contents
thoroughly by sharply tapping the test tube with your finger.
CAUTION!
Sulfuric acid causes severe burns. Flush any spill with lots of water. Use gloves with this
reagent.
3. Place the test tubes in a warm water bath at 60C for 15 min. Remove the test tubes
from the water bath, cool, and add 2 mL of water to each. Note that there is a layer on
top of the water in each test tube. With a Pasteur pipet, take a few drops from this top
layer and place on a watch glass. Note the odor. Match the ester from each test tube
with one of the following odors: banana, peach, raspberry, nail polish remover,
wintergreen.
Saponification
This part of the experiment can be done while the esterification reactions are being
heated.
1. Place into a test tube (150 18 mm) 10 drops of methyl salicylate and 5 mL of
6 M NaOH. Heat the contents in a boiling water bath for 30 min. Record on the Report
Sheet what has happened to the ester layer (1).
2. Cool the test tube to room temperature by placing it in an ice water bath. Determine
the odor of the solution and record your observation on the Report Sheet (2).
3. Carefully add 6 M HCl to the solution, 1 mL at a time, until the solution is acidic. After
each addition, mix the contents and test the solution with litmus. When the solution is
acidic, what do you observe? What is the name of the compound formed? Answer these
questions on the Report Sheet (3).
340
Experiment 32
Harcourt, Inc.
Harcourt, Inc.
Experiment 32
341