Professional Documents
Culture Documents
Ump Pd3v100 English
Ump Pd3v100 English
Umix 44
4-In / 4-Out Recording USB Expansion card with S/PDIF & MIDI I/O for Umix 8.
Umix 66
6-In / 6-Out Recording USB Expansion card with S/PDIF & MIDI I/O for Umix 12.
Umix 1008
10-In / 8-Out Recording USB Expansion card with S/PDIF & MIDI I/O for Umix 16.
N16549
Series
WARNING: To reduce the risk of fire or electric shock, do not expose this unit to rain or moisture
Introduction
What's in the package
Features
Umix 44
Umix 66
Umix 1008
2
3
4
5-10
5
5-6
7
7-8
8
9
9-10
10
2-4
11
Connection
11
12-13
14
15-17
18-21
Hardware Connections
22-23
24
Specifications
24
Services
25
Series
Installation
Introduction
Series
Thank you for purchasing the ICON Umix series recording USB expansion card.
We sincerely trust this product will provide years of satisfactory service, but if
anything is not to your complete satisfaction, we will endeavor to make things
right.
In these pages, you'll find a detailed description of the features of the Umix
series recording USB expansion card, as well as a guided tour through their
front and rear panels, step-by-step instructions for their setup and use, and full
specifications.
You'll also find a warranty card enclosed---please don't forget to fill it out and
mail it so that you can receive online technical support at: www.iconglobal.com. And so we can send you updated information about these and
other ICON products in the future. As with most electronic devices, we strongly
recommend you retain the original packaging. In the unlikely event the product
must be returned for servicing, the original packaging (or reasonable
equivalent) is required.
With proper care and adequate air circulation, your Umix series recording USB
expansion card will operate without any trouble for many years. We recommend
that you record your serial number in the space provided below for future
reference.
Please write your serial number here for future reference:
Purchased at:
Date of purchase:
Features - Umix 44
Series
The ICON Umix 44 USB recording expansion card is the ultimate audio recording
solution for your Umix 8 mixing console. It turns your Umix 8 into an audio
recording station and its main features include:
24-Bit 96/192KHz 4-In/4-Out USB Recording Interface
2x2 analog I/O full duplex recording and playback
Dual MIC/Instrument preamps with individual gain control and phantom
power switch on Umix 8's Ch.1 & Ch.2
Input recording signal via Umix8's unique design EQ, Comp circuit
Input gain level adjust by the Umix8's Ch.1 and Ch.2 faders
2 analog outputs on Main Out L/R channels
The output level is adjusted by the Main Out L/R knob
1 headphone output with assignable source and individual volume control
S/PDIF I/O on RCA coaxial connectors
1 x 1 16 channel MIDI I/O
USB2.0 High Speed equipped and USB bus-powered
Supports DirectSound, WDM and ASIO2.0
Compatible with Mac OS (Intel-Mac) and Windows XP, Vista (32-bit/64-bit) &
Windows 7 (32-bit/64-bit)
Full duplex, simultaneous record/playback
Rugged aluminum construction (Umix8)
2
Series
Features - Umix 66
The ICON Umix 66 USB recording expansion card is the ultimate audio recording
solution for your Umix 12 mixing console. It turns your Umix 12 into an audio
recording station and its main features include:
24-Bit 96/192KHz 6-In/6-Out USB Recording Interface
4x4 analog I/O full duplex recording and playback
4xMIC/Instrument preamps with individual gain control and phantom power
switch on Umix12's Ch.1-4
Input recording signal via Umix12's unique design EQ, Comp circuit
Input gain level adjust by the Umix12's Ch.1-4 faders
4 analog outputs on Output 1/2 & Output 3/4 channels
The output level is adjusted by the Output 1/2 & Output 3/4 faders
2xheadphone output with assignable source and individual volume control
S/PDIF I/O on RCA coaxial connectors
1 x 1 16 channel MIDI I/O
USB2.0 High Speed equipped and USB bus-powered
Supports DirectSound, WDM and ASIO2.0
Compatible with Mac OS (Intel-Mac) and Windows XP, Vista (32-bit/64-bit) &
Windows 7 (32-bit/64-bit)
Full duplex, simultaneous record/playback
Rugged aluminum construction (Umix12)
3
Series
The ICON Umix 1008 USB recording expansion card is the ultimate audio
recording solution for your Umix 16 mixing console. It turns your Umix 16
into an audio recording station and its main features include:
24-Bit 96/192KHz 10-In/8-Out USB Recording Interface
8x6 analog I/O full duplex recording and playback
8xMIC/Instrument preamps with individual gain control and phantom power
switch on Umix16's Ch.1-8
Input recording signal via Umix16's unique design EQ, Comp circuit
Input gain level adjust by the Umix16's Ch.1-8 faders
6 analog outputs on Output 1/2, Output 3/4 & Output5/6 channels
The output level is adjusted by the Output 1/2, Output 3/4 & Output5/6
faders
2xheadphone output with assignable source and individual volume control
S/PDIF I/O on RCA coaxial connectors
1 x 1 16 channel MIDI I/O
USB2.0 High Speed equipped and USB bus-powered
Supports DirectSound, WDM and ASIO2.0
Compatible with Mac OS (Intel-Mac) and Windows XP, Vista (32-bit/64-bit) &
Windows 7 (32-bit/64-bit)
Full duplex, simultaneous record/playback
Rugged aluminum construction (Umix16)
Series
6
9
7
8
5
Series
Series
2
3
1
1. USB 2.0 Connector
Connect it with the provided USB cable to your Mac/PC's USB connector. Your
Mac/PC must have a USB2.0 connector in order to run the full speed of Umix 66.
2. S/PDIF coaxial I/O connectors
S/PDIF digital input and output on coaxial RCA connectors. The digital input is
selected via the Umix 66's software control panel, while the digital output will
be sent to the coaxial.
3. MIDI I/O connectors
MIDI input and output on standard 5-pin DIN connectors
Series
Series
2
3
1
1. USB 2.0 Connector
Connect it with the provided USB cable to your Mac/PC's USB connector. Your
Mac/PC must have a USB2.0 connector in order to run the full speed of Umix 1008.
2. S/PDIF coaxial I/O connectors
S/PDIF digital input and output on coaxial RCA connectors. The digital input is
selected via the Umix 1008's software control panel, while the digital output will
be sent to the coaxial.
3. MIDI I/O connectors
MIDI input and output on standard 5-pin DIN connectors
Series
Installation
Series
Installing the Umix USB audio recording expansion card into your Umix series
mixing console.
The Umix USB audio recording expansion cards have been designed for use with
the ICON Umix series mixing console.
Connection
1. You will find one FRC connector
attached to the back panel of the
expansion slot.
a)This is an 16-pin connector.
b)The 16-pin connector provides
both power & audio signal from the
mixing console to the audio
expansion card.
2. Plug the connector firmly into the
Umix audio expansion card connector
as shown.
3. Install the module back to your
mixing console and secure it with the
screws.
11
Diagram 1
Series
Diagram 2
3
Diagram 3
4
Diagram 4
5
Installation start
The driver installation has started,
please wait until the process has
completed.
Diagram 5
12
Series
Diagram 6
7
Umix 44
Diagram 7
8
Diagram 8
13
Diagram 9
Playback Mixer
Series
Playback Mixer
Monitor Mixer
1. Hardware inputs level metering
Umix 44 Ch 1/2 & S/PDIF input level metering
Umix 66 Ch 1/2, 3/4 & S/PDIF input level metering
Umix 1008 Ch 1/2, 3/4, 5/6, 7/8 & S/PDIF input level metering
Showing the input level for the hardware input channel.
2. Hardware outputs level metering
Umix 44 Ch 1/2 & S/PDIF output level metering
Umix 66 Ch 1/2, 3/4 & S/PDIF output level metering
Umix 1008 Ch 1/2, 3/4, 5/6, 7/8 & S/PDIF output level metering
Showing the output level for the hardware output channel.
Monitor Mixer
14
Series
Diagram 1
Diagram 2
4
License Agreement
Check mark the I accept the terms
in the License Agreement and
click Next.
Diagram 3
5
Diagram 4
15
Driver setup
Choose the location of the driver
and click "Next" as shown in
Diagram 5
Series
Diagram 5
Installation start
The installation process has started,
the process may take some time
depending on your computer
performance, please be patient and
wait for the process to finish.
Diagram 6
Diagram 7
Setup completed
A window as shown in Diagram 8
should appear. Choose "Next.
Diagram 8
16
Series
10
11
12
13
Diagram 12
Series
Diagram 2
Device settings
Shows the serial number & product ID of
your Umix 44/Umix 66/Umix 1008 device.
If it doesn't show, it means your device is
not properly installed. Please go through
the Driver Installation process again
(Page 15).
Diagram 3
Monitor Mixer
Click this button to launch the "Monitor
Mixer" (Page 19)
Playback Mixer
Click this button to launch the "Playback
Mixer" (Page 20)
S/PDIF Status and Pass Through
Showing the S/PDIF device signal status.
S/PDIF Pass Through
"Tick" the box if you want S/PDIF signal
pass through
Diagram 4
18
Monitor Mixer
Matrix Fader
Series
19
Link switch
Switch to adjust both channels level simultaneously.
Mute switch
Switch to mute the corresponding channel.
0dB switch
Switch to instantly adjust the corresponding channel to 0dB level.
10
Series
Playback Mixer
9
8
10
Matrix Fader
Link switch
Switch to adjust both channels level simultaneously.
Mute switch
Switch to mute the corresponding channel.
0dB switch
Switch to instantly adjust the corresponding channel to 0dB level.
10
Series
21
Hardware Connections
Connect the Umix recording mixing station (Umix series console + Umix series
audio recording expansion card) outputs to your amplifier, powered monitors or
surround system. For two-channel stereo operation, the default outputs are
channels 1 and 2.
If you are monitoring through headphones, connect your headphones to the
device's headphone output.
Connect your microphones, instruments or other line level analog sources to the
device's inputs.
Series
Connect your S/PDIF digital devices to the coaxial digital I/O and MIDI device to
the MIDI I/O.
Umix 12
S/PDIF
USB
Midi Keyboard
DAT
Mac / PC
8
22
Series
Umix 12
Headphones
Microphones
HP-430
HP-360
Monitors
23
Mac OP:
Intel-Mac 1.0GHz or higher
1.0GHz RAM
OS 10.5.5 or later
Series
Windows OP:
Pentium 4 -1.0GHz or higher
1.0Ghz RAM
DirectX 8.1 or higher
Windows XP (SP1), Windows 2000 (SP3),
Windows Vista or Windows 7
Specifications
Line Inputs (Unbanced):
Frequency Response: .............................. 22Hz to 22kHz (+/-0.1dB)
Dynamic Range: ...................................... 100dB, A-weighted
Signal-to-Noise Ratio: ..............................-100dB, A-weighted
THD+N: .................................................... <0.0061% (-90dB)
Crosstalk: ................................................. -100dB @ 1kHz
Nominal Input Level: ............................... Unbalanced: +4dBV, typical;
Maximum Input level: ............................. Unbalanced: +11dBV, typical;
Input Impedance: .................................... 10K Ohms, typical
Line Outputs (Unbanced):
Frequency Response: .............................. 22Hz to 22kHz (+/-0.1dB)
Dynamic Range: ...................................... 102dB, A-weighted
Signal-to-Noise Ratio: .............................. -102dB, A-weighted
THD+N: .................................................... <0.003% (-90 dB)
Crosstalk: ................................................. -100dB @ 1kHz
Nominal Output Level: ............................ Unbalanced: +4dBV, typical;
Maximum Output Level: ......................... +11dBV, typical;
Output Impedance: ................................. 150 Ohm
24
Services
Series
25
Series
26
www.icon-global.com
info@icon-global.com
UMP PD3V100-E