Professional Documents
Culture Documents
Quick Reference Guide PPM-350C English
Quick Reference Guide PPM-350C English
Recalling Data
OLT ID
OLT Mode
Deleting Data
PPM-350C
ONT ID
Loc. ID
5
6
1
Select data to
delete
Optical
signal
OLT port
Job Mode
1
2
Test jumper
Note: Press
Inspect the fibers and clean them properly if necessary, then connect as shown.
Press
to turn
unit on.
2
5
Select appropriate
wavelength.
If necessary, switch
the units to dB.
Note: Press
to exit the recall
mode at any time.
Threshold set
number
Test jumper
Test jumper
ONT port
If necessary,
press and hold
to select the
FTTx mode.
3
4
OLT ID
OLT Mode
Inspect the fibers and clean them properly if necessary, then connect as shown.
ONT
(premises side)
Storing Data
OLT
(CO side)
OLT port
ONT ID
Loc. ID
Threshold set
name
Press to enter
the threshold
selection menu.
If desired, display the Pass/Warning/Fail values associated with the current threshold set.
Note: You must return to threshold selection menu to select a threshold set.
Signals
(wavelengths)
Status (according to
current threshold set)
Signal (wavelength)
Limit values
Hold down
Threshold
a few
seconds.
4b
4a
7
Press
to return
4c Press
to threshold
selection menu.
to turn
unit on.
If necessary, press
and hold to select
the FTTx mode.
2
3
Note: Press
to exit the
storage mode at any
time.
4
Power levels
Job Mode
LEDs
: Pass
1
2
: Warning
: Fail
OR
Press
to exit the threshold
selection menu without
selecting a new threshold set.
Note: You must install FastReporter on your computer and use the Handheld Data Transfer application to define
new thresholds. For more information on threshold definition, refer to the Handheld Data Transfer online help.
Job ID
number
Job name