Professional Documents
Culture Documents
TC Rcue40-400ag1 PDF
TC Rcue40-400ag1 PDF
TC Rcue40-400ag1 PDF
AIR COOLED
WATER CHILLERS
-SCREW TYPERCUE40AG1-400AG1 (R407C)
Cooling Capacity 108 kW - 1068 kW
TABLE OF CONTENTS
1 IMPORTANT NOTICE.................................................................................................................. 1
2 FEATURE AND BENEFITS ......................................................................................................... 1
2.1
2.2
2.3
2.4
6 INSTALLATION ........................................................................................................................... 11
6.1
6.2
6.3
6.4
6.5
6.6
6.7
ELECTRICAL WIRING.................................................................................................................................11
WATER PIPING .........................................................................................................................................13
TYPICAL COMMON WATER PIPING ...............................................................................................................14
MINIMUM INTERNAL SYSTEM WATER VOLUME ..............................................................................................15
WATER CONTROL ....................................................................................................................................15
BMS CONNECTION ...................................................................................................................................16
INSTALLATION FINAL CHECK ......................................................................................................................19
PREPARATION .........................................................................................................................................20
TEST RUNING ..........................................................................................................................................20
INSTRUCTIONS AFTER TEST RUNNING.........................................................................................................20
CONTROLLER SYSTEM..............................................................................................................................22
CONTROLLER ADJUSTMENT ......................................................................................................................22
12 TROUBLESHOOTING ............................................................................................................... 53
14 DRAWINGS ................................................................................................................................ 59
14.1
14.2
16 APPLICATION DATA................................................................................................................. 88
16.1
16.2
16.3
COMPRESSOR.......................................................................................................................................93
CONDENSER AND CONDENSER FAN .........................................................................................................93
WATER COOLER ....................................................................................................................................94
IMPORTANT NOTICE
1/1
1. IMPORTANT NOTICE
! HITACHI pursues a policy of continuing improvement
in design and performance of Products. The right is
therefore reserved to vary specifications without notice.
! HITACHI cannot anticipate every possible
circumstance that might involve a potential hazard.
! No part of this manual may be reproduced without
written permission.
! Signal words (DANGER, WARNING and CAUTION)
are used to identify levels of hazard seriousness.
Definitions for identifying hazard levels are provided
below with their respective signal words.
! DANGER:
Immediate hazards which WILL result in severe
personal injury or death.
" WARNING:
Hazards or unsafe practices which COULD result in
severe personal injury or death.
# CAUTION:
Maximum
C
Minimum
43
5 (option: -15)
15
2/2
2.2. COMPRESSOR
" The Samurai Range incorporates
&
'
*
Reciprocating
Screw
AMPLITUDE (m)
Time (second)
" Principle of Compression
Discharge Port
Suction Port
COOLING LOAD %
TIME (Hour)
2/3
Continuous
Capacity
Control
2.3. CONTROL
" Many Functions
Newly developed Control Board has many functions shown
below as standard.
! REMOTE/LOCAL changeover switch
! Individual Alarm
! Pump operation circuit
! Pump Freeze Protection Control
! Reverse Phase Protection
! Time Guard
! Star Delta starting Circuit
! Easy Interface
etc...
Start
Load Up 1
(Quick cooling)
Load Up 2
Neutral =2C Standard
(Minimum 0.5C)
Load Down
TIME
Outlet
Temperature
1st step
Final step
Temperature
Band 7C
(normally)
2/4
The new Samurai Chillers are equipped with plate type Heat
Exchangers, which have many advantages when compared
with conventional Shell & Tube evaporators as described
below:
PLATE
OPERATION INSTRUCTIONS
3/5
3. OPERATION INSTRUCTIONS
3.1. HITACHI AIR-COOLED WATER CHILLERS
To Start the Unit.
Daily Checking
1.
2.
3.
4.
Troubleshooting
" Unit Does Not Start
1.
2.
3.
4.
" Maintenance
Pilot Lamp
The red lamp indicates the normal operation.
When the red lamp is flickered or the orange lamp is
activated, any one of the safety devices may be
functioning.
Please contact your service shop, if this condition is
detected.
4/6
COMPONENTS OF CHILLER
4. COMPONENTS OF CHILLER
4.1. STRUCTURE DRAWING
" HITACHI Air-Cooled Water Chiller (Example of 2 Compressor Chiller)
ON
OFF
CHECK
POWER
OPERATION
ALARM
Air Inlet
Air Outlet
Air Outlet
Air Inlet
Air Inlet
Water Inlet
Water Outlet
N1 CYCLE
N
1
2
3
4
5
6
7
8
Name
Compressor
Water Cooler
Condenser
Electrical Box
Power Wiring Supply
Fan
Check Valve
Oil Sight Glass
N
9
10
11
12
13
14
15
16
Name
Operation Switch
Expansion Valve
Liquid Line Stop Valve
Dryer Strainer
Liquid Sight Glass
Solenoid Valve
Regulation Valve
Economizer
N2 CYCLE
5/7
" Foundation
" Transportation
! DANGER:
If leakage is detected, stop the unit and contact the
installer or service shop. Do not use a naked fire near
the refrigerant gas. If a naked fire is utilised near the
refrigerant gas, refrigerant is turned into a harmful
phosgene compound.
" WARNING:
This unit is operated with refrigerant R407C, (R22
option), which is non-flammable and non-poisonous.
However, refrigerant itself is heavier than the
atmosphere so that a floor is covered with refrigerant
gas if refrigerant is leaked. Therefore, keep good
ventilation to avoid choke during servicing.
# CAUTION:
NOTE:
The height of wall shall be smaller than that of the unit
cabinet.
When the unit is installed at the location where the unit
is encircled with walls and obstruction of free Air
circulation is suspected, construction with HITACHI
regarding the operation space is recommended.
" Transportation
" Unpacking
Follow the instructions marked on the packing.
30 mm
h1
h2
3000 mm
Overhead Air
Clearance
15 mm
h1 h2
Fig.2. Maximum Foundation Gradient
Fig.1. Operation Space
5/8
Centre of Gravity
Control Panel
Model
RCUEAG1
40
50
60
70
80
100
120
140
150
180
200
240
270
300
330
360
400
321
321
459
459
333
333
477
477
368
368
527
527
372
372
533
533
385
385
385
552
552
552
401
401
401
575
575
575
448
448
448
642
642
642
453
453
453
650
650
650
447
447
447
447
641
641
641
641
489
489
489
489
701
701
701
701
495
495
495
495
710
710
710
710
513
513
513
513
513
735
735
735
735
735
520
520
520
520
520
744
744
744
744
744
530
530
530
530
530
530
759
759
759
759
759
759
536
536
536
536
536
536
769
769
769
769
769
769
540
540
540
540
540
540
540
774
774
774
774
774
774
774
547
547
547
547
547
547
547
784
784
784
784
784
784
784
1,620
1,790
1,810
2,810
2,930
3,270
3,310
4,350
4,760
4,820
6,240
6,320
7,730
7,830
9,200
9,320
1,900
1,900
1,900
1,900
2,800
2,800
2,800
3,700
3,700
4,600
4,600
5,500
5,500
750
750
750
750
750
750
750
750
750
750
750
750
750
Operating Weight
(Kg)
1,560
5/9
Vibration-proof
Rubber mat
(6 positions)
4-26
(Mounting Holes)
Bottom Frame
Vibration-proof
Rubber mat
(14 positions)
8-26
(Mounting Holes)
6-26
(Mounting Holes)
Bottom Frame
Vibration-proof
Rubber mat
Vibration-proof
Rubber mat
(10 positions)
(18 positions)
Bottom Frame
10-26
(Mounting Holes)
Bottom Frame
Detail Of Foundation
Vibration-proof
Rubber mat
(22 positions)
Bottom Frame
12-26
(Mounting Holes)
Bottom Frame
Foundation bolt
(M20)
Rubber bush
(OPTION)
Vibration-proof
Rubber mat
Nut
Washer
(26 positions)
Concrete
14-26
(Mounting Holes)
Bottom Frame
! DANGER:
Do not stand below the unit when rigging.
# CAUTION:
Put clothes between wires and the unit to avoid
damages.
Rigging shall be performed by the instruction drawing
attached to the unit.
(Here the example of RCUE120AG1 is shown).
Electrical Box
Wire length
Min.3000mm.
(Field supplied)
Spreader Bar
(Field Supplied)
Removable
Rigging Holes
(4-50)
" WARNING:
Do not decline the unit more than an angle of 15 as
shown in the figure during transportation. If declined
more than an angle of 15, the unit may fall down.
Fig.5.Transportation by Roller.
Fig.6. Declining the unit.
INSTALLATION
6/11
6. INSTALLATION
6.1. ELECTRICAL WIRING
" Tools and Instruments
One Set of Wiring tools and Electrical Tester (Clamp Meter)
" Schedule Check
" WARNING:
- Confirm that the field-selected electrical
N
1
2
3
4
5
Name
Main Power/Terminal Board (R,S,T,N)
Electrical Box
Main Power Switch
Main Power Wiring
Earth Wiring
6/12 INSTALLATION
.
,
,
DC24V
6 Cycles
5,6 Cycles
4,5,6 Cycles
3,4,5,6 Cycles
Remote control Switch (RSW-A ) (Option)
2,3,4,5,6 Cycles
2
In case of Individual without Remote control Switch (6 Cycles)
ON/OFF
MODE
(No use low voltage control)
NORMAL
MODE
(No Low Voltage Control)
MODE1
(Hi / Lo)
Hi
Lo
OFF
MODE 2
(Pulse)
ON
min.100ms
min.100ms
N Name
In case of remote control operation this wire
1
shall be removed.
2 R Phase
3 Neutral
4 Low Voltage / Remote Control
5 Run/Stop Signal
6 Alarm Signal
7 Alarm Lamp
8 Pump Operation
9 Pump Interlock
NOTE:
1. All the setting shall be performed before Power ON.
2. Remote/Local Change over Switch on Operation
Switch shall be set, to "Remote".
3. Terminals 1!~/ 21! are for AC220-240V, Terminals
A!~D! are for DC24V.
INSTALLATION
6/13
Water Inlet
1
1
2
2
3
3
Water Outlet
1
1
2
2
3
3
# CAUTION:
This product is equipped with plate type heat
exchanger. In the plate heat exchanger, water flows
through a narrow space between the plates.
Therefore, there is a possibility that freezing may
occur if foreign particles or dust are clogged. In order
to avoid this clogging. 20 mesh water strainer shall
be attached at the inlet of chilled water piping
near the product. In case of punching metal type
strainer, mesh hole size shall be 2mm or less.
Never use the salt type antifreeze mixture, because it
possesses strong corrosion characteristics, and water
equipment will be damaged.
+ Pressure Gauge
, Strainer
- Flexible Joint
. Valve
Water Inlet
Chiller
Water Outlet
6/14 INSTALLATION
6.3. TYPICAL COMMON WATER PIPING
RCUE 150, 180, 200, 240, 270AG1
NOTES:
1. Provide a 20 mesh water strainer at the
Chiller water inlet.
2. Securely connect the chilled water pipe of
each cooler in the same water system.
3. Support the water pipes with stay not to
give the weight of water pipes directly to
the unit.
Field piping
(Field supplied)
1
2
3
4
5
6
7
8
9
10
HITACHI standard
NOTES:
3. Provide a 20 mesh water strainer at the
Chiller water inlet.
4. Securely connect the chilled water pipe of
each cooler in the same water system.
3. Support the water pipes with stay not to
give the weight of water pipes directly to
the unit.
Field piping
(Field supplied)
1
2
3
4
5
6
7
8
9
10
HITACHI standard
INSTALLATION
6/15
40
m
50
60
70
80
NOTE:
Minimum internal system water volume written above is
for standard ON/OFF differential, minimum internal
system water volume shall be increased by the setting of
differential.
100 120 140 150 180 200 240 270 300 330 360 400
0.64 0.58 0.70 0.78 1.28 1.16 1.40 1.56 1.74 2.10 2.34 2.80 3.12 3.50 3.90 4.20 4.68
litre 10.8 13.3 16.1 16.1 23.9 30.7 38.2 38.2 44.0 54.3 54.3 76.4 76.4 82.2 82.2 114.6 114.6
# CAUTION:
When industrial water is applied for chilled water and
condenser water, industrial water rarely causes
deposits of scales or other foreign substances on
equipment. However, well water or river water may in
most cases contain suspended solid matter, organic
matter, and scales in great quantities. Therefore,
such water should be subjected to filtration or
softening treatment with chemicals before application
as chilled water.
Item
Standard Quality
pH (25 C)
Electrical Conductivity (mS/m) (25C)
(2)
{S/cm} (25 C)
Chlorine Ion (mg CI/I)
2
Sulphur Acid Ion (mg SO4 /I)
The Amount of Acid Consumption (pH 4.8)
(mg CaCO3/I)
Total Hardness (mg CaCO3 /I)
Calcium Hardness (mg CaCO3 /I)
Silica L (mg SIO2 /I)
Reference Quality
Total Iron (mg Fe/I)
Total Cupper (mg Cu/I)
2
Sulphur Ion (mg S /I)
+
Ammonium Ion (mg NH4 /I)
Remaining Chlorine (mg CI/I)
Floating Carbonic Acid (mg CO2/I)
Index of Stability
(1)
Tendency
Deposits of
Corrosion
Scales
#
6.8 ~ 8.0
6.8 ~ 8.0
Less than 40
Less than 400
Less than 50
Less than 50
Less than 30
Less than 300
Less than 50
Less than 50
Less than 50
Less than 50
Less than 70
Less than 50
Less than 30
Less than 70
Less than 50
Less than 30
#
#
#
#
#
#
#
#
#
NOTE:
1. The mark "#" in the table means the factor
concerned with the tendency of corrosion or deposits
of scales.
2. The value showed in "{}" are for reference only
according to the former unit.
#
#
6/16 INSTALLATION
6.6. BMS CONNECTION
4.
6.6.1. SYSTEM
BMS connection is available by using HARC70-CE1,
optional BMS interface unit.
Upper Monitoring Devide
LonWorks
HARC70-CE1
H-Link
Chiller 1
Chiller 2
Chiller 3
Chiller 4
6.6.2. SIGNAL
Control
Operation
State
Monitoring
ON/OFF Chiller
Outlet Water Setting
ON/OFF
Chilled Water Outlet
Setting
Chilled Water Outlet
Temp.
Chilled Inlet Water Temp.
Alarm Codes
Operation status
INSTALLATION
" Marking of Terminals
Mark
POW
Indication
Red: Power Supply (AC220/240V)
Green: Lighted During
Transmission Between LONWORKS
Yellow: Lighted During
Transmission Between Chiller
IRP
PAC
POW
Down
After Open
Terminal Cover
After Open
6/17
IRP
AC / AC /
CONTROL SYSTEM
PAC
G/W HITACHI
LON / H-LINK
MCLR
B B
LON-SERV.
S201
S202
LON H-LINK
Mounting by Screw
Power Line
Section
1220-240V
Power Source
HARC70-CE1
Wiring Method
Remark
AC / AC / E
AC / AC / E
Earthing Wire
Control Circuit
LON / H-LINK
Upper System
HARC70-CE1
Non-polar
LON / H-LINK
HARC70-CE1
Water Chillers
Non-polar
Chiller Unit
n1
,
.
Chiller Unit
n2
Description
Power Supply
Power Wire AC
220/240V
(Field Supplied)
Connection Wiring
Between Chiller Signal
Wiring DC 5V
(Field Supplied)
Ground Earth Wire
(Field Supplied)
Connection Wire
Between LonWorks
Signal Wire DC 5V
(Field Supplied)
Chiller Unit
n3
Chiller Unit
n4
Wire Size
2mm2 Shielded
_N: CHILLER UNIT N_
2
Configuration Properties
nc60 MinSendTime
nc61 MaxSendTime
NOTE:
Set and use the variables in accordance with the
following tables. (The variables based on "Chiller Part
of LonMarkFunction Profile", however, some function
and setting range have limitation).
6/18 INSTALLATION
" Specifications
Item
Connection
Capacity
Power Supply
Power
Consumption
Ambient Condition
Temperature
Relative Humidity
Net weight
Colour
Material of Box
NOTE:
1. Before operating this gateway, initial settings by a
system integrator for the local LonWorks system
are necessary
2. This gateway is designed to be connected with
LonWorks network, and will not function by itself
when it is not connected.
3. The power lines and the signal lines shall be
separated with a minimum distance of 15cm.
4. It is necessary to set and adjust the Chillers and
gateway, before operating the system.
5. "LonWork" "LonMark" are trademarks of Echelon
Corporation registered in the USA and other
countries.
Mounting Method
Mounting Location
Accessories
Transceiver
Warranty
Specifications
Maximum 4H-Link PCBs of Hitachi
Chiller
AC 1-PH, 220~240V10% 50/60Hz
Maximum 10W
0-45C
10-80% (with condition of no
condensation)
0.6kg
Grey (Munsell 5Y7/1 our similar)
ABS resin molding material
Wall Mount (By 2 x M4 Screws), or on
DIN Rail (35mm)
In Weather and Dust-Proofed Control
Panel
Core x 1, Capacitor x 1
Using FTT-10A
No warranty shall be applied for the
control and operation of the upper
"LonWorks" side.
Hitachi's liability shall cover only Hitachi
Chillers, this gateway, and accessibility
by "LonWorks"
DSW
ON
OFF
In case that Chiller Unit quantity in the same H-Link is 2 or more, set No. 1 pin of DSW10 at the OFF
side from 2nd Unit. If only one Chiller Unit is used, no setting is required.
ON
OFF
In case of applying high voltage to the terminal TB1 (E,F), the fuse on the PCB is cut.
In such a case, first connect the wiring to TB1 (E,F) and then turn ON DSW-2
ON
OFF
4
4
4
4
Air
Water
Heat
Pump
4
4
4
4
nvi0
nvi1
nvi2
nvi3
nvo4
4
4
4
4
4
4
4
4
4
4
nvo5
nvo6
nvo7
nvo8
nvo9
Water
cooled
Air
Cooled
4
4
4
4
Field
Code
Item
Value
SCPT (*2)
State
0:OFF 1:ON
-20~25C
0:OFF, 1:ON
30~60C
HVAC_COOL, HVAC-FREECOOL,HVAC_HEAT.
30~60C
0~100%
-20~60C
-20~60C
Alarm Code
nvo10
4
4
4
4
4
4
nc60
nc61
0~6553 Seconds
0~6553 Seconds
nc52 nc49
When
Update
Default
Transmitted Rate Service Type
4
4
Change occurs
Change occurs
Acknowledged
Acknowledged
4
4
4
4
4
4
4
-
Change occurs
Change occurs
Change occurs
Change occurs
Acknowledged
Acknowledged
Acknowledged
Acknowledged
Change occurs
Acknowledged
INSTALLATION
6/19
Tightened Connections
Switch Size
Fuse Size
Safety Devices
Voltage and Hz
Interlock
Appearance
3. Is the water piping system adequate?
Tube Size
Water Drain
Length
Water Control
Flexible Joint
Air Purge
Insulation
Pressure Control
Strainer
Common Pipes (for 3 or 4 cycles)
6. Are the stop valves for the condenser liquid line open?
7. Have the packing glands and the cap nuts for the stop
valves been tightened?
8. Is BMS connected correctly and operate as decided?
7. TEST RUNNING
7.1. PREPARATION
" Tools and instruments
High Pressure Compound Gauge. Low Pressure
Compound Gauge. Electrical Tester and General Tools.
# CAUTION:
When the unit is wired according to the HITACHI
standard wiring shown on the wiring label. Switch ON
the main power switch, and energise the oil heater for
12 hours before start-up to sufficiently warm the oil.
Each rotation direction of two rotors in the compressor is
fixed so that a reversal phase protection device is
equipped.
However, the rotation direction should be checked with a
following method.
Confirm that phases R, S and T for the compressor is
correctly connected. The correct phase connection can be
checked by a phase sequence indicator. If not, the
compressor does not start due to activation of the reversal
phase protection device.
Cut the main switch and interchange two of three terminals,
R, S and T on the main terminals at the field connection
side in the unit.
# CAUTION:
Switch On the main power switch, and energise the
oil heater for 12 hours before start-up, to sufficiently
warm the oil.
Check to ensure that valves are correctly opened. If
not opened, serious damage will occur to the
compressor due to an abnormally high pressure.
! Operate the pump for chilled water and other auxiliary
equipment such as fan coil units and Air handling units.
! Check to ensure that the chilled water flows sufficiently
and that other auxiliary equipment operate properly.
! Set the switch at the desired temperature.
! Depress the ON push button, the condenser fans will
start to operate and the compressor will be started.
! Check the rotation direction of the condenser fans.
! After system operation becomes stabilised, check the
discharge and suction pressures by 7-segment on
control panel.
! Check to ensure that the thermostat functions properly.
! Check to ensure that the control and protective devices
function properly.
! Starting timer and unload-starting timer are set at five
(5), thirty (30) seconds and three (3) minutes,
respectively, in accordance with operation
characteristics. Therefore, local adjustment should be
avoided.
NOTE:
A loud sound occurs when this compressor is stopped
after the normal operation. However, this sound
indicates no abnormalities and stops within a few
seconds by the activation of the check valve. This sound
is due to the reverse rotation of the screw rotors,
resulting from the pressure difference between the
discharge and the suction pressure.
# CAUTION:
Do not cut off the power source switch during the
operating season. When the power source switch is
cut off, the oil heater for screw compressor is not
energised, and the compressor might be damaged
due to oil foaming at starting.
When the operation season starts after long
disconnection of the power source switch, please turn
on the power source switch 12 hours before starting
operation.
CONTROLLER ADJUSTMENT
8/21
8. CONTROLLER ADJUSTMENT
LED
PUSH
BUTTON
SWITCH
7 SEGMENTS
SWITCH POSITION
ON
OFF
ON
OFF
ON
OFF
Cool
Heat
Local
Remote
(STANDARD: "+07")
) Mode
Set Switch A
(DEPEND ON MODEL)
5 Optional Function B
(STANDARD: ALL OFF)
6 Optional Function C
(STANDARD: ALL OFF)
(STANDARD: "Remote")
DSW5
Definition of Special Terms.
Water
Temperature
Load Up 1 Mode
10C
Set by
DSW5,
5 pin
Set by
RSW8
Load Up 2 Mode
Water Outlet
Temperature
Neutral Zone
Water Inlet
Temperature
Inlet Water Temp.
when system is
stopped with
Thermos Off mode
7C
Setting Temperature
0 1 2 3 4 5 6 7 8 9
Figure
Band (degree) 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0
Set by
DSW5,
1&2 pin
9C
Set by
DSW5,
3&4 pin
CONTROLLER ADJUSTMENT
" Continuos Capacity Control Setting
Switch=DSW5
Temperature Band for Stop Setting Switch
= 1 degree is standard. The figure 1 and 2 of the DSW5
switch are already set at figure 1 = ON side, 2 = OFF side.
The locations at the figure 1 and 2 of the DSW5 mean as
follows.
1
2
1
2
1
2
1
2
Figure
ON ON ON OFF OFF ON OFF OFF
Location
0.5
1.0
1.5
2.0
Band(degree)
Temperature Band for Restart Setting Switch
= 2 degree is standard. The figure 3 and 4 of the DSW5
switch are already set at figure 3 = ON side, 4 = OFF side.
The locations at the figure 3 and 4 of the DSW5 mean as
follows.
3
4
3
4
3
4
3
4
Figure
ON ON ON OFF OFF ON OFF OFF
Location
1.0
2.0
3.0
4.0
Band(degree)
Differential Temperature of Load-up 2 Mode Setting Switch
= 1 degree is standard. The figure 5 of the DSW5 switch is
already set at ON side.
The locations at the figure 5 of the DSW5 mean as follows.
5
5
Figure
ON OFF
Location
Band(degree) 1.0 3.0
8/23
= DSW2
* Time Delay Starting for Compressor Setting Switch *
The compressor will be started after this setting time.
= 3 minutes is standard. The figure 1 and 2 of the DSW2
switch are already set at figure 1 = OFF side, 2 = OFF side.
The locations at the figure 1 and 2 of the DSW2 mean as
follows.
Figure
Location
Time(minute)
1
2
1
2
1
2
1
2
ON ON ON OFF OFF ON OFF OFF
0.5
6
10
3
1
ON
2
OFF
3
4
5
OFF OFF OFF
1 Comp. System
6
OFF
Figure
Location
Model
1
ON
2
ON
3
4
5
OFF OFF OFF
2 Comp. System
6
OFF
6
6
Figure
ON OFF
Location
Time(second) 12 24
Figure
Location
Model
1
ON
2
ON
3
4
5
ON
OFF OFF
3 Comp. System
6
OFF
Figure
Location
Model
1
ON
2
ON
3
4
5
ON
ON
OFF
4 Comp. System
6
OFF
Figure
Location
Model
1
ON
2
ON
3
4
5
ON
ON
ON
5 Comp. System
6
OFF
7
8
7
8
7
8
7
8
Figure
ON ON ON OFF OFF ON OFF OFF
Location
2
4
6
8
Time(second)
Figure
Location
Model
1
ON
2
ON
3
4
5
ON
ON
ON
6 Comp. System
6
ON
Interval of Output Signal Time for Load-up 2 and Loaddown Mode Setting Switch.
= 60 seconds is standard. The figure 9 and 10 of the DSW5
switch are already set at figure 9=ON side, 10=ON side.
The locations at the figure 9 and 10 o f the DSW5 mean as
follows.
9
10
9
10
9
10
9
10
Figure
ON ON ON OFF OFF ON OFF OFF
Location
60
90
120
30
Time(second)
NOTE:
The figures 2, 3 and 4 of DSW3 which are Not
corresponding to the equipped compressor number are
always turned to the OFF side.
3
ON
Figure
Location
Type of
Chiller/Refrigerant
3
OFF
7
ON
R407C LW
7
ON
R407C ST
3
ON
7
OFF
R22 LW
3
OFF
7
OFF
R22 ST
9
10
ON OFF
50 HP
9
10
ON
ON
60 HP
Chilled
Water
Temp.
(C)
Operation = SW8
= All model in this series are for cooling only. So that
Heating function is Not available.
The SW8 Selection Switch must be turned to the upper
side.
" Selection Switch for Local/ Remote Operation =
Chilled
Water
Temp.
(C)
SW6
= Remote operation is standard. So that the SW6 selection
switch is turned to the lower side.
If local operation is required, the SW6 selection switch is
turned to the upper side.
" Selection Switch for Local/ Remote Pump
Operation = SW7
= The SW7 selection switch is turned to the lower ("OFF")
side as remote setting.
If local operation is required, the SW7 selection switch is
turned to the upper side.
" Anti-freeze Control by Pump Operation =
DSW6-2pin
If the ambient temperature get lower than 2 C, water pump
is operated forcedly and it protect water line against
freezing. OFF side setting of DSW6-2pin makes this control
available.
This control is available only when the pump is controlled
by Chiller (See wiring diagram).
" Other Switches = SW5, DSW6, RSW9 and
DSW1
This control panel is equipped with other switches:
The SW5 selection switch for chilled water/brine water, so
that this switch must be turned to the upper side
(water). DSW6 and RSW9 for operation mode and
setting change of these switches are not available.
It is recommended that the setting is not changed at site.
Also, the DSW1 switch is equipped with. This switch is
used for only checking, resulting in easy troubleshooting.
Symbols
Show
Continuous Run
Intermittent Run
Stopped
1/25
" Brine Option Setting = DSW4
NOTE:
The other information of brine option are on page 29 and
32.
9. SELF-INSPECTION FUNCTIONS
9.1. ALARM INDICATION
If the unit is operated under abnormal conditions, an alarm
code(refer to the table below) is indicated and the "Alarm"
LED lamp is lighted.
Function of 7-Segment Light Emitted Diode on Control
Panel is as shown in the table below.
SEG.1
SEG.2
7 Segments on
? ? ? ? Control Panel
No.1
cycle
No.2
cycle
Code
No.3
No.4
cycle
cycle
No.5
cycle
No.6
cycle
C1-H1
C2-H2
C3-H3
C4-H4
C5-H5
C6-H6
C1-L1
C2-L2
C3-L3
C4-L4
C5-L5
C6-L6
C1-t1
C2-t2
C3-t3
C4-t4
C5-t5
C6-t6
C1-41
C2-42
C3-43
C4-44
C5-45
C6-46
C1-51
C2-52
C3-53
C4-54
C5-55
C6-56
C1-71
C2-72
C3-73
C4-74
C5-75
C6-76
C1-61
C2-62
C3-63
C4-64
C5-65
C6-66
C1-o1
C2-o2
C3-o3
C4-o4
C5-o5
C6-o6
C1-28
C2-28
C3-28
C4-28
C5-28
C6-28
C1-27
C2-27
C3-27
C4-27
C5-27
C6-27
C1-26
C2-26
C3-26
C4-26
C5-26
C6-26
C1-21
C2-21
C3-21
C4-21
C5-21
C6-21
C1-23
C2-23
C3-23
C4-23
C5-23
C6-23
C1-24
C2-24
C3-24
C4-24
C5-24
C6-24
C1-P6
C2-P6
C3-P6
C4-P6
C5-P6
C6-P6
Content
6E-6E
AP-AP
13-13
Freezing Protection
C1-05
C2-05
C3-05
C4-05
C5-05
C6-05
Phase Abnormally
C1-5P
C2-5P
C3-5P
C4-5P
C5-5P
C6-5P
"C1""Pu"
"C2""Pu"
"C3""Pu"
"C4""Pu"
"C5""Pu"
"C6""Pu"
40-40
Malfunction
11-11
12-12
15-15
16-16
22-22
XX - XX : SEG1-SEG2
No.1
cycle
No.2
cycle
Code
No.3
No.4
cycle
cycle
No.5
cycle
No.6
cycle
Content
C1-88
C2-88
C3-88
C4-88
C5-88
C6-88
C1-Co
C2-Co
C3-Co
C4-Co
C5-Co
C6-Co
Cooling Operation
C1-oF
C2-oF
C3-oF
C4-oF
C5-oF
C6-oF
Stoppage by Thermo-Off
C1-Pu
C2-Pu
C3-Pu
C4-Pu
C5-Pu
C6-Pu
Normal Operation
Condition
"88" "Co" "oF"
Checking
Indication
than 3 sec.
It is changed to the normal mode by
pressing the "" switch for more than
3 sec. again.
Capacity Control
Indication
than 3 seconds.
It is available only while the ""
switch is pressed. It changes to
normal mode after 3 seconds
automatically.
NOTE:
Each indication mode shall be changed from the normal mode.
" Indication Mode of Alarm Occurrence Data
Example
D B H I
D G @ H
D J K C
D B L L
@ A B C
In case of No. 1 cycle high
pressure alarm occurrence
D B E B
@ A
F
D G E G
NOTE:
If an abnormal operation is occurred under this
indication mode, this indication mode is changed to the
alarm indication mode.
SELF-INSPECTION FUNCTIONS
" Checking Indication
,
Back to "CPU ROM number"
(no alarm)
D B M K
D G M Q
C N G
D J M Q
C N G
D N M Q
C N G
D O M Q
C N G
D P M Q
C N G
D B R K
? G
(N 1 Cycle RK = 82C)
D G R K
? G
D J R K
? G
D N R K
? G
D O R K
? G
D P R K
? G
C N G
D B M Q
B F G
D P M K
B F G
D O M K
B F G
D N M K
B F G
D J M K
B F G
D G M K
B F G
C C C C
D B R Q
(N 1 Cycle RQ = -2C)
9/27
D O R Q
D P R Q
D B R S
J O
(N 1 Cycle RS1 = 36)
N
(N 1 Cycle RS2 = 4)
D G R S
J O
D J R S
J O
D N R S
J O
D O R S
J O
D P R S
J O
D T U
B G
D A U
D A U B
D A U G
D A U J
R Q D
K W
R X
J O
D N R Q
D J R Q
D G R Q
S @ C
(ROM N = C-203)
G Y J
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Time Schedule
Solenoid Valve
OFF
OFF
OFF
OFF
MF11~14
SV11
SV12
SV13
Fan Motor
OFF
CLS
OFF
OFF
OFF
OFF
OFF
OFF
CH1
MC1
No.1
CPUE
MI
PBS
Compressor Motor
Control Devices
Control Stage
OFF
OFF
OFF
OFF
OFF
ON
CLS
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
CLS
ON
ON
ON
OFF
ON
Capacity Control
Minimun 3min.
OFF
OFF
ON
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33~99%
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33~99%
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33~99%
OFF
OFF
OFF
OFF
OFF
OPN
ON
ON
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
OFF
OFF
ON
Safety Devices
10/29
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33~99%
ON
OFF
OFF
OFF
ON
ON
-
OFF
OFF
OFF
OFF
OFF
ON
CLS
OFF
ON
OFF
OFF
ON
10sec.
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
ON
ON
OFF
OFF
ON
Shut Down
CLS
ON
ON
ON
OFF
OFF
DTA
(ULD)
33%
!
!
!
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
DLT
DLT
DLT
(FLD) (FLD)
(ULD)
(ULD) OFF
100% 100% 33~99%
33%
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
ON
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
!
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33~99%
30sec.
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
33%
5sec.
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
STA
(ULD)
33%
3min.
ON
OFF
OFF
OFF
ON
CLS
ON
ON
ON
OFF
OFF
Starting Control
CONTROL SYSTEM
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OFF
OFF
OFF
OFF
OFF
CONTROL SYSTEM
10/29
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Time Schedule
MF11~14
SV11
SV12
SV13
OFF
OFF
OFF
OFF
Solenoid Valve
Fan Motor
OFF
CLS
OFF
OFF
OFF
OFF
OFF
OFF
CH1
MC1
No.1
CPUE
MI
PBS
Compressor Motor
Control Devices
Control Stage
OFF
OFF
OFF
OFF
OFF
ON
CLS
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
CLS
ON
ON
ON
OFF
ON
Capacity Control
Minimun 3min.
OFF
OFF
ON
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25~99%
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25~99%
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25~99%
OFF
OFF
OFF
OFF
OFF
OPN
ON
ON
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
OFF
OFF
ON
Safety Devices
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25~99%
ON
OFF
OFF
OFF
ON
ON
-
OFF
OFF
OFF
OFF
OFF
ON
CLS
OFF
ON
OFF
OFF
ON
10sec.
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
ON
ON
OFF
OFF
ON
Shut Down
CLS
ON
ON
ON
OFF
OFF
DTA
(ULD)
25%
!
!
!
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
DLT
DLT
DLT
(FLD) (FLD)
(ULD)
(ULD) OFF
100% 100% 25~99%
25%
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
ON
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
!
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25~99%
30sec.
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
DLT
(ULD)
25%
5sec.
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
STA
(ULD)
25%
3min.
ON
OFF
OFF
OFF
ON
CLS
ON
ON
ON
OFF
OFF
Starting Control
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OFF
OFF
OFF
OFF
OFF
10/30
CONTROL SYSTEM
OFF
No.1
No.2
CPUE
MC1
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC2
MF11~14
MF21~24
SV11
SV12
SV13
SV21
SV22
SV23
CH1
CH2
OFF
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
MI
PBS
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Time Schedule
Solenoid Valve
Fan Motor
Compressor Motor
Oil Heater
Safety Devices
Control Devices
Control Stage
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
OFF
OFF
ON
OFF
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
CLS
CLS
ON
ON
ON
OFF
OFF
ON
DLT
(ULD)
33%
60sec
5sec.
CLS
CLS
ON
ON
ON
OFF
OFF
ON
STA
(ULD)
33%
3min.
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
CLS
CLS
ON
ON
ON
OFF
ON
ON
Starting Control
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33%
DLT
(ULD)
33%
OFF
OFF
ON
OFF
OFF
ON
CLS
CLS
ON
ON
ON
OFF
ON
ON
Minimun 3min.
!
!
!
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
DLT
DLT
DLT
(FLD) (FLD)
(ULD)
(ULD) OFF
100% 100% 33~99%
33%
DLT
DLT
DLT
DLT
(FLD) (FLD)
(ULD)
(ULD) OFF
100% 100% 33~99%
33%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
ON
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
ON
OFF
ON
OFF
OFF
OFF
OFF
!
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
5sec. 30sec.
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33%
STA
(ULD)
33%
Capacity Control
OFF
OFF
ON
OFF
OFF
ON
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
10/31
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
33~99%
OFF
OPN
CLS
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OPN
OPN
ON
ON
OFF
ON
ON
ON
Safety Devices
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DTA
(ULD)
33%
DTA
(ULD)
33%
CONTROL SYSTEM
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
-
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
10sec.
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
ON
ON
OFF
OFF
ON
ON
Shut Down
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
CONTROL SYSTEM
10/31
MF11~14
MF21~24
SV11
SV12
SV13
SV21
SV22
SV23
MC2
CH1
CH2
MC1
No.2
CPUE
No.1
MI
PBS
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Time Schedule
Solenoid Valve
Fan Motor
Compressor Motor
Oil Heater
Safety Devices
Control Devices
Control Stage
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OFF
ON
OFF
OFF
ON
ON
ON
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
ON
OFF
OFF
ON
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
ON
DLT
(ULD)
25%
CLS
60sec
5sec.
ON
OFF
OFF
ON
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
ON
STA
(ULD)
25%
3min.
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
ON
ON
ON
CLS
Starting Control
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25%
DLT
(ULD)
25%
CLS
CLS
CLS
OFF
OFF
ON
OFF
OFF
ON
CLS
CLS
CLS
CLS
Minimun 3min.
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
DLT
DLT
DLT
DLT
(FLD)
(FLD)
(ULD)
(ULD) OFF
100%
100%
25~99%
25%
DLT
DLT
DLT
DLT
(FLD)
(FLD)
(ULD)
(ULD) OFF
100%
100%
25~99%
25%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
ON
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
ON
OFF
ON
OFF
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
5sec. 30sec.
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25%
STA
(ULD)
25%
CLS
Capacity Control
OFF
OFF
ON
OFF
OFF
ON
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
OFF
CLS
ON
ON
ON
ON
ON
OFF
OPN
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OPN
ON
ON
OFF
ON
ON
ON
OPN
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
OFF
OFF
ON
ON
OFF
CLS
ON
OFF
OFF
ON
OFF
OFF
CLS
ON
ON
ON
OFF
OFF
OFF
DTA
(ULD)
25%
DTA
(ULD)
25%
CLS
Safety Devices
CLS
ON
ON
ON
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
-
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OFF
ON
OFF
OFF
ON
ON
ON
CLS
10sec.
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
ON
ON
OFF
OFF
ON
ON
ON
OFF
CLS
Shut Down
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
10/32
CONTROL SYSTEM
CLS Close
OPN: Open
STA: Star
DLT Delta
Time Schedule
Solenoid Valve
Fan Motor
Compressor Motor
Oil Heater
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC3
MF11~14
MF21~24
MF31~34
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
OFF
OFF
OFF
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC2
MC1
CH1
CH2
CH3
No.1
No.2
No.3
CPUE
MI
PBS
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Safety Devices
Control Devices
Control Stage
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
60sec.
5sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
60sec.
5sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
Capacity Control
Minimun 3min.
!
!
!
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
33~99% 100% 100% 33~99% 33%
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
33~99% 100% 100% 33~99% 33%
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
33~99% 100% 100% 33~99% 33%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
5sec. 30sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF OFF OFF OFF
OFF
OFF OFF OFF OFF OFF
OFF
ON
ON
OFF OFF OFF
OFF
ON
ON
ON
ON
OFF
OFF
STA
DLT
DLT
DLT
DLT
DLT
(ULD) (ULD) (ULD) (ULD) (ULD) (ULD)
33% 33% 33% 33% 33%
33%
STA
DLT
DLT
DLT
OFF OFF (ULD) (ULD) (ULD) (ULD)
33% 33% 33%
33%
STA
DLT
OFF OFF OFF OFF (ULD) (ULD)
33%
33%
3min.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
Starting Control
10/33
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OPN
OPN
OPN
ON
ON
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
Safety Devices
!
!
!
!
!
CLS
CLS
CLS
CLS
OPN
OPN
CLS
CLS
CLS
CLS
CLS
OPN
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
DTA
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
OFF
OFF
33% 33~99% 33~99% 33~99%
DTA
DLT
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
(ULD)
OFF
33% 33~99% 33~99% 33~99% 33~99%
DTA
DLT
DLT
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
(ULD)
(ULD)
33% 33~99% 33~99% 33~99% 33~99% 33~99%
CONTROL SYSTEM
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
DLT
(ULD)
33~99%
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
-
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
10sec.
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
Shut Down
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CONTROL SYSTEM
10/33
CLS Close
OPN: Open
STA: Star
DLT Delta
Time Schedule
Solenoid Valve
Fan Motor
Compressor Motor
Oil Heater
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC3
MF11~14
MF21~24
MF31~34
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
OFF
OFF
OFF
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC2
MC1
CH1
CH2
CH3
No.1
No.2
No.3
CPUE
MI
PBS
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
Safety Devices
Control Devices
Control Stage
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
60sec.
5sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
60sec.
5sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
Capacity Control
Minimun 3min.
!
!
!
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
25~99% 100% 100% 25~99% 25%
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
25~99% 100% 100% 25~99% 25%
DLT
DLT
DLT
DLT
DLT
(ULD)
(FLD) (FLD)
(ULD) (ULD) OFF
25~99% 100% 100% 25~99% 25%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
OFF
ON
ON
OFF
OFF
OFF OFF
5sec. 30sec.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF OFF OFF OFF
OFF
OFF OFF OFF OFF OFF
OFF
ON
ON
OFF OFF OFF
OFF
ON
ON
ON
ON
OFF
OFF
STA
DLT
DLT
DLT
DLT
DLT
(ULD) (ULD) (ULD) (ULD) (ULD) (ULD)
25% 25% 25% 25% 25%
25%
STA
DLT
DLT
DLT
OFF OFF (ULD) (ULD) (ULD) (ULD)
25% 25% 25%
25%
STA
DLT
OFF OFF OFF OFF (ULD) (ULD)
25%
25%
3min.
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
Starting Control
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OPN
OPN
OPN
ON
ON
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
!
!
!
!
!
CLS
CLS
CLS
CLS
OPN
OPN
CLS
CLS
CLS
CLS
CLS
OPN
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
DTA
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
OFF
OFF
25% 25~99% 25~99% 25~99%
DTA
DLT
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
(ULD)
OFF
25% 25~99% 25~99% 25~99% 25~99%
DTA
DLT
DLT
DLT
DLT
DLT
(ULD) (ULD)
(ULD)
(ULD)
(ULD)
(ULD)
25% 25~99% 25~99% 25~99% 25~99% 25~99%
Safety Devices
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
-
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
10sec.
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
Shut Down
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
10/34
CONTROL SYSTEM
CONTROL SYSTEM
10/35
Capacity Control
Control Devices
Main Power Switch
Operation Switch
Load Up
Controller
Neutral
Load Down
Safety Devices
Chilled Water Pump
Power Supply Indicator
Operation Indicator
Alarm Indicator
Oil Heater
MI
PBS
No.1
No.2
No.3
No.4
CPUE
CH1
CH2
CH3
CH4
MC1
OFF
CLS
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
CLS
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
ON
ON
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
MC2
Compressor Motor
MC3
MC4
Fan Motor
Solenoid Valve
MF11~14
MF21~24
MF31~34
MF41~44
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
!
!
!
CLS CLS CLS CLS CLS
CLS CLS CLS
CLS
CLS
CLS
CLS CLS CLS CLS CLS
CLS CLS CLS
CLS
CLS
CLS
CLS CLS CLS CLS CLS
CLS CLS CLS
CLS
CLS
CLS
CLS CLS CLS CLS CLS
CLS CLS CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
ON
ON
OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
ON
ON
ON
ON
OFF OFF OFF OFF
OFF
OFF
OFF
ON
ON
ON
ON
ON
ON
OFF OFF
OFF
OFF
OFF
STA DLT DLT
DLT
DLT
DLT DLT DLT
DLT
DLT
DLT
(ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD)
(FLD) (FLD)
25% 25% 25% 25% 25% 25% 25% 25% 25~99% 100% 100%
STA DLT
DLT
DLT DLT DLT
DLT
DLT
DLT
OFF OFF (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD)
(FLD) (FLD)
25% 25% 25% 25% 25% 25% 25~99% 100% 100%
STA
DLT DLT DLT
DLT
DLT
DLT
OFF OFF OFF OFF (ULD) (ULD) (ULD) (ULD) (ULD)
(FLD) (FLD)
25% 25% 25% 25% 25~99% 100% 100%
STA DLT
DLT
DLT
DLT
OFF OFF OFF OFF OFF OFF (ULD) (ULD) (ULD)
(FLD) (FLD)
25% 25% 25~99% 100% 100%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
ON
ON
OFF
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
ON
ON
OFF
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
ON
ON
OFF
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
OFF
OFF
OFF
OFF OFF OFF OFF OFF OFF OFF OFF
ON
ON
OFF
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25%
DLT
(ULD)
25%
DLT
(ULD)
25%
DLT
(ULD)
25%
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DTA
(ULD)
25%
DTA
(ULD)
25%
DTA
(ULD)
25%
DTA
(ULD)
25%
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
Time Schedule
3min.
5sec.
60sec.
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
5sec.
60sec.
5sec.
60sec.
5sec 30sec.
Minimun 3min.
The Compressor
which started
finally will be
restarted first.
Shut Down
Control Devices
Main Power Switch
Operation Switch
Load Up
Controller
Neutral
Load Down
Safety Devices
Chilled Water Pump
Power Supply Indicator
Operation Indicator
Alarm Indicator
Oil Heater
MI
PBS
No.1
No.2
No.3
No.4
CPUE
CH1
CH2
CH3
CH4
MC1
MC2
Compressor Motor
MC3
MC4
Fan Motor
Solenoid Valve
MF11~14
MF21~24
MF31~34
MF41~44
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
OPN
OPN
CLS
CLS
ON
ON
ON
OFF
ON
ON
OFF
OFF
OPN
OPN
OPN
CLS
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
ON
ON
OFF
ON
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OPN
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
OFF
OFF
OFF
25~99%
DLT
DLT
(ULD)
(ULD)
OFF
OFF
25~99% 25~99%
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
OFF
25~99% 25~99% 25~99%
DLT
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
(ULD)
25~99% 25~99% 25~99% 25~99%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
ON
ON
-
!
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
ON
CLS
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
Time Schedule
10sec.
The Compressor which started finally
will be restarted first.
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
CONTROL SYSTEM
10/37
Capacity Control
Control Devices
Main Power Switch
Operation Switch
Controller
Load Up
Neutral
Load Down
Safety Devices
Compressor Motor
MI
PBS
No.1
No.2
No.3
No.4
No.5
CPUE
CH1
CH2
CH3
CH4
CH5
MC1
OFF
ON
ON
CLS CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF OFF
STA DLT DLT DLT DLT DLT DLT DLT DLT DLT
OFF (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD)
25% 25% 25% 25% 25% 25% 25% 25% 25% 25%
DLT
(ULD)
25~99%
DLT
DLT
(FLD) (FLD)
100% 100%
DLT
(ULD)
25~99%
DLT
(ULD)
25%
OFF
DTA
DLT
DLT
(ULD) (ULD)
(ULD)
25% 25~99% 25~99%
OFF OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
DLT
(FLD) (FLD)
100% 100%
DLT
(ULD)
25~99%
DLT
(ULD)
25%
OFF
DTA
DLT
DLT
(ULD) (ULD)
(ULD)
25% 25~99% 25~99%
OFF OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
DLT
(FLD) (FLD)
100% 100%
DLT
(ULD)
25~99%
DLT
(ULD)
25%
OFF
DTA
DLT
DLT
(ULD) (ULD)
(ULD)
25% 25~99% 25~99%
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
DLT
(FLD) (FLD)
100% 100%
DLT
(ULD)
25~99%
DLT
(ULD)
25%
OFF
DTA
DLT
DLT
(ULD) (ULD)
(ULD)
25% 25~99% 25~99%
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
STA DLT
OFF (ULD) (ULD)
25% 25%
DLT
(ULD)
25~99%
DLT
DLT
(FLD) (FLD)
100% 100%
DLT
(ULD)
25~99%
DLT
(ULD)
25%
OFF
DTA
DLT
DLT
(ULD) (ULD)
(ULD)
25% 25~99% 25~99%
MC2
MC3
MC4
MC5
Fan Motor
Solenoid Valve
MF11~14
MF21~24
MF31~34
MF41~44
MF51~54
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
SV51
SV52
SV53
OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
Time Schedule
30sec.
5sec.
60sec
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
5sec.
60sec
5sec
60sec.
5sec.
60sec.
5sec. 30sec.
Minimun
The Compressor
which started
finally will be
restarted first.
Shut Down
Control Devices
Main Power Switch
Operation Switch
Controller
Load Up
Neutral
Load Down
Safety Devices
Compressor Motor
MI
PBS
No.1
No.2
No.3
No.4
No.5
CPUE
CH1
CH2
CH3
CH4
CH5
MC1
MC2
MC3
MC4
MC5
Fan Motor
Solenoid Valve
MF11~14
MF21~24
MF31~34
MF41~44
MF51~54
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
SV51
SV52
SV53
OPN
OPN
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
OFF
OFF
OFF
OPN
OPN
OPN
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
CLS
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
OPN
ON
ON
OFF
ON
ON
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
CLS
OPN
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
OFF
OFF
OFF
OFF
25~99%
DLT
DLT
(ULD)
(ULD)
OFF
OFF
OFF
25~99% 25~99%
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
OFF
OFF
25~99% 25~99% 25~99%
DLT
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
(ULD)
OFF
25~99% 25~99% 25~99% 25~99%
DLT
DLT
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
(ULD)
(ULD)
25~99% 25~99% 25~99% 25~99% 25~99%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
ON
ON
ON
-
!
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
ON
ON
CLS
CLS
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
Time Schedule
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
10sec.
CONTROL SYSTEM
10/39
Capacity Control
Control Devices
Main Power Switch
Operation Switch
Load Up
Controller Neutral
Load Down
Safety Devices
Oil Heater
MI
PBS
No.1
No.2
No.3
No.4
No.5
No.6
CPUE
CH1
CH2
CH3
CH4
CH5
CH6
MC1
OFF ON
-
ON
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
CLS
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
STA DLT DLT DLT DLT DLT DLT DLT DLT DLT DLT DLT
DLT
DLT DLT
DLT
DLT
DTA
DLT
DLT
OFF OFF OFF (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (FLD) (FLD) (ULD) (ULD) OFF (ULD) (ULD)
(ULD)
25% 25% 25% 25% 25% 25% 25% 25% 25% 25% 25% 25% 25~99% 100% 100% 25~99% 25%
25% 25~99% 25~99%
OFF OFF OFF OFF
STA DLT DLT DLT DLT DLT DLT DLT DLT DLT
DLT
DLT DLT
DLT
DLT
DTA
DLT
DLT
OFF (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (ULD) (FLD) (FLD) (ULD) (ULD) OFF (ULD) (ULD)
(ULD)
25% 25% 25% 25% 25% 25% 25% 25% 25% 25% 25~99% 100% 100% 25~99% 25%
25% 25~99% 25~99%
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
MC4
MC6
Solenoid Valve
MC5
Fan Motor
MC3
MF11~14
MF21~24
MF31~34
MF41~44
MF51~54
MF61~64
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
SV51
SV52
SV53
SV61
SV62
SV63
MC2
Compressor Motor
OFF
STA DLT
DLT
DLT DLT
DLT
DLT
DTA
DLT
DLT
OFF (ULD) (ULD) (ULD) (FLD) (FLD) (ULD) (ULD) OFF (ULD) (ULD)
(ULD)
25% 25% 25~99% 100% 100% 25~99% 25%
25% 25~99% 25~99%
OFF OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF OFF ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
OFF
OFF
OFF
OFF
OFF
ON
OFF
Time Schedule
30min.
5sec.
60sec
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
5sec.
60sec
5sec
60sec.
5sec.
60sec.
5sec.
5sec. 30sec.
Minimun
The Compressor
which started
finally will be
restarted first.
Shut Down
Control Devices
Main Power Switch
Operation Switch
Load Up
Controller Neutral
Load Down
Safety Devices
Oil Heater
MI
PBS
No.1
No.2
No.3
No.4
No.5
No.6
CPUE
CH1
CH2
CH3
CH4
CH5
CH6
MC1
MC2
MC3
Compressor Motor
MC4
MC5
MC6
Fan Motor
Solenoid Valve
MF11~14
MF21~24
MF31~34
MF41~44
MF51~54
MF61~64
SV11
SV12
SV13
SV21
SV22
SV23
SV31
SV32
SV33
SV41
SV42
SV43
SV51
SV52
SV53
SV61
SV62
SV63
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OPN
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
ON
OFF
OFF
OFF
OFF
OFF
OPN
OPN
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
ON
ON
OFF
OFF
OFF
OFF
OPN
OPN
OPN
CLS
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
CLS
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
OPN
CLS
ON
ON
ON
ON
ON
ON
ON
ON
ON
OFF
OPN
OPN
OPN
OPN
OPN
OPN
ON
ON
OFF
ON
ON
ON
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
OFF
OFF
OFF
25~99%
DLT
DLT
(ULD)
(ULD)
OFF
OFF
25~99% 25~99%
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
OFF
25~99% 25~99% 25~99%
DLT
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
(ULD)
25~99% 25~99% 25~99%
25~99%
DLT
DLT
DLT
DLT
(ULD)
(ULD)
(ULD)
(ULD)
25~99% 25~99% 25~99%
25~99%
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
ON (Q'ty Depends on "Fan Cycling Control")
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
ON
ON
-
!
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
DLT
(ULD)
25~99%
ON
ON
ON
ON
ON
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
ON
OFF
CLS
CLS
CLS
CLS
CLS
CLS
ON
ON
OFF
OFF
ON
ON
ON
ON
ON
ON
ON
CLS
CLS
CLS
CLS
CLS
CLS
OFF
ON
OFF
OFF
ON
ON
ON
ON
ON
ON
OFF
CLS
CLS
CLS
CLS
CLS
CLS
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
Time Schedule
The Compressor which started finally
will be restarted first.
CLS Close
OPN: Open
STA: Star
DLT Delta
ULD: Unload
FLD: Full Load
!: Changing Compressor Load
!: Keeping Compressor Load
10sec.
MAINTENANCE
11/41
11. MAINTENANCE
The unit should be periodically inspected according to the
same items as those described in the paragraph titled
"Test Running". In order to ensure dependable
performance and long life operation, the following
additional items should be given for particular attention.
" WARNING:
If a fire accidentally occurs, turn OFF the main switch
and use an extinguisher for an oil fire and an electric
fire.
Do not operate the unit near flammable gases such
lacquer, paint oil, etc. to avoid a fire or an explosion.
Turn OFF the main switch when electrical box covers
are removed for setting the temperature. Do not
operate the unit without fixing panels.
# CAUTION:
Perform periodical maintenance according to the
"INSTRUCTIONS" to maintain the unit in a good
condition.
Do not touch the parts at the discharge gas side by
hand, since the pipes at the discharge side are
heated by refrigerant and the temperature becomes
higher than 100 C.
Do not utilise this unit for cooling or heating of
drinking water or food. Comply with local codes and
regulations.
Turn OFF all the main switches if refrigerant leakage
or chilled water leakage occurs. Also, if the unit can
not be stopped by the control switch, turn OFF all the
switches for power source.
11.1. COMPONENTS
" Compressor
11.2. LUBRICATION
" Compressor
11.3. DEPOSITS
Lime and other minerals in the condenser water or chilled
water tend to deposit on inside surfaces of plates over a
long period of operation. As deposits of these minerals
increase, excessive power consumption, excessive high
discharge pressure or lower operation pressure are
detected, indicating evidence of deposits on the condenser
or the water cooler.
# CAUTION:
Cleaning of plate type heat exchangers shall be
performed by specialists. Please contact your
contractor or dealer of HITACHI.
Clean the water strainer filter periodically according to
its clogging degree.
" WARNING:
This product is equipped with plate type heat
exchangers. In the plate type heat exchanger, water
flows through a narrow space between plates.
Therefore, there is a possibility that freezing may
occur if foreign particles or dusts are clogged. In
order to avoid this clogging, provide a 20 mesh water
strainer at the inlet of the chilled water piping near the
product. If clogging in the plate type heat exchanger
occurs seriously, this will cause insufficient cooling
performance or local freezing in the plate type heat
exchanger. It is strongly recommended that the heat
exchanger be cleaned at the same time when the
filter is cleaned.
Pay attention to the following caution and normal
cleaning method. For details, contact your Hitachi
installer.
11/42 MAINTENANCE
# CAUTION:
Water
Refrigerant
In the case that acid cleaning is performed,
neutralisation treatment is required after cleaning.
Treatment for neutralisation fluid should be performed
by a waste fluid contractors.
The cleaning agent and neutralising agent have
erosiveness and stimulativeness against eyes, skin,
mucous membrane etc. Therefore use protection
tools (protection glasses, protection gloves, protection
shoes, protection cloth, protection mask, etc.) in order
not to absorb or touch these agents during this
cleaning work.
N
1
2
3
4
5
Name
Chiller Unit
Chilled Water / Inlet Piping
Acid-resistant Type Water Pump
Hose
Diluted Cleaning Fluid
N
6
7
8
9
Name
Waste Fluid Tank
Cleaning Water Tank
Hose
Chilled Water / Outlet Piping
MAINTENANCE
4. Waste Fluid
! Stop the acid-resistant pump.
! Put the waste fluid into the waste fluid tank.
! Supply water into the cleaning tank and operate the
pump for water cleaning.
! Put the cleaning water into the waste fluid tank as
same as the waste fluid.
! Measure pH degree by using a pH test sheet and
neutralise the waste fluid by gradually adding
neutralising agent.
! After neutralisation ask a waste fluid treatment
contractors to handle it.
5. Neutralisation Treatment in the Water Piping
! Put water into the cleaning tank.
! Operate the acid-resistant pump after Air-purging.
! Measure the pH degree and gradually add neutralising
agent until the pH reaches pH = 7.
! Operate the pump for a specified period of time for
neutralisation.
! Discharge the used water.
! Operate the circulating pump and clean the circuit with
water until no fouling fluid is observed.
6. Re-starting
! Reconnect the water piping as they were so that the
water Chiller can operate.
! After cleaning, perform water treatment (preventive
treatment) in order to prevent the water circuit from
corrosion.
N
1
2
3
11/43
Name
Saturation Line of R407C
Saturation Line of R22 (option)
Area Requiring Cleaning
11/44 MAINTENANCE
Remove the drain plug and drain all residual water from the
water cooler piping systems, as such water may freeze
during the cold season. It is very helpful to supply brine
(anti-freezer) to the piping systems.
# CAUTION:
When the main switch for this unit has been at the
OFF position for an extended period of time, it should
be switched ON at least 12 hours before start-up, so
that oil in the compressor discharge casing may be
warmed enough, to prevent oil foaming by the oil
heater during start-up.
# CAUTION:
Do not replace with spare parts which are not the
equivalent.
MAINTENANCE
Option
Gauge
Manifold
Option
Option
Option
Chilled Water Inlet
Charging Evacuation
Chilled Water Outlet
Unit Side
No.
1
2
3
4
5
6
7
8
9
10
11
Name
Compressor
Air Cooled Condenser
Water Cooler
Drier Strainer
Expansion Valve
Check Valve
Stop Valve (with check Joint)
Stop Valve
High Pressure Switch
Pressure Sensor (Low)
Pressure Sensor (High)
NOTE:
R407C shall be charged by LIQUID.
No.
12
13
14
15
16
17
A
B
C
D
E
Name
Pressure Relief Valve
Sight Glass
Compressor Safety Valve (Option)
Stop Valve (Option)
Stop Valve (Option)
Compressor Dual Safety Valve (Option)
High Pressure Gauge
Low Pressure Gauge
Stop Valve
Charging Cylinder
Vacuum Pump
11/45
11/46 MAINTENANCE
11.10. REFRIGERANT CYCLE DIAGRAM OF HITACHI AIR-COOLED WATER CHILLER (RCUE
50,60,70,100,120,140,150,180,200,240,270,300,330,360,400AG1) WITH ECONOMIZER.
Option
Gauge
Manifold
Option
Option
Option
Flange Connection
Flare Connection
Solder Connection
Refrigerant Cycle
Unit Side
NOTE:
R407C shall be charged by LIQUID.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Name
Compressor
Air Cooled Condenser
Water Cooler
Drier Strainer
Expansion Valve
Check Valve
Stop Valve (with check Joint)
Stop Valve
High Pressure Switch
Pressure Sensor (Low)
Pressure Sensor (High)
Pressure Relief Valve
Sight Glass
Compressor Safety Valve
(Option)
No.
15
16
17
18
19
20
21
22
A
B
C
D
E
Name
Stop Valve (Option)
Stop Valve (Option)
Compressor Dual Safety Valve (Option)
Pressure Switch
Solenoid Valve
Regulation Valve
Economizer
Strainer
High Pressure Gauge
Low Pressure Gauge
Stop Valve
Charging Cylinder
Vacuum Pump
Charging Evacuation
MAINTENANCE
# CAUTION:
Do not charge OXYGEN, ACETYLENE or other
flammable and poisonous gases into the refrigeration
cycle when performing a leakage test or an airtight
test. These types of gases are extremely dangerous,
because explosion can occur. It is recommended that
compressed air or nitrogen be charged for these
types of tests.
Mineral deposits on water cooler plates act as
thermal insulators, and also act as resistance against
water flow, causing the water flow to decrease
running through them, and resulting in a decreasing
of the cooling capacity. Deposits on the plates should
be inspected at regular, intervals, experience with the
water Chiller will dictate accurate inspection intervals.
11/47
11/48 MAINTENANCE
11.12. SAFETY AND PROTECTION CONTROL
The safety and protective devices are equipped with the
unit to ensure dependable and long life operation.
! Compressor protection
! Refrigeration Cycle
! Water Cooler
RCUE-AG1
40
50
60
70
MPa
2,74
2,74
2,74
2,74
80
100
120
140
150
180
200
240
270
300
330
360
400
For Compressor
High Pressure Switch
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
2,74
0,05
0,05
0,05
0,05
0,05
0,05
0,05
Electronic Control
(Pressure Sensor)
Cut-Out
MPa
0,05
0,05
0,05
0,05
0,05
0,05
0,05
0,05
0,05
0,05
115
115
115
115
115
115
115
115
115
115
115
115
115
115
115
115
115
Cut- In
93
93
93
93
93
93
93
93
93
93
93
93
93
93
93
93
93
125
125
125
160
125
125
125
160
125
125
160
125
160
125
160
125
160
90
70
90
Compressor Motor
(380-415V/50Hz)
Fuse
Manual Reset, Adjustable ( One Three-Phase Set for Each Compressor Motor )
Thermal Relay
54
65
70
Circuit Protector(Option)
112
136
136
90
54
65
70
90
65
70
90
70
90
70
Manual Reset, Adjustable ( One Three-Phase Set for Each Compressor Motor )
160
112
136
136
160
136
136
160
136
160
136
160
136
160
Oil Heater
Capacity
150
150
150
150
150
150
150
150
150
150
150
150
150
150
150
150
150
140
140
140
140
140
140
140
140
140
140
140
140
140
140
140
140
140
Cut- In
110
110
110
110
110
110
110
110
110
110
110
110
110
110
110
110
110
180
CCP Timer
Setting Time
180
180
180
180
180
180
180
180
180
180
180
180
180
180
180
180
Star-Delta
30
30
30
30
30
30
30
30
30
30
30
30
30
30
30
30
30
3,0
3,0
3,0
3,0
3,0
3,0
3,0
MPa
3,0
3,0
3,0
3,0
3,0
3,0
3,0
3,0
3,0
3,0
Cut- In
Fuse
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
Cut-Out
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
Cut- In
82
82
82
82
82
82
82
82
82
82
82
82
82
82
82
82
82
10
10
10
Internal Thermostat
Circuit Protector(Option)
Manual Reset, Adjustable ( One Three-Phase Set for Each Fan Motor )
A
10
10
10
10
10
10
10
10
10
10
10
10
10
10
MAINTENANCE
11/49
11.12.1. OPTIONS
Following table shows options:
General
Specifications
Low Noise Option
Standard
Compressor
$
$
$
$
$
$
$
$
$
$
$
$
Condenser
Coated Fin
$
$
$
Standard:
Pressure Display on Operation Panel
$
$
$
R22
PED Certificate (97/23/EC)
STEK Coupling
Others
Independent Circuit
Water Cooler
$
$
Copper Fin
Refrigerant
by Alarm Code
$
$
DSW7-3 ON
$
$
$
$
$
$
$
Low Water
Temperature
Option
$
$
$
$
$
$
$
$
11/50 MAINTENANCE
11.13. NORMAL OPERATING PRESSURE
each Cycle
Standard Working Range
# CAUTION:
! Periodical Maintenance
Perform periodical maintenance according to the
"INSTRUCTIONS" to maintain the unit in a good
condition.
! Fire
If a fire accidentally occurs, turn OFF the main switch
and use an extinguisher for an oil fire and electric fire.
! Flammable Gases
Do not operate the unit near the flammable gases
such as lacquer, paint, oil, etc. to avoid a fire or an
explosion.
! Service Panels and Electrical Box Cover
Turn OFF the main switch when service panels or
electrical box covers are removed for setting the
temperature.
Do not operate the unit without fixing panels.
! Heated Pipe
Do not touch the parts at discharge gas side by hand,
since the pipes at the discharge side are heated by
refrigerant and temperature becomes higher than
100C.
! Use
Do not utilise this unit for cooling of drinking water or
food. Comply with local codes and regulations.
! Failure
Turn OFF all the main switches if refrigerant leakage
or chilled water leakage occurs. Also, if the unit can
not be stopped by the control switch, turn OFF all the
switches for power source.
MAINTENANCE
MODEL:
RCUE
MFG. NO.
COMPRESSOR
MFG. NO.
DATE
Outlet
m /h
Check Suction Line Temperature and Superheat:
Suction Line Temperature
Superheat
deg
deg
deg
deg
Discharge Pressure
MPa
MPa
MPa
MPa
MPa
MPa
MPa
MPa
Check Pressure:
Suction Pressure
Check Running Current:
11/51
11/52 MAINTENANCE
11.15. DAILY OPERATING RECORDS
Model:
Date:
Weather:
Time of Operation : Start,
Stop. (
Sampling Time
Compressor Number
Term
Ambient Temperature
Compressor
DB
WB
High Pressure
MPa
Low
MPa
Pressure
Voltage
Current
Inlet
Outlet
C
A
TROUBLESHOOTING
12/53
12. TROUBLESHOOTING
" The following table shows efficient checking procedures for trouble.
Fault
Possible Cause
Current to Unit is Shut Off
Fuse for Operation Circuit is Blown Out or
Faulty Contact
Compressor Stops on
Overcurrent Relay
Check/Corrective Action
1. Reset the power supply line to the unit.
1. Check for shorted components.
2. Check for loose connection. Tighten or
replace. If necessary.
1. Find the causes, and repair or replace.
1. Remove the causes, and reset the
overcurrent relay.
1. Check the voltage of unit rating.
1. Check the motor and terminals.
Repair or replace, if necessary.
1. Remove all causes of inoperative fan.
1. Check the pump contactor. Repair or
replace, if necessary.
2. Check for the faulty pump.
1. Remove the causes, and reset the ON
button. See the following causes.
1. Interchange two of three terminals R, S
and T at the main power source terminals.
1. See High Discharge Pressure
1. Readjust the setting or replace, if defective.
1. See High Discharge Pressure and High
Suction Pressure.
1. Check the power supply line and
contactors. Repair, if necessary.
1. Tighten the loose electrical connection or
repair, if necessary.
1. Check the compressor motor. Repair or
replace, if necessary.
1. Replace it, if necessary.
12/54 TROUBLESHOOTING
" The following table shows efficient checking procedures for trouble.
Fault
Possible Cause
Excessively Low Chilled water Outlet
Temperature
Defective Thermistor
Shortage of Chilled Water Flow
Air in water Circuit
High or Low Voltage, Single-Phase or Phase
Imbalance
Insufficient Cooling
Excessive Superheat
Defective Element
Excessive High Discharge Pressure and Low
Suction Pressure
High Discharge Pressure or Low Suction
Pressure
Improper Thermostat Setting
Defective Unload Mechanism
Noisy Compressor
Miscellaneous Noise
Check/Corrective Action
1. Check for excessively low setting of the
chilled water setting knob.
1. Check for malfunction of the thermistor.
Replace, if necessary.
1. Check the rotation of the pump.
1. Purge air.
1. Check the power supply line and contactor.
Repair, if necessary.
1. Check for refrigerant leakage and faulty
solenoid valve for liquid bypass.
1. Check the contact of the internal
thermostat during the cold condition.
1. See High Discharge Pressure and Low
Suction Pressure.
1. See High Discharge Pressure and Low
Suction Pressure.
1. Readjust the setting.
1. Adjust unload mechanism. Repair or
replace unloaded parts, if necessary.
1. Check the superheat of suction gas. Keep
the superheat in proper range.
1. Check for the sound of internal parts.
Replace the compressor, if necessary.
1. Tighten the screws of all parts.
1. Adjust the setting temperature.
2. Replace the thermistor.
1. Check the coil in the solenoid valve.
2. Check oil passage for clogging.
1. Check the unloaded system parts in the
compressor.
1. Check the fan operation.
2. Check for coil clogging; clean, if
necessary.
1. Check the valves, capillary tubes and
strainer. Replace, if necessary.
1. Purge the refrigerant.
1. Purge the gas from the refrigerant cycle.
1.
1.
1.
1.
1.
1.
2.
1.
1.
1.
1.
1.
1.
GENERAL SPECIFICATIONS
13/55
RCUE40AG1
RCUE50AG1
RCUE60AG1
RCUE70AG1
Cooling Capacity
KW
108
126
156
178
KW
41,1
48,1
59,3
68,4
2,63
2,62
2,63
2,60
Height
Mm
2.430
2.430
2.430
2,430
Width
Mm
1.800
1.800
1.800
1,800
Depth
Mm
2.050
2.050
2.050
2,050
1.760
1.780
COP
Outer Dimension
Cabinet Colour
Net Weight
Compressor Type
Natural Gray
Kg
1.530
1.590
Model
4005SC-Z
4005SC-Z
5005SC-Z
6005SC-Z
Quantity
150
150
150
150
Oil Heater
Capacity Control
33~100
25~100
Condenser Type
KW
0.4 (6)
0.4 (6)
0.4 (6)
0.4 (6)
Refrigerant Type
R407C(Factory Charged)
Flow Control
Number of Independent
Circuits
Oil Type
Inch
Control System
Micro-Processor Control
5~15
5~43 (Option:-15~43)
MPa
1.0
Power Supply
25~100
Reverse Phase Protection Device, Fuse and Thermal Relay for Compressor,
Internal Thermostat for Compressor, Compressor Oil Heater,
Fuse and internal Thermostat for Fan Motor, Control Circuit Fuse,
High Pressure Switch, Low Pressure Control, High Pressure Relief Valve,
Discharge Gas Temperature Control, Suction Gas Temperature Control, Freeze
Proctection Control and Compressor Operation Hour Meter
3~,N/380-415V/50Hz
NOTE:
The nominal cooling capacities are based on the European Standard EN12055.
- Chilled Water Inlet/Outlet Temperature: 12/7 C
- Condenser Inlet Air Temperature: 35 C
- Cooling Capacity and total power input data at 40~43C are available at distributor side
RCUE80AG1
RCUE100AG1
RCUE120AG1
RCUE140AG1
Cooling Capacity
KW
216
252
312
356
KW
82,2
96,2
118,6
136,7
2,63
2,62
2,63
2.60
COP
Outer Dimension
Height
Mm
2.430
2.430
2.430
2,430
Width
Mm
1.800
1.800
1.800
1,800
Depth
Mm
3.850
3.850
3.850
3,850
3.220
3.260
Cabinet Colour
Net Weight
Compressor Type
Natural Gray
Kg
2.760
2.880
Model
4005SC-Z
4005SC-Z
5005SC-Z
6005SC-Z
Quantity
150x2
150x2
150x2
150x2
Oil Heater
Capacity Control
16.7, 33~100
12.5, 25~100
Condenser Type
KW
0.4 (6)
0.4 (6)
0.4 (6)
0.4 (6)
Refrigerant Type
R407C(Factory Charged)
Flow Control
Oil Type
Inch
Control System
Micro-Processor Control
5 15
5~43 (Option:-15~43)
MPa
1.0
12.5, 25~100
Power Supply
Reverse Phase Protection Device, Fuse and Thermal Relay for Compressor,
Internal Thermostat for Compressor, Compressor Oil Heater,
Fuse and Internal Thermostat for Fan Motor, Control Circuit Fuse,
High Pressure Switch, Low Pressure Control, High Pressure Relief Valve,
Discharge Gas Temperature Control, Suction Gas Temperature Control,
Freeze Protection Control and Compressor Operation Hour Meter
3~,N/380-415V/50Hz
NOTE:
The nominal cooling capacities are based on the European Standard EN12055.
- Chilled Water Inlet/Outlet Temperature: 12/7 C
- Condenser Inlet Air Temperature: 35 C
- Cooling capacity and total power input data at 40~43C are available at distributor side
GENERAL SPECIFICATIONS
Model (R407C)
13/57
Cooling Capacity
KW
378
468
534
624
712
KW
144,3
177,9
205,1
237,2
273,4
2,62
2,63
2,60
2,63
2,60
Height
Mm
2.430
2.430
2.430
2.430
2,430
Width
Mm
1.800
1.800
1.800
1.800
1,800
Depth
Mm
5.650
5.650
5.650
7.450
7,450
6.140
6.220
COP
Outer Dimension
Cabinet Colour
Net Weight
Compressor Type
Natural Gray
Kg
4.270
4.680
4.740
Semi-Hermetic Screw Type
Model
4005SC-Z
5005SC-Z
6005SC-Z
5005SC-Z
6005SC-Z
Quantity
150x3
150x3
150x3
150x4
150x4
Oil Heater
Capacity Control
8.3, 25~100
8.3, 25~100
12.5, 25~100
Condenser Type
KW
0.4 (6)
0.4 (6)
0.4 (6)
0.4 (6)
0.4 (6)
12
12
12
16
16
Refrigerant Type
R407C(Factory Charged)
Flow Control
Oil Type
Inch
Control System
Micro-Processor Control
5 15
5~43 (Option:-15~43)
MPa
1.0
12.5, 25~100
Power Supply
Reverse Phase Protection Device, Fuse and Thermal Relay for Compressor,
Internal Thermostat for Compressor, Compressor Oil Heater,
Fuse and Internal Thermostat for Fan Motor, Control Circuit Fuse,
High Pressure Switch, Low Pressure Control, High Pressure Relief Valve,
Discharge Gas Temperature Control, Suction Gas Temperature Control,
Freeze Protection Control and Compressor Operation Hour Meter
3~,N/380-415V/50Hz
NOTE:
The nominal cooling capacities are based on the European Standard EN12055.
- Chilled Water Inlet/Outlet Temperature: 12/7 C
- Condenser Inlet Air Temperature: 35 C
- Cooling capacity and total power input data at 40~43C are available at distributor side
RCUE300AG1
RCUE330AG1
RCUE360AG1
RCUE400AG1
Cooling Capacity
kW
780
890
936
1.068
kW
296,5
341,8
355,8
410,1
2,63
2,60
2,63
2.60
COP
Outer Dimension
Height
mm
2.430
2.430
2.430
2,430
Width
mm
1.800
1.800
1.800
1,800
Depth
mm
9.250
9.250
11.050
11,050
9.050
9.170
Cabinet Colour
Net Weight
Compressor Type
Natural Gray
kg
7.600
7.700
Model
5005SC-Z
6005SC-Z
5005SC-Z
6005SC-Z
Quantity
150x5
150x5
150x6
150x6
Oil Heater
Capacity Control
Water Cooler Type
12.5, 25~100
12.5, 25~100
12.5, 25~100
Condenser Type
kW
0.4 (6)
0.4 (6)
0.4 (6)
0.4 (6)
20
20
24
24
Quantity
Refrigerant Type
R407C(Factory Charged)
Flow Control
Oil Type
Inch
Control System
Micro-Processor Control
5 15
5~43 (Option:-15~43)
MPa
1.0
Power Supply
Reverse Phase Protection Device, Fuse and Thermal Relay for Compressor,
Internal Thermostat for Compressor, Compressor Oil Heater,
Fuse and Internal Thermostat for Fan Motor, Control Circuit Fuse,
High Pressure Switch, Low Pressure Control, High Pressure Relief Valve,
Discharge Gas Temperature Control, Suction Gas Temperature Control,
Freeze Protection Control and Compressor Operation Hour Meter
3~,N/380-415V/50Hz
NOTE:
The nominal cooling capacities are based on the European Standard EN12055.
- Chilled Water Inlet/Outlet Temperature: 12/7 C
- Condenser Inlet Air Temperature: 35 C
- Cooling capacity and total power input data at 40~43C are available at distributor side
DRAWINGS
14/59
14. DRAWINGS
14.1. DIMENSIONAL DRAWING
RCUE 40AG1, RCUE 50AG1, RCUE 60AG1, RCUE 70AG1
Model
RCUE 40AG1
RCUE 50AG1
RCUE 60AG1
RCUE 70AG1
Air Outlet
Air Outlet
Electrical Box
Air Inlet
Air Inlet
Air Inlet
Water Inlet
Water Inlet
(3B Victaulic)
(Rear Side)
(Both Side)
Water Outlet
(Rear Side)
Rigging Holes
(4-50)
Removable
Mounting Holes
(4- 26)
Water Outlet
(3B Victaulic)
Air Outlet
Air Outlet
Air Outlet
Electrical Box
Air Inlet
Air Inlet
Air Inlet
Water Inlet
(4B Victaulic)
Water Inlet
(Rear Side)
(Both Side)
Water Outlet
(Rear Side)
Rigging Holes
(4-50)
Removable
Mounting Holes
(6- 26)
Water Outlet
(4B Victaulic)
14/60 DRAWINGS
RCUE 150AG1, RCUE 180AG1, RCUE 200AG1
Model
RCUE 150AG1
RCUE 180AG1
RCUE 200AG1
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Electrical Box
Air Inlet
Air Inlet
Air Inlet
4B Vitaulic
Water Inlet
(Both Side)
Water Inlet
(Rear Side)
Water Inlet
(Rear Side)
Water Outlet
(Rear Side)
Water Outlet
(Rear Side)
Rigging Holes
(4-50)
Removable
Water Outlet
4B Vitaulic
Mounting Holes
(8- 26)
Model
RCUE 240AG1
RCUE 270AG1
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Electrical Box
Air Inlet
Air Inlet
Air Inlet
4B Vitaulic
Water Inlet
Water Inlet
(Rear Side)
Water Inlet
(Rear Side)
Water Outlet
(Rear Side)
Water Outlet
(Rear Side)
Rigging Holes
(8-50)
Removable
Mounting Holes
(10- 26)
Water Outlet
4B Vitaulic
DRAWINGS
14/61
Air Outlet
Air Outlet
Electrical Box
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Inlet
Air Inlet Air Inlet
4B Vitaulic
Water Inlet
Water Inlet
(Rear Side)
Water Inlet
(Rear Side)
Water Outlet
(Rear Side)
Water Outlet
(Rear Side)
Water Inlet
(Rear Side)
Rigging Holes
(8-50)
Water Outlet
(Rear Side)
Removable
Water Outlet
4B Vitaulic
Mounting Holes
(12- 26)
(Both Side)
Model
RCUE 360AG1
RCUE 400AG1
Electrical Box
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Outlet
Air Inlet
Air Inlet
Air Inlet
4B Vitaulic
Water Inlet
Water Inlet
(Rear Side)
Water Inlet
(Rear Side)
Water Inlet
(Rear Side)
Water Outlet
(Rear Side)
Water Outlet
(Rear Side)
Water Outlet
(Rear Side)
Rigging Holes
Mounting Holes
(10- 26)
(8-50)
Removable
Water Outlet
4B Vitaulic
14/62 DRAWINGS
14.2. WIRING DIAGRAM
POWER CIRCUIT
Main Switch
(OPTION)
(OPTION)
RCUE 70AG1
RCUE 60AG1
RCUE 50AG1
RCUE 40AG1
Models
POWER CIRCUIT FOR RCUE 40AG1, RCUE 50AG1, RCUE 60AG1, RCUE 70AG1
DRAWINGS
POWER CIRCUIT
Main Switch
RCUE 140AG1
RCUE 120AG1
RCUE 100AG1
RCUE 80AG1
Models
POWER CIRCUIT FOR RCUE 80AG1, RCUE 100AG1, RCUE 120AG1, RCUE 140AG1
14/63
14/64 DRAWINGS
Main Switch
POWER CIRCUIT
RCUE 200AG1
RCUE 180AG1
RCUE 150AG1
Models
DRAWINGS
Main Switch
POWER CIRCUIT
RCUE 270AG1
RCUE 240AG1
Models
14/65
14/66 DRAWINGS
Main Switch
POWER CIRCUIT
RCUE 330AG1
RCUE 300AG1
Models
DRAWINGS
Main Switch
POWER CIRCUIT
RCUE 400AG1
RCUE 360AG1
Models
14/67
CONTROL CIRCUIT
FAN SPEED
CTRL (OPTION)
RCUIE 70AG1
RCUE 60AG1
RCUE 50AG1
RCUE 40AG1
Models
14/68 DRAWINGS
CONTROL CIRCUIT FOR RCUE 40AG1, RCUE 50AG1, RCUE 60AG1, RCUE 70AG1
CONTROL CIRCUIT
FAN SPEED
CTRL. (OPTION)
RCUE 140AG1
RCUE 120AG1
RCUE 100AG1
RCUE 80AG1
Models
DRAWINGS
CONTROL CIRCUIT FOR RCUE 80AG1, RCUE 100AG1, RCUE 120AG1, RCUE 140AG1
14/69
CONTROL CIRCUIT
FAN SPEED
CTRL. (OPTION)
RCUE 200AG1
RCUE 180AG1
RCUE 150AG1
Models
14/70 DRAWINGS
CONTROL CIRCUIT
FAN SPEED
CTRL. (OPTION)
RCUE 270AG1
RCUE 240AG1
Models
DRAWINGS
14/71
RCUE 330AG1
RCUE 300AG1
Models
CONTROL CIRCUIT
FAN SPEED
CTRL. (OPTION)
FAN SPEED
CTRL. (OPTION)
14/72 DRAWINGS
RCUE 400AG1
RCUE 360AG1
Models
CONTROL CIRCUIT
FAN SPEED
CTRL. (OPTION)
FAN SPEED
CTRL. (OPTION)
DRAWINGS
14/73
ALARM
OPERATION
OPERATION
POWER
(CHECK)
BMS
CONNECTION
FAN SPEED
CTRL. (OPTION)
Differential Water
14/74 DRAWINGS
Fan Speed
Ctrl. (option)
PCBC - MASTER
(only RCUE 300AG1400AG1)
RCUE 400AG1
RCUE 360AG1
RCUE 330AG1
RCUE 300AG1
Model
DRAWINGS
14/75
(OPTION)
DUMMY
THERMI
DM-1
(ONLY)
RCUE 240,270AG1
RCUE 150,180,200AG1
RCUE 80,100,120,140AG1
RCUE 40,50,60,70AG1
Model
14/76 DRAWINGS
(OPTION)
(ONLY)
RCUE 360,400AG1
RCUE 300,330AG1
Model
DRAWINGS
14/77
Pump
operation
R Phase
Neutral
2,3,4,5,6 Cycles
NOTE:
1. All the setting shall be performed before Power ON.
2. Remote/Local Change over Switch on Operation Switch shall be set to "Remote".
3. Terminals 1! 17 ! are for AC220-240V Terminals A! D ! are for DC24V.
Pump
Interlock
R Phase
CUSTOMER WIRING
Customer Wiring
3,4,5,6 Cycles
4,5,6 Cycles
ON/OFF
MODE 2
(Pulse)
MODE1
(Hi / Lo)
min.100ms
min.100ms
Hi
Lo ON
OFF
NORMAL
MODE
(No Low Voltage Control)
MODE
ALARM
LAMP
ALARM
SIGNAL DC24V
5,6 Cycles
6 Cycles
RUN/STOP
SIGNAL
LOW VOLTAGE
REMOTE CONTROL
14/78 DRAWINGS
CUSTOMER WIRING
DRAWINGS
14/79
PARTS LIST
Mark
Name
MC1-n
Compressor Motor
THMs1-n
MF11-n4
MI
CMC1-n
THMI1-n
EF1~3, R,S,T
SV11-n1
Name
Suction Gas Temperature
Thermistor
Liquid Temperature Thermistor
Fuse
Solenoid Valve for Starting
SV12-n2
SV13-n3
TM1-n
Hour Meter
CMCs1-sn
CMCD1-Dn
CMF11-n4
Remark
or optional
Circuit Breaker
EFC1-n
ORC1-n
EFF11-n4
ITC1-n
Mark
PCBA
PCBB
or optional
Circuit Breaker
PCBD1-Dn
ITF11-n4
PCBE1-En
CH1-n
Crankcase Heater
WP
AR1-n,H,R
Auxiliary Relay
PBSR1
PSH1-n
Pd1-n
RL
Ps1-n
OL1-n
PBSR2
THMr2 1-n
THMd 1-n
PSW n
PFC1-n
THMi
THM01,
02,03
PFF1-n
THMa
Or optional
Circuit Breaker
Or optional
Circuit Breaker
OPTION
OPTION
OPTION
CMP
TRP
SVEn
EHF1-n
Cooler Heater
TF1,2,3,4,5
Transformers
Model
RCUE 40, 50, 60, 70AG1
RCUE 80, 100, 120,140AG1
RCUE 150, 180, 200AG1
RCUE 240, 270AG1
RCUE 300,330AG1
RCUE 360,400AG1
OPTION
6A
PCBC1,C2
OFF: 2.74Mpa
ON: Manual
Reset
(n=1~N)
Remark
N
1
2
3
4
5
6
Field
Supplied
30 C
7 C
12 C
250 kW
R407C
PD:
Q:
,
PD = x Q
Pressure Drop (kPa)
Water Flow (m/h)
Parameters (table below)
260.8 kW
44.9 m/h
39.4 kPa
71.6 kW
Fouling Factor
2
m hC/kcal
2
(m C/kW)
Kfc
Kfi
1.00
1.00
0.00005(0.044)
1.00
1.00
0.0001(0.088)
0.99
1.01
Model:
RCUE-AG1
40
50
60,70
80
100
120,140
150
180, 200
240, 270
300, 330
360,400
0.1730
0.1220
0.0878
0.0459
0.0308
0.0280
0.0150
0.0127
0.0079
0.0054
0.0038
1.846
1.840
1.840
1.875
1.881
1.826
1.867
1.831
1.826
1.828
1.826
MODEL SELECTION
15/81
CAP
114,2
117,6
121,0
124,3
127,7
131,1
134,5
137,8
141,2
144,6
148,0
107,7
111,1
114,5
117,9
121,2
124,6
128,0
131,4
134,7
138,1
141,5
104,5
107,9
111,2
114,6
118,0
121,4
124,7
128,1
131,5
134,9
138,2
101,3
104,6
108,0
111,4
114,8
118,1
121,5
124,9
128,3
131,6
135,0
98,0
101,4
104,8
108,1
111,5
114,9
118,3
121,6
125,0
128,4
131,8
94,8
98,1
101,5
104,9
108,3
111,6
115,0
118,4
121,8
125,1
128,5
RCUE40AG1
CFR CPD
19,6 42,2
20,2 44,5
20,8 46,9
21,4 49,4
22,0 51,9
22,5 54,4
23,1 57,0
23,7 59,7
24,3 62,4
24,9 65,2
25,4 68,1
18,5 37,9
19,1 40,1
19,7 42,4
20,3 44,7
20,9 47,1
21,4 49,6
22,0 52,1
22,6 54,6
23,2 57,3
23,8 59,9
24,3 62,7
18,0 35,8
18,6 38,0
19,1 40,2
19,7 42,5
20,3 44,8
20,9 47,2
21,5 49,7
22,0 52,2
22,6 54,7
23,2 57,4
23,8 60,0
17,4 33,8
18,0 35,9
18,6 38,1
19,2 40,3
19,7 42,6
20,3 44,9
20,9 47,3
21,5 49,8
22,1 52,3
22,6 54,8
23,2 57,5
16,9 31,8
17,4 33,9
18,0 36,0
18,6 38,2
19,2 40,4
19,8 42,7
20,3 45,0
20,9 47,4
21,5 49,9
22,1 52,4
22,7 54,9
16,3 29,9
16,9 31,9
17,5 34,0
18,0 36,1
18,6 38,2
19,2 40,5
19,8 42,8
20,4 45,1
20,9 47,5
21,5 50,0
22,1 52,5
IPT
32,1
32,4
32,6
32,9
33,2
33,5
33,8
34,0
34,3
34,6
34,9
33,8
34,3
34,9
35,4
36,0
36,5
37,1
37,7
38,2
38,8
39,3
34,4
35,1
35,8
36,4
37,1
37,8
38,4
39,1
39,8
40,4
41,1
35,4
36,3
37,1
37,9
38,8
39,6
40,4
41,3
42,1
42,9
43,8
37,0
37,9
38,9
39,8
40,8
41,7
42,7
43,6
44,6
45,5
46,4
39,3
40,4
41,6
42,7
43,8
44,9
46,0
47,1
48,2
49,3
50,5
Where,
ABT:
Condenser Air Inlet Temperature (C)
COT:
Chilled Water Outlet Temperature (C)
CAP:
Cooling Capacity (kW)
CAP
133,2
137,2
141,1
145,1
149,0
152,9
156,9
160,8
164,7
168,7
172,6
125,7
129,6
133,6
137,5
141,4
145,4
149,3
153,2
157,2
161,1
165,1
121,9
125,8
129,8
133,7
137,7
141,6
145,5
149,5
153,4
157,3
161,3
118,1
122,1
126,0
129,9
133,9
137,8
141,8
145,7
149,6
153,6
157,5
114,3
118,3
122,2
126,2
130,1
134,0
138,0
141,9
145,8
149,8
153,7
110,6
114,5
118,4
122,4
126,3
130,3
134,2
138,1
142,1
146,0
149,9
RCUE50AG1
CFR CPD
22,9 38,8
23,6 41,0
24,3 43,1
24,9 45,4
25,6 47,7
26,3 50,0
27,0 52,4
27,7 54,9
28,3 57,4
29,0 59,9
29,7 62,5
21,6 34,9
22,3 36,9
23,0 39,0
23,6 41,1
24,3 43,3
25,0 45,6
25,7 47,9
26,4 50,2
27,0 52,6
27,7 55,1
28,4 57,6
21,0 33,0
21,6 34,9
22,3 37,0
23,0 39,1
23,7 41,2
24,4 43,4
25,0 45,7
25,7 48,0
26,4 50,3
27,1 52,7
27,7 55,2
20,3 31,1
21,0 33,0
21,7 35,0
22,3 37,1
23,0 39,2
23,7 41,3
24,4 43,5
25,1 45,8
25,7 48,1
26,4 50,4
27,1 52,8
19,7 29,3
20,3 31,2
21,0 33,1
21,7 35,1
22,4 37,2
23,1 39,2
23,7 41,4
24,4 43,6
25,1 45,8
25,8 48,1
26,4 50,5
19,0 27,5
19,7 29,4
20,4 31,3
21,0 33,2
21,7 35,2
22,4 37,2
23,1 39,3
23,8 41,5
24,4 43,7
25,1 45,9
25,8 48,2
IPT
38,1
38,5
38,8
39,1
39,5
39,8
40,1
40,5
40,8
41,1
41,5
40,1
40,8
41,5
42,1
42,8
43,4
44,1
44,8
45,4
46,1
46,7
40,9
41,7
42,5
43,3
44,1
44,9
45,7
46,5
47,3
48,1
48,9
42,1
43,1
44,1
45,1
46,1
47,1
48,1
49,1
50,1
51,0
52,0
44,0
45,1
46,2
47,3
48,5
49,6
50,7
51,8
53,0
54,1
55,2
46,7
48,1
49,4
50,7
52,0
53,4
54,7
56,0
57,3
58,7
60,0
CAP
165,0
169,8
174,7
179,6
184,5
189,3
194,2
199,1
204,0
208,8
213,7
155,6
160,5
165,4
170,2
175,1
180,0
184,9
189,7
194,6
199,5
204,4
150,9
155,8
160,7
165,6
170,4
175,3
180,2
185,1
189,9
194,8
199,7
146,3
151,1
156,0
160,9
165,8
170,6
175,5
180,4
185,3
190,1
195,0
141,6
146,4
151,3
156,2
161,1
165,9
170,8
175,7
180,6
185,4
190,3
136,9
141,8
146,6
151,5
156,4
161,3
166,1
171,0
175,9
180,8
185,6
RCUE60AG1
CFR CPD
28,4 41,4
29,2 43,7
30,1 46,0
30,9 48,4
31,7 50,8
32,6 53,3
33,4 55,9
34,2 58,5
35,1 61,2
35,9 63,9
36,8 66,6
26,8 37,2
27,6 39,3
28,4 41,6
29,3 43,9
30,1 46,2
31,0 48,6
31,8 51,0
32,6 53,5
33,5 56,1
34,3 58,7
35,1 61,4
26,0 35,1
26,8 37,3
27,6 39,4
28,5 41,7
29,3 43,9
30,2 46,3
31,0 48,7
31,8 51,1
32,7 53,6
33,5 56,2
34,3 58,8
25,2 33,2
26,0 35,2
26,8 37,3
27,7 39,5
28,5 41,8
29,3 44,0
30,2 46,4
31,0 48,8
31,9 51,2
32,7 53,7
33,5 56,3
24,4 31,2
25,2 33,2
26,0 35,3
26,9 37,4
27,7 39,6
28,5 41,8
29,4 44,1
30,2 46,5
31,1 48,9
31,9 51,3
32,7 53,8
23,5 29,4
24,4 31,3
25,2 33,3
26,1 35,4
26,9 37,5
27,7 39,7
28,6 41,9
29,4 44,2
30,3 46,6
31,1 49,0
31,9 51,4
3
CFR: Chilled Water Flow Rate at 5C (m /h)
CPD:
Water Cooler Pressure Drop (kPa)
IPT:
Compressor Input Power (kW)
IPT
47,7
48,1
48,5
48,9
49,3
49,7
50,1
50,6
51,0
51,4
51,8
50,1
51,0
51,8
52,6
53,4
54,3
55,1
55,9
56,8
57,6
58,4
51,1
52,1
53,1
54,1
55,1
56,1
57,1
58,1
59,1
60,1
61,1
52,6
53,9
55,1
56,3
57,6
58,8
60,1
61,3
62,5
63,8
65,0
54,9
56,3
57,7
59,1
60,6
62,0
63,4
64,8
66,2
67,6
69,0
58,4
60,1
61,7
63,4
65,0
66,7
68,3
70,0
71,6
73,3
74,9
CAP
188,2
193,8
199,4
204,9
210,5
216,0
221,6
227,2
232,7
238,3
243,9
177,6
183,1
188,7
194,2
199,8
205,4
210,9
216,5
222,1
227,6
233,2
172,2
177,8
183,3
188,9
194,5
200,0
205,6
211,2
216,7
222,3
227,8
166,9
172,4
178,0
183,6
189,1
194,7
200,3
205,8
211,4
216,9
222,5
161,5
167,1
172,7
178,2
183,8
189,3
194,9
200,5
206,0
211,6
217,2
156,2
161,8
167,3
172,9
178,4
184,0
189,6
195,1
200,7
206,3
211,8
RCUE70AG1
CFR CPD
32,4
52,8
33,3
55,7
34,3
58,6
35,2
61,7
36,2
64,8
37,2
68,0
38,1
71,2
39,1
74,6
40,0
78,0
41,0
81,4
41,9
85,0
30,5
47,4
31,5
50,2
32,5
53,0
33,4
55,9
34,4
58,9
35,3
61,9
36,3
65,1
37,2
68,2
38,2
71,5
39,2
74,8
40,1
78,2
29,6
44,8
30,6
47,5
31,5
50,3
32,5
53,1
33,4
56,0
34,4
59,0
35,4
62,1
36,3
65,2
37,3
68,4
38,2
71,6
39,2
75,0
28,7
42,3
29,7
44,9
30,6
47,6
31,6
50,4
32,5
53,2
33,5
56,1
34,4
59,1
35,4
62,2
36,4
65,3
37,3
68,5
38,3
71,8
27,8
39,8
28,7
42,4
29,7
45,0
30,7
47,7
31,6
50,5
32,6
53,3
33,5
56,3
34,5
59,2
35,4
62,3
36,4
65,4
37,4
68,6
26,9
37,4
27,8
39,9
28,8
42,5
29,7
45,1
30,7
47,8
31,6
50,6
32,6
53,5
33,6
56,4
34,5
59,4
35,5
62,4
36,4
65,6
Conversion Multiplier:
1 kW = 860 kcal/h
= 3412 Btu/h
1 kPa = 0.102 mAq
IPT
55,5
56,0
56,5
57,0
57,5
57,9
58,4
58,9
59,4
59,9
60,3
58,4
59,4
60,3
61,3
62,3
63,2
64,2
65,2
66,1
67,1
68,1
59,6
60,7
61,9
63,0
64,2
65,4
66,5
67,7
68,8
70,0
71,1
61,3
62,8
64,2
65,6
67,1
68,5
70,0
71,4
72,9
74,3
75,8
64,0
65,6
67,3
68,9
70,6
72,2
73,8
75,5
77,1
78,7
80,4
68,1
70,0
71,9
73,8
75,8
77,7
79,6
81,5
83,5
85,4
87,3
CAP
228,4
235,2
241,9
248,7
255,4
262,2
268,9
275,7
282,4
289,2
295,9
215,5
222,2
229,0
235,7
242,5
249,2
256,0
262,7
269,5
276,2
283,0
209,0
215,7
222,5
229,2
236,0
242,7
249,5
256,2
263,0
269,7
276,5
202,5
209,3
216,0
222,8
229,5
236,3
243,0
249,8
256,5
263,3
270,0
196,0
202,8
209,5
216,3
223,0
229,8
236,5
243,3
250,0
256,8
263,5
189,5
196,3
203,0
209,8
216,5
223,3
230,0
236,8
243,5
250,3
257,0
RCUE80AG1
CFR CPD
39,3 44,8
40,4 47,3
41,6 49,9
42,8 52,5
43,9 55,2
45,1 58,0
46,3 60,8
47,4 63,7
48,6 66,7
49,7 69,7
50,9 72,8
37,1 40,1
38,2 42,5
39,4 45,0
40,5 47,5
41,7 50,1
42,9 52,7
44,0 55,4
45,2 58,2
46,3 61,0
47,5 63,9
48,7 66,9
35,9 37,9
37,1 40,2
38,3 42,6
39,4 45,1
40,6 47,6
41,7 50,2
42,9 52,8
44,1 55,5
45,2 58,3
46,4 61,2
47,6 64,1
34,8 35,7
36,0 38,0
37,2 40,3
38,3 42,7
39,5 45,2
40,6 47,7
41,8 50,3
43,0 52,9
44,1 55,7
45,3 58,4
46,4 61,3
33,7 33,6
34,9 35,8
36,0 38,1
37,2 40,4
38,4 42,8
39,5 45,3
40,7 47,8
41,8 50,4
43,0 53,0
44,2 55,8
45,3 58,5
32,6 31,6
33,8 33,7
34,9 35,9
36,1 38,2
37,2 40,5
38,4 42,9
39,6 45,4
40,7 47,9
41,9 50,5
43,0 53,2
44,2 55,9
IPT
64,2
64,7
65,3
65,9
66,4
67,0
67,5
68,1
68,6
69,2
69,7
67,5
68,6
69,7
70,9
72,0
73,1
74,2
75,3
76,4
77,5
78,7
68,9
70,2
71,5
72,9
74,2
75,5
76,9
78,2
79,5
80,9
82,2
70,9
72,5
74,2
75,9
77,5
79,2
80,9
82,5
84,2
85,9
87,6
74,0
75,9
77,8
79,7
81,5
83,4
85,3
87,2
89,1
91,0
92,9
78,7
80,9
83,1
85,3
87,6
89,8
92,0
94,2
96,5
98,7
100,9
Where,
ABT:
Condenser Air Inlet Temperature (C)
COT:
Chilled Water Outlet Temperature (C)
CAP:
Cooling Capacity (kW)
CAP
266,5
274,4
282,2
290,1
298,0
305,9
313,7
321,6
329,5
337,4
345,2
251,4
259,2
267,1
275,0
282,9
290,7
298,6
306,5
314,4
322,2
330,1
243,8
251,7
259,6
267,4
275,3
283,2
291,1
298,9
306,8
314,7
322,6
236,3
244,1
252,0
259,9
267,8
275,6
283,5
291,4
299,3
307,1
315,0
228,7
236,6
244,4
252,3
260,2
268,1
275,9
283,8
291,7
299,6
307,4
221,1
229,0
236,9
244,8
252,6
260,5
268,4
276,3
284,1
292,0
299,9
RCUE100AG1
CFR CPD
45,8 41,0
47,2 43,4
48,5 45,7
49,9 48,2
51,3 50,6
52,6 53,2
54,0 55,8
55,3 58,5
56,7 61,2
58,0 64,0
59,4 66,8
43,2 36,8
44,6 39,0
45,9 41,2
47,3 43,5
48,7 45,9
50,0 48,4
51,4 50,8
52,7 53,4
54,1 56,0
55,4 58,7
56,8 61,4
41,9 34,7
43,3 36,9
44,6 39,1
46,0 41,3
47,4 43,6
48,7 46,0
50,1 48,5
51,4 50,9
52,8 53,5
54,1 56,1
55,5 58,8
40,6 32,7
42,0 34,8
43,3 36,9
44,7 39,2
46,1 41,4
47,4 43,7
48,8 46,1
50,1 48,6
51,5 51,1
52,8 53,6
54,2 56,2
39,3 30,8
40,7 32,8
42,0 34,9
43,4 37,0
44,8 39,2
46,1 41,5
47,5 43,8
48,8 46,2
50,2 48,7
51,5 51,2
52,9 53,7
38,0 28,9
39,4 30,9
40,7 32,9
42,1 35,0
43,5 37,1
44,8 39,3
46,2 41,6
47,5 43,9
48,9 46,3
50,2 48,8
51,6 51,3
CFR:
CPD:
IPT:
IPT
76,3
77,0
77,6
78,3
78,9
79,6
80,3
80,9
81,6
82,2
82,9
80,3
81,6
82,9
84,2
85,6
86,9
88,2
89,5
90,8
92,2
93,5
81,8
83,4
85,0
86,6
88,2
89,8
91,4
93,0
94,6
96,1
97,7
84,2
86,2
88,2
90,2
92,2
94,2
96,1
98,1
100,1
102,1
104,1
87,9
90,2
92,4
94,7
96,9
99,2
101,4
103,7
105,9
108,2
110,4
93,5
96,1
98,8
101,4
104,1
106,7
109,4
112,0
114,7
117,3
120,0
CAP
329,9
339,7
349,4
359,2
368,9
378,7
388,4
398,2
407,9
417,7
427,4
311,2
321,0
330,7
340,5
350,2
360,0
369,7
379,5
389,2
399,0
408,7
301,9
311,6
321,4
331,1
340,9
350,6
360,4
370,1
379,9
389,6
399,4
292,5
302,3
312,0
321,8
331,5
341,3
351,0
360,8
370,5
380,3
390,0
283,1
292,9
302,6
312,4
322,1
331,9
341,6
351,4
361,1
370,9
380,6
273,8
283,5
293,3
303,0
312,8
322,5
332,3
342,0
351,8
361,5
371,3
RCUE120AG1
CFR CPD IPT
56,7 44,7 95,2
58,4 47,1 96,1
60,1 49,6 96,9
61,8 52,2 97,7
63,5 54,8 98,5
65,1 57,4 99,4
66,8 60,2 100,2
68,5 63,0 101,0
70,2 65,8 101,8
71,8 68,7 102,7
73,5 71,6 103,5
53,5 40,1 100,2
55,2 42,5 101,8
56,9 44,9 103,5
58,6 47,3 105,1
60,2 49,8 106,8
61,9 52,4 108,4
63,6 55,0 110,1
65,3 57,7 111,8
66,9 60,4 113,4
68,6 63,2 115,1
70,3 66,0 116,7
51,9 38,0 102,2
53,6 40,2 104,2
55,3 42,6 106,1
57,0 44,9 108,1
58,6 47,4 110,1
60,3 49,9 112,1
62,0 52,5 114,1
63,7 55,1 116,0
65,3 57,8 118,0
67,0 60,5 120,0
68,7 63,3 122,0
50,3 35,8 105,1
52,0 38,1 107,6
53,7 40,3 110,1
55,3 42,7 112,6
57,0 45,0 115,1
58,7 47,5 117,5
60,4 50,0 120,0
62,0 52,6 122,5
63,7 55,2 125,0
65,4 57,9 127,4
67,1 60,6 129,9
48,7 33,8 109,8
50,4 35,9 112,6
52,1 38,1 115,4
53,7 40,4 118,2
55,4 42,7 121,0
57,1 45,1 123,8
58,8 47,6 126,6
60,4 50,1 129,4
62,1 52,7 132,2
63,8 55,3 135,0
65,5 58,0 137,8
47,1 31,8 116,7
48,8 33,9 120,0
50,4 36,0 123,3
52,1 38,2 126,6
53,8 40,5 129,9
55,5 42,8 133,2
57,2 45,2 136,5
58,8 47,7 139,8
60,5 50,2 143,1
62,2 52,8 146,4
63,9 55,4 149,7
3
Chilled Water Flow Rate at 5C (m /h)
Water Cooler Pressure Drop (kPa)
Compressor Input Power (kW)
CAP
376,5
387,6
398,7
409,8
421,0
432,1
443,2
454,3
465,5
476,6
487,7
355,1
366,2
377,4
388,5
399,6
410,7
421,9
433,0
444,1
455,2
466,4
344,4
355,6
366,7
377,8
388,9
400,1
411,2
422,3
433,4
444,6
455,7
333,8
344,9
356,0
367,1
378,3
389,4
400,5
411,6
422,8
433,9
445,0
323,1
334,2
345,3
356,4
367,6
378,7
389,8
400,9
412,1
423,2
434,3
312,4
323,5
334,6
345,8
356,9
368,0
379,1
390,3
401,4
412,5
423,6
RCUE140AG1
CFR CPD
64,8
56,8
66,7
59,9
68,6
63,1
70,5
66,4
72,4
69,7
74,3
73,1
76,2
76,6
78,1
80,1
80,1
83,7
82,0
87,4
83,9
91,2
61,1
51,1
63,0
54,0
64,9
57,1
66,8
60,2
68,7
63,4
70,6
66,6
72,6
70,0
74,5
73,4
76,4
76,8
78,3
80,4
80,2
84,0
59,2
48,3
61,2
51,2
63,1
54,2
65,0
57,2
66,9
60,3
68,8
63,5
70,7
66,8
72,6
70,1
74,5
73,5
76,5
77,0
78,4
80,5
57,4
45,6
59,3
48,4
61,2
51,3
63,1
54,3
65,1
57,3
67,0
60,4
68,9
63,6
70,8
66,9
72,7
70,2
74,6
73,6
76,5
77,1
55,6
43,0
57,5
45,7
59,4
48,5
61,3
51,4
63,2
54,4
65,1
57,4
67,0
60,6
69,0
63,7
70,9
67,0
72,8
70,4
74,7
73,8
53,7
40,4
55,6
43,1
57,6
45,8
59,5
48,6
61,4
51,5
63,3
54,5
65,2
57,6
67,1
60,7
69,0
63,9
71,0
67,1
72,9
70,5
Conversion Multiplier:
1 kW = 860 kcal/h
= 3412 Btu/h
1 kPa = 0.102 mAq
IPT
110,9
111,9
112,8
113,8
114,7
115,7
116,7
117,6
118,6
119,5
120,5
116,7
118,6
120,5
122,4
124,4
126,3
128,2
130,1
132,0
134,0
135,9
119,0
121,3
123,6
125,9
128,2
130,5
132,8
135,1
137,4
139,7
142,0
122,4
125,3
128,2
131,1
134,0
136,9
139,7
142,6
145,5
148,4
151,3
127,8
131,1
134,4
137,6
140,9
144,2
147,4
150,7
154,0
157,2
160,5
135,9
139,7
143,6
147,4
151,3
155,1
159,0
162,8
166,7
170,5
174,4
MODEL SELECTION
15/83
CAP
399,7
411,5
423,4
435,2
447,0
458,8
470,6
482,4
494,2
506,0
517,9
377,1
388,9
400,7
412,5
424,3
436,1
447,9
459,7
471,6
483,4
495,2
365,7
377,5
389,3
401,2
413,0
424,8
436,6
448,4
460,2
472,0
483,8
354,4
366,2
378,0
389,8
401,6
413,4
425,3
437,1
448,9
460,7
472,5
343,0
354,8
366,7
378,5
390,3
402,1
413,9
425,7
437,5
449,3
461,2
331,7
343,5
355,3
367,1
378,9
390,8
402,6
414,4
426,2
438,0
449,8
RCUE150AG1
CFR CPD
68,8 40,4
70,8 42,7
72,8 45,0
74,8 47,3
76,9 49,8
78,9 52,2
80,9 54,8
83,0 57,4
85,0 60,0
87,0 62,7
89,1 65,5
64,9 36,2
66,9 38,4
68,9 40,6
70,9 42,8
73,0 45,2
75,0 47,5
77,0 50,0
79,1 52,4
81,1 55,0
83,1 57,6
85,2 60,2
62,9 34,2
64,9 36,3
67,0 38,5
69,0 40,7
71,0 42,9
73,1 45,2
75,1 47,6
77,1 50,1
79,2 52,5
81,2 55,1
83,2 57,7
61,0 32,3
63,0 34,3
65,0 36,4
67,0 38,5
69,1 40,8
71,1 43,0
73,1 45,3
75,2 47,7
77,2 50,2
79,2 52,7
81,3 55,2
59,0 30,4
61,0 32,3
63,1 34,4
65,1 36,5
67,1 38,6
69,2 40,8
71,2 43,1
73,2 45,4
75,3 47,8
77,3 50,3
79,3 52,8
57,1 28,5
59,1 30,4
61,1 32,4
63,1 34,5
65,2 36,6
67,2 38,7
69,2 40,9
71,3 43,2
73,3 45,5
75,3 47,9
77,4 50,4
IPT
114,4
115,4
116,4
117,4
118,4
119,4
120,4
121,4
122,4
123,4
124,4
120,4
122,4
124,4
126,3
128,3
130,3
132,3
134,3
136,3
138,3
140,2
122,8
125,2
127,5
129,9
132,3
134,7
137,1
139,4
141,8
144,2
146,6
126,3
129,3
132,3
135,3
138,3
141,2
144,2
147,2
150,2
153,1
156,1
131,9
135,3
138,7
142,0
145,4
148,8
152,1
155,5
158,9
162,3
165,6
140,2
144,2
148,2
152,1
156,1
160,1
164,1
168,0
172,0
176,0
179,9
Where,
ABT:
Condenser Air Inlet Temperature (C)
COT:
Chilled Water Outlet Temperature (C)
CAP: Cooling Capacity (kW)
CAP
494,9
509,5
524,2
538,8
553,4
568,0
582,7
597,3
611,9
626,5
641,2
466,8
481,5
496,1
510,7
525,3
540,0
554,6
569,2
583,8
598,5
613,1
452,8
467,4
482,0
496,7
511,3
525,9
540,5
555,2
569,8
584,4
599,0
438,8
453,4
468,0
482,6
497,3
511,9
526,5
541,1
555,8
570,4
585,0
424,7
439,3
454,0
468,6
483,2
497,8
512,5
527,1
541,7
556,3
571,0
410,7
425,3
439,9
454,5
469,2
483,8
498,4
513,0
527,7
542,3
556,9
RCUE180AG1
CFR CPD
85,1 43,4
87,6 45,8
90,2 48,2
92,7 50,7
95,2 53,3
97,7 55,9
100,2 58,6
102,7 61,3
105,2 64,0
107,8 66,9
110,3 69,8
80,3 39,0
82,8 41,3
85,3 43,6
87,8 46,0
90,4 48,4
92,9 50,9
95,4 53,5
97,9 56,1
100,4 58,8
102,9 61,5
105,4 64,3
77,9 36,9
80,4 39,1
82,9 41,4
85,4 43,7
87,9 46,1
90,5 48,5
93,0 51,0
95,5 53,6
98,0 56,2
100,5 58,9
103,0 61,6
75,5 34,8
78,0 37,0
80,5 39,2
83,0 41,5
85,5 43,8
88,0 46,2
90,6 48,6
93,1 51,1
95,6 53,7
98,1 56,3
100,6 59,0
73,1 32,8
75,6 34,9
78,1 37,1
80,6 39,3
83,1 41,6
85,6 43,9
88,1 46,3
90,7 48,7
93,2 51,2
95,7 53,8
98,2 56,4
70,6 30,9
73,2 32,9
75,7 35,0
78,2 37,2
80,7 39,4
83,2 41,7
85,7 44,0
88,2 46,4
90,8 48,8
93,3 51,3
95,8 53,9
IPT
142,9
144,1
145,4
146,6
147,9
149,1
150,3
151,6
152,8
154,0
155,3
150,3
152,8
155,3
157,8
160,2
162,7
165,2
167,7
170,2
172,6
175,1
153,3
156,3
159,3
162,2
165,2
168,2
171,1
174,1
177,1
180,1
183,0
157,8
161,5
165,2
168,9
172,6
176,4
180,1
183,8
187,5
191,2
194,9
164,7
168,9
173,1
177,3
181,6
185,8
190,0
194,2
198,4
202,6
206,8
175,1
180,1
185,0
190,0
194,9
199,9
204,8
209,8
214,8
219,7
224,7
CAP
564,7
581,4
598,1
614,8
631,5
648,1
664,8
681,5
698,2
714,9
731,6
532,7
549,4
566,0
582,7
599,4
616,1
632,8
649,5
666,2
682,9
699,5
516,6
533,3
550,0
566,7
583,4
600,1
616,8
633,5
650,1
666,8
683,5
500,6
517,3
534,0
550,7
567,4
584,1
600,8
617,4
634,1
650,8
667,5
484,6
501,3
518,0
534,7
551,4
568,0
584,7
601,4
618,1
634,8
651,5
468,6
485,3
502,0
518,6
535,3
552,0
568,7
585,4
602,1
618,8
635,5
RCUE200AG1
CFR CPD IPT
97,1 55,3 166,4
100,0 58,3 167,9
102,9 61,4 169,3
105,7 64,6 170,8
108,6 67,8 172,2
111,5 71,2 173,6
114,4 74,5 175,1
117,2 78,0 176,5
120,1 81,5 178,0
123,0 85,1 179,4
125,8 88,8 180,9
91,6 49,7 175,1
94,5 52,6 178,0
97,4 55,5 180,9
100,2 58,6 183,7
103,1 61,7 186,6
106,0 64,9 189,5
108,8 68,1 192,4
111,7 71,4 195,3
114,6 74,8 198,2
117,5 78,3 201,1
120,3 81,8 203,9
88,9 47,0 178,5
91,7 49,8 182,0
94,6 52,7 185,5
97,5 55,6 188,9
100,3 58,7 192,4
103,2 61,8 195,9
106,1 65,0 199,3
109,0 68,2 202,8
111,8 71,6 206,3
114,7 75,0 209,7
117,6 78,4 213,2
86,1 44,3 183,7
89,0 47,1 188,1
91,8 49,9 192,4
94,7 52,8 196,7
97,6 55,8 201,1
100,5 58,8 205,4
103,3 61,9 209,7
106,2 65,1 214,0
109,1 68,4 218,4
111,9 71,7 222,7
114,8 75,1 227,0
83,4 41,8 191,8
86,2 44,5 196,7
89,1 47,2 201,6
92,0 50,0 206,5
94,8 52,9 211,4
97,7 55,9 216,4
100,6 58,9 221,3
103,4 62,0 226,2
106,3 65,2 231,1
109,2 68,5 236,0
112,1 71,8 240,9
80,6 39,3 203,9
83,5 41,9 209,7
86,3 44,6 215,5
89,2 47,3 221,3
92,1 50,1 227,0
94,9 53,0 232,8
97,8 56,0 238,6
100,7 59,1 244,3
103,6 62,2 250,1
106,4 65,4 255,9
109,3 68,6 261,7
3
CAP
659,9
679,4
698,9
718,4
737,9
757,4
776,9
796,4
815,9
835,4
854,9
622,4
641,9
661,4
680,9
700,4
719,9
739,4
758,9
778,4
797,9
817,4
603,7
623,2
642,7
662,2
681,7
701,2
720,7
740,2
759,7
779,2
798,7
585,0
604,5
624,0
643,5
663,0
682,5
702,0
721,5
741,0
760,5
780,0
566,3
585,8
605,3
624,8
644,3
663,8
683,3
702,8
722,3
741,8
761,3
547,6
567,1
586,6
606,1
625,6
645,1
664,6
684,1
703,6
723,1
742,6
RCUE240AG1
CFR CPD
113,5 44,7
116,9 47,1
120,2 49,6
123,6 52,2
126,9 54,8
130,3 57,5
133,6 60,2
137,0 63,0
140,3 65,8
143,7 68,7
147,0 71,7
107,1 40,2
110,4 42,5
113,8 44,9
117,1 47,3
120,5 49,8
123,8 52,4
127,2 55,0
130,5 57,7
133,9 60,4
137,2 63,2
140,6 66,0
103,8 38,0
107,2 40,2
110,5 42,6
113,9 45,0
117,3 47,4
120,6 49,9
124,0 52,5
127,3 55,1
130,7 57,8
134,0 60,5
137,4 63,3
100,6 35,9
104,0 38,1
107,3 40,3
110,7 42,7
114,0 45,1
117,4 47,5
120,7 50,0
124,1 52,6
127,5 55,2
130,8 57,9
134,2 60,6
97,4
33,8
100,8 35,9
104,1 38,2
107,5 40,4
110,8 42,8
114,2 45,2
117,5 47,6
120,9 50,1
124,2 52,7
127,6 55,3
130,9 58,0
94,2
31,8
97,5
33,9
100,9 36,0
104,2 38,2
107,6 40,5
111,0 42,9
114,3 45,3
117,7 47,7
121,0 50,2
124,4 52,8
127,7 55,4
Conversion Multiplier:
1 kW = 860 kcal/h
= 3412 Btu/h
1 kPa = 0.102 mAq
IPT
190,5
192,1
193,8
195,4
197,1
198,7
200,4
202,0
203,7
205,3
207,0
200,4
203,7
207,0
210,3
213,6
216,9
220,2
223,5
226,8
230,1
233,4
204,3
208,3
212,3
216,2
220,2
224,2
228,1
232,1
236,1
240,0
244,0
210,3
215,2
220,2
225,2
230,1
235,1
240,0
245,0
249,9
254,9
259,8
219,5
225,2
230,8
236,4
242,0
247,6
253,2
258,8
264,5
270,1
275,7
233,4
240,0
246,6
253,2
259,8
266,4
273,0
279,7
286,3
292,9
299,5
CAP
752,9
775,2
797,4
819,7
841,9
864,2
886,4
908,7
930,9
953,2
975,4
710,2
732,5
754,7
777,0
799,2
821,5
843,7
866,0
888,2
910,5
932,7
688,9
711,1
733,4
755,6
777,9
800,1
822,4
844,6
866,9
889,1
911,4
667,5
689,8
712,0
734,3
756,5
778,8
801,0
823,3
845,5
867,8
890,0
646,1
668,4
690,6
712,9
735,1
757,4
779,6
801,9
824,1
846,4
868,6
624,8
647,0
669,3
691,5
713,8
736,0
758,3
780,5
802,8
825,0
847,3
RCUE270AG1
CFR CPD
129,5 56,8
133,3 59,9
137,2 63,1
141,0 66,4
144,8 69,7
148,6 73,1
152,5 76,6
156,3 80,1
160,1 83,7
163,9 87,4
167,8 91,2
122,2 51,1
126,0 54,1
129,8 57,1
133,6 60,2
137,5 63,4
141,3 66,6
145,1 70,0
148,9 73,4
152,8 76,9
156,6 80,4
160,4 84,0
118,5 48,3
122,3 51,2
126,1 54,2
130,0 57,2
133,8 60,3
137,6 63,5
141,4 66,8
145,3 70,1
149,1 73,5
152,9 77,0
156,8 80,6
114,8 45,6
118,6 48,4
122,5 51,3
126,3 54,3
130,1 57,3
133,9 60,4
137,8 63,6
141,6 66,9
145,4 70,2
149,3 73,7
153,1 77,1
111,1 43,0
115,0 45,7
118,8 48,5
122,6 51,4
126,4 54,4
130,3 57,5
134,1 60,6
137,9 63,8
141,8 67,0
145,6 70,4
149,4 73,8
107,5 40,4
111,3 43,1
115,1 45,8
118,9 48,7
122,8 51,6
126,6 54,5
130,4 57,6
134,3 60,7
138,1 63,9
141,9 67,2
145,7 70,5
IPT
221,8
223,7
225,6
227,6
229,5
231,4
233,3
235,2
237,2
239,1
241,0
233,3
237,2
241,0
244,9
248,7
252,6
256,4
260,2
264,1
267,9
271,8
237,9
242,6
247,2
251,8
256,4
261,0
265,6
270,2
274,9
279,5
284,1
244,9
250,6
256,4
262,2
267,9
273,7
279,5
285,2
291,0
296,8
302,6
255,6
262,2
268,7
275,2
281,8
288,3
294,9
301,4
307,9
314,5
321,0
271,8
279,5
287,2
294,9
302,6
310,2
317,9
325,6
333,3
341,0
348,7
Where,
ABT:
Condenser Air Inlet Temperature (C)
COT:
Chilled Water Outlet Temperature (C)
CAP: Cooling Capacity (kW)
CAP
824,9
849,2
873,6
898,0
922,4
946,7
971,1
995,5
1019,9
1044,2
1068,6
778,1
802,4
826,8
851,2
875,6
899,9
924,3
948,7
973,1
997,4
1021,8
754,7
779,0
803,4
827,8
852,2
876,5
900,9
925,3
949,7
974,0
998,4
731,3
755,6
780,0
804,4
828,8
853,1
877,5
901,9
926,3
950,6
975,0
707,9
732,2
756,6
781,0
805,4
829,7
854,1
878,5
902,9
927,2
951,6
684,5
708,8
733,2
757,6
782,0
806,3
830,7
855,1
879,5
903,8
928,2
RCUE300AG1
CFR CPD
141,9 46,4
146,1 48,9
150,3 51,5
154,5 54,1
158,6 56,9
162,8 59,6
167,0 62,5
171,2 65,4
175,4 68,3
179,6 71,3
183,8 74,4
133,8 41,7
138,0 44,1
142,2 46,6
146,4 49,1
150,6 51,7
154,8 54,4
159,0 57,1
163,2 59,9
167,4 62,7
171,6 65,6
175,7 68,6
129,8 39,4
134,0 41,8
138,2 44,2
142,4 46,7
146,6 49,2
150,8 51,8
155,0 54,5
159,1 57,2
163,3 60,0
167,5 62,8
171,7 65,7
125,8 37,2
130,0 39,5
134,2 41,8
138,4 44,3
142,5 46,8
146,7 49,3
150,9 51,9
155,1 54,6
159,3 57,3
163,5 60,1
167,7 62,9
121,8 35,0
125,9 37,3
130,1 39,6
134,3 41,9
138,5 44,4
142,7 46,9
146,9 49,4
151,1 52,0
155,3 54,7
159,5 57,4
163,7 60,2
117,7 33,0
121,9 35,1
126,1 37,4
130,3 39,7
134,5 42,0
138,7 44,5
142,9 47,0
147,1 49,5
151,3 52,1
155,5 54,8
159,7 57,5
IPT
238,1
240,2
242,3
244,3
246,4
248,5
250,5
252,6
254,7
256,7
258,8
250,5
254,7
258,8
262,9
267,0
271,2
275,3
279,4
283,6
287,7
291,8
255,5
260,4
265,4
270,3
275,3
280,3
285,2
290,2
295,1
300,1
305,0
262,9
269,1
275,3
281,5
287,7
293,9
300,1
306,3
312,5
318,7
324,9
274,5
281,5
288,5
295,5
302,6
309,6
316,6
323,6
330,6
337,7
344,7
291,8
300,1
308,3
316,6
324,9
333,1
341,4
349,6
357,9
366,1
374,4
CAP
941,2
969,0
996,8
1024,6
1052,4
1080,2
1108,1
1135,9
1163,7
1191,5
1219,3
887,8
915,6
943,4
971,2
999,0
1026,8
1054,7
1082,5
1110,3
1138,1
1165,9
861,1
888,9
916,7
944,5
972,3
1000,1
1028,0
1055,8
1083,6
1111,4
1139,2
834,4
862,2
890,0
917,8
945,6
973,4
1001,3
1029,1
1056,9
1084,7
1112,5
807,7
835,5
863,3
891,1
918,9
946,7
974,6
1002,4
1030,2
1058,0
1085,8
781,0
808,8
836,6
864,4
892,2
920,0
947,9
975,7
1003,5
1031,3
1059,1
3
RCUE330AG1
CFR CPD IPT
161,9 59,0 277,3
166,7 62,2 279,7
171,4 65,5 282,1
176,2 68,9 284,5
181,0 72,4 286,9
185,8 75,9 289,3
190,6 79,5 291,7
195,4 83,2 294,2
200,2 87,0 296,6
204,9 90,8 299,0
209,7 94,7 301,4
152,7 53,0 291,7
157,5 56,1 296,6
162,3 59,2 301,4
167,0 62,5 306,2
171,8 65,8 311,0
176,6 69,2 315,8
181,4 72,6 320,6
186,2 76,2 325,4
191,0 79,8 330,2
195,8 83,5 335,0
200,5 87,3 339,8
148,1 50,1 297,5
152,9 53,1 303,3
157,7 56,2 309,1
162,5 59,4 314,8
167,2 62,6 320,6
172,0 65,9 326,4
176,8 69,3 332,1
181,6 72,8 337,9
186,4 76,3 343,7
191,2 79,9 349,5
195,9 83,6 355,2
143,5 47,3 306,2
148,3 50,3 313,4
153,1 53,3 320,6
157,9 56,3 327,8
162,6 59,5 335,0
167,4 62,7 342,2
172,2 66,1 349,5
177,0 69,5 356,7
181,8 72,9 363,9
186,6 76,5 371,1
191,4 80,1 378,3
138,9 44,6 319,6
143,7 47,5 327,8
148,5 50,4 336,0
153,3 53,4 344,2
158,1 56,5 352,3
162,8 59,6 360,5
167,6 62,9 368,7
172,4 66,2 376,9
177,2 69,6 385,0
182,0 73,1 393,2
186,8 76,6 401,4
134,3 41,9 339,8
139,1 44,7 349,5
143,9 47,6 359,1
148,7 50,5 368,7
153,5 53,5 378,3
158,2 56,6 387,9
163,0 59,8 397,5
167,8 63,0 407,2
172,6 66,3 416,8
177,4 69,7 426,4
182,2 73,2 436,0
Conversion Multiplier:
1 kW = 860 kcal/h
= 3412 Btu/h
1 kPa = 0.102 mAq
MODEL SELECTION
Performance Table (R407C) (cont.)
ABT COT
25,0
30,0
32,0
35,0
37,0
40,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
5,0
6,0
7,0
8,0
9,0
10,0
11,0
12,0
13,0
14,0
15,0
RCUE360AG1
CAP
CFR CPD
989,8 170,2 45,1
1019,1 175,3 47,5
1048,3 180,3 50,0
1077,6 185,3 52,6
1106,8 190,4 55,3
1136,1 195,4 57,9
1165,3 200,4 60,7
1194,6 205,5 63,5
1223,8 210,5 66,4
1253,1 215,5 69,3
1282,3 220,6 72,3
933,7 160,6 40,5
962,9 165,6 42,8
992,2 170,7 45,2
1021,4 175,7 47,7
1050,7 180,7 50,2
1079,9 185,7 52,8
1109,2 190,8 55,5
1138,4 195,8 58,2
1167,7 200,8 60,9
1196,9 205,9 63,7
1226,2 210,9 66,6
905,6 155,8 38,3
934,8 160,8 40,6
964,1 165,8 42,9
993,3 170,9 45,3
1022,6 175,9 47,8
1051,8 180,9 50,3
1081,1 185,9 52,9
1110,3 191,0 55,6
1139,6 196,0 58,3
1168,8 201,0 61,0
1198,1 206,1 63,9
877,5 150,9 36,2
906,8 156,0 38,4
936,0 161,0 40,7
965,3 166,0 43,0
994,5 171,1 45,4
1023,8 176,1 47,9
1053,0 181,1 50,4
1082,3 186,1 53,0
1111,5 191,2 55,7
1140,8 196,2 58,4
1170,0 201,2 61,1
849,4 146,1 34,1
878,7 151,1 36,2
907,9 156,2 38,5
937,2 161,2 40,8
966,4 166,2 43,1
995,7 171,3 45,5
1024,9 176,3 48,0
1054,2 181,3 50,5
1083,4 186,3 53,1
1112,7 191,4 55,8
1141,9 196,4 58,5
821,3 141,3 32,0
850,6 146,3 34,2
879,8 151,3 36,3
909,1 156,4 38,6
938,3 161,4 40,9
967,6 166,4 43,2
996,8 171,5 45,6
1026,1 176,5 48,1
1055,3 181,5 50,6
1084,6 186,5 53,2
1113,8 191,6 55,9
Where,
ABT:
Condenser Air Inlet Temperature (C)
COT:
Chilled Water Outlet Temperature (C)
CAP:
Cooling Capacity (kW)
IPT
285,8
288,3
290,8
293,2
295,7
298,2
300,7
303,1
305,6
308,1
310,6
300,7
305,6
310,6
315,5
320,5
325,4
330,4
335,4
340,3
345,3
350,2
306,6
312,6
318,5
324,5
330,4
336,3
342,3
348,2
354,2
360,1
366,1
315,5
323,0
330,4
337,8
345,3
352,7
360,1
367,6
375,0
382,4
389,9
329,4
337,8
346,3
354,7
363,1
371,5
380,0
388,4
396,8
405,2
413,7
350,2
360,1
370,0
380,0
389,9
399,8
409,7
419,6
429,5
439,4
449,3
RCUE400AG1
CAP
CFR CPD
1129,4 194,3 57,3
1162,8 200,0 60,5
1196,2 205,7 63,7
1229,5 211,5 66,9
1262,9 217,2 70,3
1296,3 223,0 73,7
1329,7 228,7 77,2
1363,0 234,4 80,8
1396,4 240,2 84,5
1429,8 245,9 88,2
1463,2 251,7 92,0
1065,3 183,2 51,5
1098,7 189,0 54,5
1132,1 194,7 57,6
1165,5 200,5 60,7
1198,8 206,2 63,9
1232,2 211,9 67,2
1265,6 217,7 70,6
1299,0 223,4 74,0
1332,3 229,2 77,5
1365,7 234,9 81,1
1399,1 240,6 84,8
1033,3 177,7 48,7
1066,7 183,5 51,6
1100,0 189,2 54,6
1133,4 194,9 57,7
1166,8 200,7 60,8
1200,2 206,4 64,1
1233,5 212,2 67,3
1266,9 217,9 70,7
1300,3 223,6 74,1
1333,7 229,4 77,7
1367,0 235,1 81,2
1001,3 172,2 46,0
1034,6 178,0 48,8
1068,0 183,7 51,8
1101,4 189,4 54,8
1134,8 195,2 57,8
1168,1 200,9 61,0
1201,5 206,7 64,2
1234,9 212,4 67,5
1268,3 218,1 70,8
1301,6 223,9 74,3
1335,0 229,6 77,8
969,2 166,7 43,4
1002,6 172,4 46,1
1036,0 178,2 49,0
1069,3 183,9 51,9
1102,7 189,7 54,9
1136,1 195,4 57,9
1169,5 201,1 61,1
1202,8 206,9 64,3
1236,2 212,6 67,6
1269,6 218,4 71,0
1303,0 224,1 74,4
937,2 161,2 40,8
970,5 166,9 43,5
1003,9 172,7 46,2
1037,3 178,4 49,1
1070,7 184,2 52,0
1104,0 189,9 55,0
1137,4 195,6 58,1
1170,8 201,4 61,2
1204,2 207,1 64,4
1237,5 212,9 67,7
1270,9 218,6 71,1
IPT
332,8
335,7
338,5
341,4
344,3
347,2
350,1
353,0
355,8
358,7
361,6
350,1
355,8
361,6
367,4
373,2
378,9
384,7
390,5
396,2
402,0
407,8
357,0
363,9
370,9
377,8
384,7
391,6
398,5
405,5
412,4
419,3
426,2
367,4
376,0
384,7
393,4
402,0
410,7
419,3
428,0
436,6
445,3
453,9
383,5
393,4
403,2
413,0
422,8
432,6
442,4
452,2
462,0
471,8
481,6
407,8
419,3
430,9
442,4
453,9
465,5
477,0
488,6
500,1
511,7
523,2
Conversion Multiplier:
1 kW = 860 kcal/h
= 3412 Btu/h
1 kPa = 0.102 mAq
15/85
Model
RCUE 40AG1
RCUE 50AG1
RCUE 60AG1
RCUE 70AG1
RCUE 80AG1
RCUE100AG1
RCUE120AG1
RCUE140AG1
RCUE150AG1
RCUE180AG1
RCUE200AG1
RCUE240AG1
RCUE270AG1
RCUE300AG1
RCUE330AG1
RCUE360AG1
RCUE400AG1
Unit Main
Power
(V)
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
380
415
(Hz)
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
50
Applicable
Instantaneous
Voltage (V)
Maximum Minimum
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
418
342
457
374
Commpressor
Motor
1
STC*
RNC
IPT
(A)
(A)
(kW)
114,6
62,8 37,1
125,2
60,7 37,1
114,6
75,3 44,1
125,2
72,6 44,1
147,5
91,9 55,1
161,1
87,5 55,1
178,4 106,8 64,2
194,8 100,7 64,2
114,6 125,6 74,2
125,2 121,4 74,2
114,6 150,6 88,2
125,2 145,2 88,2
147,5 183,8 110,1
161,1 175,0 110,1
178,4 213,6 128,2
194,8 201,4 128,2
114,6 225,9 132,3
125,2 217,8 132,3
147,5 275,7 165,2
161,1 262,5 165,2
178,4 320,4 192,4
194,8 302,1 192,4
147,5 367,6 220,2
161,1 350,0 220,2
178,4 427,2 256,4
194,8 402,8 256,4
147,5 459,5 275,3
161,1 437,5 275,3
178,4 534,0 320,6
194,8 503,5 320,6
147,5 551,4 330,4
161,1 525,0 330,4
178,4 640,8 384,7
194,8 604,2 384,7
2
Condenser Maximum
STC*
Fan Motor
Unit
Unit
Current Maximum
RNC IPT
(A) (kW)
(A)
(A)
7,2
4,0
92
122
7,2
4,0
89
132
7,2
4,0
109
122
7,2
4,0
105
132
7,6
4,2
132
155
7,6
4,2
126
169
7,6
4,2
152
186
7,6
4,2
144
202
14,4 8,0
184
161
14,4 8,0
178
170
14,4 8,0
218
167
14,4 8,0
210
176
15,2 8,5
263
198
15,2 8,5
251
210
15,2 8,5
304
235
15,2 8,5
287
249
21,6 12,0
327
213
21,6 12,0
316
221
22,8 12,7
395
241
22,8 12,7
377
251
22,8 12,7
455
294
22,8 12,7
431
305
30,4 17,0
527
249
30,4 17,0
503
259
30,4 17,0
607
291
30,4 17,0
574
303
38,0 21,2
658
303
38,0 21,2
629
311
38,0 21,2
759
353
38,0 21,2
718
362
45,6 25,4
790
352
45,6 25,4
754
358
45,6 25,4
911
409
45,6 25,4
861
415
NOTE:
1. This data is based on the following conditions...Chilled Water Inlet/Outlet Temperature: 12/7C, Ambient Temperature: 35C.
2. The "Maximum Unit Current" shown in the above table is the maximum total unit running current at the following conditions.
Supply Voltage: 90% of the rated voltage, Unit Capacity: 100% at max. operating conditions
3. The power supply cables must be sized to cover this maximum current value.
4. Starting Current (*1,*2) means as follows.
*1:First Compressor Starting Current
2
* :Unit Maximum Starting Current, when Last Compressor starts.
5. Compressor motor is star-delta starting, fan motor is direct starting.
MODEL SELECTION
15/87
250
87
87
88
88
88
88
91
91
92
92
92
92
92
93
93
93
93
250
83
83
84
84
84
84
87
87
88
88
88
88
88
89
89
90
90
Model
RCUE40AG1
RCUE50AG1
RCUE60AG1
RCUE70AG1
RCUE80AG1
RCUE100AG1
RCUE120AG1
RCUE140AG1
RCUE150AG1
RCUE180AG1
RCUE200AG1
RCUE240AG1
RCUE270AG1
RCUE300AG1
RCUE330AG1
RCUE360AG1
RCUE400AG1
63
82
82
83
83
83
83
86
86
87
87
87
88
88
88
88
89
89
125
81
81
82
82
82
82
85
85
86
86
86
87
87
87
87
88
88
4000
83
83
84
84
84
84
87
87
87
87
87
87
87
88
88
88
88
8000
78
78
79
79
79
79
82
82
83
83
83
84
84
85
85
85
85
Overall
(dBA)
93
93
94
94
94
94
97
97
97
97
97
97
97
98
98
99
99
Model
RCUE40AG1
RCUE50AG1
RCUE60AG1
RCUE70AG1
RCUE80AG1
RCUE100AG1
RCUE120AG1
RCUE140AG1
RCUE150AG1
RCUE180AG1
RCUE200AG1
RCUE240AG1
RCUE270AG1
RCUE300AG1
RCUE330AG1
RCUE330AG1
RCUE400AG1
63
78
78
79
79
79
79
82
82
83
83
83
84
84
84
84
85
85
125
77
77
78
78
78
78
81
81
82
82
82
83
83
83
83
84
84
4000
79
79
80
80
80
80
83
83
83
83
83
83
83
84
84
85
85
8000
74
74
75
75
75
75
78
78
79
79
79
80
80
80
80
81
81
Overall
(dBA)
89
89
90
90
90
90
93
93
93
93
93
93
93
94
94
95
95
NOTE:
1. Operating conditions are as follows.
1.1. Standard Models: Water Inlet/Outlet Temperature 12/7 C, Ambient Temperature 35 C, All Fans Running
1.2. Low Noise Option: Water Inlet/Outlet Temperature 12/7 C, Ambient Temperature 30 C, All Fans Running.
Voltage
Imbalance
Starting Voltage
Standard
(*1)
Low Noise
Option
Standard
Ambient
Temperature
Water Outlet
Temperature
R407C
R22 (Option)
90% ~ 110% of Rated Voltage
(-15) 5 ~ 43 C
(-15) 5 ~ 43 C
(-15) 5 ~ 35 C
(-15) 5 ~ 40 C
Low Temperature
Option
Remark
5 ~ 15 C
Water
4 ~ 0 C (Low1)
-1~ -5 C (Low2)
-6 ~ -10 C (Low3)
Ethylene glycol
1.0 Mpa
NOTE:
(*1) In case of Low Noise option, the performance changes .
Therefore, Capacity and Compressor Input will be corrected
by the right table, based on the standard performance table.
Item
Capacity
0.96
0.93
Compressor Input
1.07
1.02
40
50
60
70
80
100 120 140 150 180 200 240 270 300 330 360 400
m3/h 13.7 16.8 20.1 22.2 27.4 33.5 40.3 44.3 50.3 60.4 67.1 80.5 88.5
101
111
121
133
224
246
269
296
61
112
134
149
179
197
0.64 0.58 0.70 0.78 1.28 1.16 1.40 1.56 1.74 2.10 2.34 2.80 3.12 3.50 3.90 4.20 4.68
litre 10.8 13.3 16.1 16.1 23.9 30.7 38.2 38.2 44.0 54.3 54.3 76.4 76.4 82.2 82.2 114.6 114.6
NOTE:
1. Minimum Internal Water Volume above table is for
standard ON/OFF differential.
In case of changing ON/OFF differential, minimum
internal water volume changes as following
percentage.
Inlet ON/OFF Differential
4C
(set by Dip-switch 5, 3&4pins)
Minimum Internal Water
50%
Volume
3C
2C
1C
67%
100%
200%
APPLICATION DATA
35C
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
33~100%
40
38
105
43
34
126
46
32
144
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
35C
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
25~100%
30
35
86
32
32
100
34
29
117
35
26
135
40
38
105
40
34
118
40
30
133
40
28
143
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
20
19
105
22
17
126
23
16
144
25
15
167
33~100%
40
38
105
43
34
126
46
32
144
50
43
116
50
38
132
50
34
147
50
30
167
:Standard Condition
(Ambient: 35C, Water Inlet/Outlet: 12/7C, Full Load)
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
16/89
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
15
18
86
16
16
100
17
15
117
18
13
135
25~100%
30
35
86
32
32
100
34
29
117
35
26
135
40
38
105
40
34
118
40
30
133
40
28
143
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
Full Load
70
56
125
70
50
140
70
42
167
70
36
194
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
Model: RCUE150AG1,
Compressor Load
Ambient
Performance
Temperature
35C
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
11%
(*)
13
13
105
14
11
126
15
11
144
17
10
167
33~100%
40
38
105
43
34
126
46
32
144
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
35C
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
8.3%
(*)
10
12
86
11
11
100
11
10
117
12
9
135
25~100%
30
35
86
32
32
100
34
29
117
35
26
135
40
38
105
40
34
118
40
30
133
40
28
143
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
APPLICATION DATA
16/91
35C
30C
25C
20C
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
Capacity
Input
COP
%
%
%
%
%
%
%
%
%
%
%
%
10%
(*)
12
14
86
13
13
100
13
12
117
14
4
135
25~100%
30
35
86
32
32
100
34
29
117
35
26
135
40
38
105
40
34
118
40
30
133
40
28
143
50
43
116
50
38
132
50
34
147
50
30
167
60
48
125
60
42
143
60
37
162
60
32
188
70
56
125
70
50
140
70
42
167
70
36
194
Full Load
80
67
119
80
57
140
80
50
160
80
42
190
90
80
113
90
67
134
90
59
153
90
50
180
100
100
100
100
83
120
100
70
143
100
57
175
106
94
113
112
88
127
110
67
164
120
80
150
Outlet Water
Temp. (C)
Required
Ethylene
Glycol (wt%)
Low 1
Low 2
Low 3
4~0
-1 ~ -5
-6 ~ -10
20
30
40
Ethylene
Glycol
Freezing
Temp. (C)
-7
-13
-22
NOTE:
Freeze Protection Thermostat is the electronic control,
but non-adjustable.
For the performance, Each value can be given by using
following table. (See example in the next page)
2. Performance
Ethylene
glycol
(wt%)
20
30
40
Outlet
Water
Temp.
(C)
4
3
2
1
0
-1
-2
-3
-4
-5
-6
-7
-8
-9
-10
Ambient Temperature
(C)
30
35
CAP
IPT
CAP
IPT
(%)
(%)
(%)
(%)
95
90
90
95
92
89
87
94
89
88
84
93
86
87
81
92
84
86
79
91
81
85
76
90
78
84
73
89
75
83
71
88
72
82
68
87
69
81
65
86
66
80
63
85
64
79
60
84
61
78
57
83
58
77
55
82
55
76
52
81
25
CAP
(%)
100
97
94
91
88
85
82
79
76
73
70
67
64
61
58
IPT
(%)
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
40
CAP
(%)
84
82
79
77
74
72
69
67
64
62
59
56
54
51
49
IPT
(%)
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
NOTE:
1. CAP: Cooling Capacity, IPT: Compressor Input
2. Capacity and Compressor Input show the percentage of the standard
condition Standard condition: Ambient 35C, Water Inlet/Outlet
12/7c
3. Water Flow Rate and Pressure Drop can be calculated by the
Correction Factor Kf and Kp.
4. Example:
a) Model: RCUE100A
b) Standard Condition: Capacity 260kW, Compressor Input 90.4kW
c) Outlet/Inlet Water Temperature -3/2C, Ambient Temperature
30C
1/93
4005SC-Z
rpm
3
m /h
%
5005SC-Z
Semi-Hermetic
2880
169.5
100 ~ 25. 0
137.4
100 ~ 33. 0
MPa
MPa
kW
30
Litre
kg
360
6005SC-Z
208.7
100 ~ 25. 0
3.0
2.0
Special Squirrel Cage, Three-Phase Motor
Star-Delta Starting
37
2
E
CASTROL, ICEMATIC SW220HT
6
420
45
440
40
50
60
70
80
100 120 140 150 180 200 240 270 300 330 360 400
Condenser Type
Condenser Tube
Copper Tube
Material
Outer Diameter
mm
Rows
9.53 9.53
3
9.53 9.53
4
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
4
2.1
Fin Material
Pitch
Aluminium
mm
Number of Condenser
Maximum Operating Pressure
MPa
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
2.1
12
12
12
16
16
20
20
24
24
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
3.0
Quantity
12
12
12
16
16
20
20
24
24
Outer Diameter
mm
710
710
710
710
710
710
710
710
710
710
710
710
710
710
710
710
710
Revolution
rpm
850
850
850
850
850
850
850
850
850
850
850
850
850
850
850
850
850
Air Flow
840
840
840
840 2*840 2*840 2*840 2*840 3*840 3*840 3*840 4*840 4*840 5*840 5*840 6*840 6*840
m /min.
Starting Method
Nominal Output
Direct-On-Line Starting
kW
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
Quantity
12
12
12
16
16
20
20
24
24
Poles
40
50
60,70
Water Cooler
Type (Quantity)
-See Table Below-
A(1)
B(1)
C(1)
TYPE
REFRIGERANT CYCLE
Dimensions
Height (H)
Width (W)
Depth (D)
Maximum Permissible Pressure
Refrigerant Side
Water Side
Internal Volume
Refrigerant Side
Water Side
Material
Approval
80
100
120,140
150
A
40HP
SINGLE TYPE
B
C
50HP
60HP
D
80HP
F(2)
C(1)
F(2)
F(3)
DUAL TYPE
E
F
100HP
120HP
mm
mm
mm
693
243
186
693
243
225
693
243
269
694
304
294
694
304
372
694
304
460
Mpa
MPa
1.8
1.0
1.8
1.0
1.8
1.0
1.8
1.0
1.8
1.0
1.8
1.0
Litre
Litre
11.2
11.6
13.9
14.2
16.8
2 11.8
17.2
23.9
Stainless Steel
PED (1)
2 15.1
30.7
2 18.9
38.2
NOTE:
Pressure equipment Directive (97/23/EC)
SINGLE TYPE
DUAL TYPE
Water In
Water In
Refrigerant Out
Water Out
Water Out
No.1 Refrigerant In
Refrigerant In
No.2 Refrigerant In
Refrigerant
Water
Water
Plates
Plates
No.1 Refrigerant
No.2 Refrigerant