Professional Documents
Culture Documents
DEIR Appendix Q
DEIR Appendix Q
April 2015
Denise Duffy & Associates, Inc.
April 2015
Denise Duffy & Associates, Inc.
Prepared for
Prepared by
December 2014
Monterey Peninsula
Water Management District
List of Tables
Table i Acronyms Used in this Report........................................................................................ iii
Table ii Units of Measure Used in this Report ............................................................................ iv
Table 2-1: Estimated Return Flows into Blanco Drain ................................................................... 8
Table 2-2: Estimated Yields based on Pump Capacity ................................................................... 8
Table 2-3: SRDF By-Passed Flows, with and without Blanco Drain ........................................... 10
Table 3-1: Estimated Capital Costs............................................................................................... 18
Table 3-2: Estimated Annual Costs, 3 cfs Pump Station .............................................................. 19
Table 3-3: Estimated Annual Costs, 6 cfs Pump Station .............................................................. 19
Table 4-1: Water Quality Parameters, Blanco Drain above Salinas River ................................... 20
Table 4-2: Estimated Pollutant Removal at Blanco Drain, 6 cfs capacity .................................... 21
Table 4-3: Estimated Pollutant Removal at Blanco Drain, 3 cfs capacity .................................... 21
List of Figures
Figure 1.1: Blanco Drain Schematic ............................................................................................... 3
Figure 1.2: Blanco Drain Flap Gate ................................................................................................ 4
Figure 1.3: Old Pump Station ......................................................................................................... 4
Figure 1.4: Current Pump Station ................................................................................................... 5
Figure 2.1: SRDF Release Weir.................................................................................................... 11
Figure 2.2: SWRCB eWRIMS Interface ...................................................................................... 12
Figure 3.1: Existing Blanco Drain Pump Station.......................................................................... 14
Figure 3.2: System Curve for a 16-inch Force Main .................................................................... 15
Figure 3.3: System Curve for a 20-inch Force Main .................................................................... 16
12/31/2014
Monterey Peninsula
Water Management District
Appendices
A.
B.
C.
D.
Figures
Tables
Conceptual Diversion Facility
References
ii
12/31/2014
Monterey Peninsula
Water Management District
Description
Acre-feet/year
Cubic foot per second
Gallons per day
Million gallons per day
Milligrams per liter
Micrograms per liter
Most Probable Number
Nanogram per liter
Parts per billion
Parts per million
ASBS
ASR
BMP
CAW, CalAm
CCAMP
CCoWS
CCR
CCRWQCB
CDPH
CEQA
CSIP
CWC
DWR
GWR
MCWRA
MPWMD
MRSWMP
MRWPCA
NMFS
NOAA
NRCS
RTP
SIWTF
SRDF
SRDP
SVRP
SVWP
SVGB
SWRCB
USACE
USBR
USGS
iii
12/31/2014
Monterey Peninsula
Water Management District
Equals
= 43,560 cubic feet
= 325,851 gallons
1 cubic foot
= 7.48 gallons
1 cfs
1 MGD
= 1,000,000 gallons/day
= 1,120 acre-feet / year
1 mg/L
= 1 ppm
= 1 / 106
1 g/L
= 0.001 mg/L
= 1 ppb
= 1 / 109
1 ng/L
= 0.001 g/L
= 1 part per trillion
= 1 / 1012
iv
12/31/2014
Monterey Peninsula
Water Management District
12/31/2014
Monterey Peninsula
Water Management District
Section 1 - Introduction
1.1
Project Description
The Monterey Peninsula Water Management District (MPWMD) and the Monterey Regional
Water Pollution Control Agency (MRWPCA) are jointly sponsoring the proposed Pure Water
Monterey Groundwater Replenishment Project (Proposed Project), a water supply project that
will serve northern Monterey County. The project will provide purified water for recharge of the
Seaside Groundwater Basin that serves as drinking water supply, and recycled water to augment
the existing Castroville Seawater Intrusion Project agricultural irrigation supply.
Source water for the project would include agricultural wash water from the City of Salinas
Industrial Wastewater Collection System, stormwater from MRWPCA member cities,
secondary-treated effluent from the MRWPCA Regional Treatment Plant, and surface water
diverted from the Reclamation Ditch, Tembladero Slough and Blanco Drain. Water supplied to
the Proposed Project would undergo primary and secondary treatment at the existing Regional
Treatment Plant. The portion used for groundwater recharge would then undergo advanced
treatment at a new facility to be located at the MRWPCA site, and then be conveyed to the
Seaside Groundwater Basin for injection. The portion used for agricultural irrigation would
undergo tertiary treatment at the existing Salinas Valley Reclamation Plant, and distribution
through the Castroville Seawater Intrusion Project system.
The MRWPCA provides wastewater treatment for municipalities along the Monterey Bay from
Pacific Grove north to Moss Landing, and inland to the City of Salinas. Wastewater is collected
in an interceptor pipeline system and conveyed to the Regional Treatment Plant (RTP), located
two miles north of the City of Marina. A large portion of this incoming flow undergoes tertiary
treatment and is used for unrestricted agricultural irrigation within the Castroville Seawater
Intrusion Project system in the northern Salinas Valley. Flow that is not sent to the tertiary
treatment system is discharged through an outfall to Monterey Bay after receiving secondary
treatment. The RTP has an average dry weather design capacity of 29.6 million gallons per day
(mgd) and a peak wet weather design capacity of 75.6 mgd. It currently receives and treats
approximately 17 to 18 mgd of average dry weather flow and therefore has capacity to treat
additional flows. The interceptor pipeline system also has currently unused or excess conveyance
capacity. Most of the new source waters would be conveyed to the RTP using the existing
wastewater collection system; water from Blanco Drain would be conveyed in a new pipeline
directly to the RTP.
Transfers of source water flowing in known and definite channels, such as the Blanco Drain, to
the GWR project and thence out of the Salinas Valley to the Monterey Peninsula would be a
consumptive use that may require an appropriative permit from the State Water Resources
Control Board (SWRCB). The purpose of this study was to analyze water availability in the
Blanco Drain and provide an engineering analysis of the potential yields and the infrastructure
12/31/2014
Monterey Peninsula
Water Management District
required to capture and convey those flows to the RTP. This hydrologic information and analysis
may then be used in a permit application to the SWRCB.
1.2
The Blanco Drain is a man-made reclamation ditch draining approximately 6,400 acres of
agricultural lands near Salinas, CA. The watershed is between the Salinas River and Alisal
Slough, and discharges to the Salinas River at river mile 5 (see Figure A-1). The system is
maintained by the Monterey County Water Resources Agency (MCWRA).
The system consists of three separate ditches (A, B, and C) as shown in Figure 1.1. Ditch A is
what is commonly referred to as the Blanco Drain. A headwall and flap gate at the lower end of
Ditch A prevents seasonal high flows in the Salinas River from migrating up the Blanco Drain
channel (Figure 1.2). Until 2010, MCWRA operated a seasonal pump station at the confluence
of ditches A, B and C to lift summer flows over a low weir and into the ditch channel. This was
required to improve tile drainage into ditches B and C (Figure 1.3). The pump station was not
operated in the winter months, and ditches B and C were allowed to fill and overflow the weir.
Figure 1.1: Blanco Drain Schematic
12/31/2014
Monterey Peninsula
Water Management District
In 2009-2010, the MCWRA Salinas River Diversion Facility (SRDF) was constructed
downstream of the Blanco Drain. The SRDF includes an inflatable rubber dam that impounds
water during the summer months to supply the diversion pump station. To overcome the
backwater into the Blanco Drain channel, the Blanco Drain channels were regraded and a new
pump station was installed at the lower end of Ditch A. The new pump station (Figure 1.4) lifts
Blanco Drain flows past a new slide gate and into the gravity portion of the channel.
12/31/2014
Monterey Peninsula
Water Management District
Summer flows in the Blanco Drain are generally tile drainage and runoff from irrigated
agriculture. Winter flows include stormwater runoff, although some fields remain in production
and under irrigation year-round. Irrigation supply is predominantly groundwater from the
Pressure Subarea of the Salinas Valley Groundwater Basin (see Figure A-2). A portion of the
area tributary to the Blanco Drain is within the Castroville Seawater Intrusion Project (CSIP)
service area (see figure A-3). The CSIP supplies growers with Recycled Water from the Salinas
Valley Reclamation Plant (SVRP), located next to the MRWPCA RTP, and Salinas River water
diverted at the MCWRA Salinas River Diversion Facility (SRDF).
During the summer months, the Salinas River flows into the Old Salinas River Channel through
a gated culvert at the Salinas Lagoon. Direct discharge to the ocean is blocked by a seasonal
sand bar which forms across the mouth of the Salinas Lagoon due to wave and tidal action in the
Monterey Bay. The Old Salinas River channel is controlled by tide gates at Potrero Road in
Moss Landing. River flow combines with Tembladero Slough flow approximately 1.2-miles
above the tide gates. During high winter flows in the Salinas River, the sand bar breaches and
the river flows directly to the Bay. When this occurs, MCWRA closes the slide gate to the Old
Salinas River.
The Central Coast Regional Water Quality Control Board (CCRWQCB) has listed Blanco Drain
on the impaired water body listing pursuant to Section 303(d) of the Clean Water Act for
pesticides, nitrate and low dissolved oxygen. The lower Salinas River is also listed as an
impaired water body for pesticides, nitrate, chloride and other parameters. A summary matrix of
12/31/2014
Monterey Peninsula
Water Management District
303(d) listed streams is provided in Appendix B, Table B-1. Water quality is discussed in
greater detail in Section 4 of this report.
Aquatic habitats within the Blanco Drain system are poor. In addition to the poor water quality,
the system is generally maintained as a drainage canal without tree canopy. The adjacent
agricultural lands are used for growing table crops (leafy greens, berries and artichokes). The
growers prevent vegetation from establishing along the Ditch banks to discourage birds and
rodents from nesting near their fields. The Biological Opinion for the Salinas Valley Water
project, NMFS noted: The outlet culvert of the Blanco Drain, where the drain enters the Salinas
River, has a flap gate on its downstream end, preventing fish passage in Blanco Drain. Even if
the flap gate fails and some fish are able to enter the drain, current water quality conditions are
such that survival is not likely.1
NMFS, Biological Opinion for the Salinas River Diversion Facility, pg 84.
12/31/2014
Monterey Peninsula
Water Management District
Methodology
Estimates of stream flow capture from the Blanco Drain system were made, assuming diversion
would occur at the existing MCWRA Blanco Drain pump station. Limited seasonal flow data
was available for this location and was used as the basis of this analysis. The Blanco Drain is an
8-mile long channel that drains approximately 6,000 acres of irrigated agricultural land west of
Salinas, CA. The terrain is generally flat with type C and D clay soils. Flows are primarily
agricultural tile drainage.
The Blanco Drain connects to the Salinas River through a 60-inch pipe culvert with a flap gate.
To facilitate drainage, MCWRA historically operated a pump station approximately 2-miles
upstream of the pipe culvert, from the drain channel (parallel to the Salinas River) to the
connecting channel. This pump station was replaced as part of the Salinas River Diversion
Facility (SRDF) project. The current pump station is located at the upstream end of the 60-inch
pipe culvert, and includes a slide gate which is closed when the SRDF rubber dam is inflated,
and a by-pass pump station which lifts Blanco Drain flows past the gate structure.
Limited flow data is available for the Blanco Drain. A weir gage was installed in 2007 to record
flows used in sizing the current pump station, and operational records for the pump station were
obtained for 2010 through 2013 and used in this analysis. Because the SRDF only operates
during the peak irrigation season (April to October), flow data was not recorded for the rest of
the year.
Approximately one third of the area tributary to the Blanco Drain is within the Castroville
Seawater Intrusion Project (CSIP) service area. The MCWRA publishes monthly records of the
total CSIP water deliveries, which can be used to estimate applied irrigation per acre (= total
deliveries 12,000 acre service area). Similar crops and irrigation methods are used throughout
the Blanco Drain tributary areas, so it was assumed that the CSIP irrigation rates applied to the
full area.
Flows from the Blanco Drain were estimated as return flows from applied irrigation and natural
precipitation. For the months with recorded Blanco Drain flow data, the source flows were
calculated as:
(CSIP Irrigation) + (Precipitation at Salinas) x 6,000 acres = total acre-feet/month
Return Rate = (Blanco Drain Flow) / (total ac-ft/mo)
The calculated return rates ranged from 3% to 25%, with an average return of 17.3% (see Table
B-2: Blanco Drain Flows as Return Flows). The period with the most complete flow data for the
Blanco Drain was August to October 2013, with an average return rate of 16.9%. For this
estimate, we assumed a flat 17% return rate. The MCWRA CSIP records were combined with
12/31/2014
Monterey Peninsula
Water Management District
the Salinas rainfall records to calculate the total estimated source flows (Table B-4: Applied
Irrigation and Recorded Precipitation in the CSIP Service Area). The return flows were
estimated by month as shown below.
Table 2-1: Estimated Return Flows into Blanco Drain
Month
January
February
March
April
May
June
July
August
September
October
November
December
Totals
Applied Irrig
+ Precip
AF
1,229
1,314
1,446
1,481
1,323
1,613
1,629
1,436
1,080
989
782
1,088
15,410
17%
return
AF
209
223
246
252
225
274
277
244
184
168
133
185
2,620
Avg Return
Flow Rate
cfs
3.4
4.0
4.0
4.2
3.7
4.6
4.5
4.0
3.1
2.7
2.2
3.0
The values shown in Table 2-1 are monthly average values. Although the average monthly
return flow rates range from 2.2 to 4.6 cfs, daily flows rates over 6 cfs have been recorded during
the four years the Blanco Drain pump station has been in operation. To achieve an annual
average diversion of 2,620 AFY, a peak diversion rate of 6 cfs is therefore required. Yields
applying lower average station capacities are shown in Table 2-2. If excess flows on peak days
may be stored in-channel behind the slide gate and held until the following day, diverting at a
lower rate may be feasible. However, the current pump station configuration and operating
regimen is designed to drain the channel to facilitate tile drainage, so the use of in-channel
storage should not be assumed.
Table 2-2: Estimated Yields based on Pump Capacity
Station Capacity
Yield
cfs
AFY
2.9
2,050
2.99
2,104
3.0
2,110
3.5
2,350
4.0
2,538
4.5
2,613
4.6
2,619
12/31/2014
Monterey Peninsula
Water Management District
The permitting process for a water right diversion rate less than 3 cfs is shorter than for a larger
diversion rate, so the proposed project assumes an initial water right diversion at 2.99 cfs, and an
ultimate water right allowing diversions at up to 6 cfs. Both capacities are considered in Section
3, Facility Requirements.
12/31/2014
Monterey Peninsula
Water Management District
2.2
For this report, we assumed that all flows within the Blanco Drain are available for diversion and
capture. This is based upon previous documentation in the Salinas Valley Water Project EIR and
the supporting Biological Opinion prepared by NMFS for the SRDF construction. Those
documents identify (1) the water quality within the Blanco Drain is poor and does not support
aquatic species, (2) the flap gate between the river and the Blanco Drain prevents the migration
of fish from the river into the drain, and (3) the water quality at the downstream Salinas Lagoon
would be improved if the flows from the Blanco Drain were diverted to the MRWPCA Regional
Treatment Plant.
As a condition of operating the SRDF, MCWRA must maintain certain in-stream flows in the
Salinas River. When San Antonio and Nacimiento Reservoirs have a combined storage of
220,000 acre-feet, the SRDF has a requirement to release (1) a minimum of 15 cfs downstream
from April 1 to June 30, and (2) a minimum of 2 cfs downstream from July 1 to the end of the
SRDF operating season for maintenance of the Salinas River Lagoon habitat. Higher block flow
releases are triggered during steelhead migration season if the Salinas Lagoon is open to the
ocean. When the combined storage in the two reservoirs is under 220,000 ac-ft, the minimum
release requirement for Lagoon habitat maintenance is 2 cfs while the SRDF is in operation. In
Table 2-3, we compare the recorded daily by-passed flows at the SRDF (fish ladder plus
regulating weir, as shown in Figure 2.1) to the recorded Blanco Drain flows during year 2012.
Additional flow is reported to have spilled over the rubber dam during this period, but that
volume was not estimated. In each month, the by-passed flow minus the Blanco Drain flow
exceeds the required minimum release.
Table 2-3: SRDF By-Passed Flows, with and without Blanco Drain2
Month
Year
Avg Daily
By-Passed
Flow
Blanco
Drain
Flow
Average
minus
B.D.
Required
Minimum
By-Pass
cfs
cfs
cfs
cfs
2012
22.5
5.6
16.9
2.0
2012
18.6
5.0
13.6
2.0
2012
9.1
5.6
3.5
2.0
2012
10.1
5.3
4.8
2.0
2012
11.3
4.8
6.5
2.0
2012
18.3
3.6
14.7
2.0
10
2012
15.0
2.4
12.6
2.0
11
2012
57.3
1.1
56.2
2.0
Note: The triggers for a 15 cfs by-pass in April did not occur in 2012.
Salinas Valley Water Project, Annual Flow Monitoring Report, Water Year 2012
10
12/31/2014
Monterey Peninsula
Water Management District
11
12/31/2014
Monterey Peninsula
Water Management District
2.3
Water Rights
Water that enters surface streams and rivers is considered water of the state. A water rights
permit is required to impound or divert waters of the state, except for certain riparian uses.
Stormwater and agricultural return flows in the Blanco Drain would be subject to water rights
permitting rules. Existing surface water rights were researched to assess potential impacts to
current water right holders or challenges to the proposed diversions.
The State Water Resources Control Board Electronic Water Rights Information Management
System (eWRIMS) was queried to identify existing water rights in the Lower Salinas Watershed.
A listing of all current water rights for Monterey County was obtained using a database query.
The Points of Diversion (PODs) within the Lower Salinas watershed and vicinity were identified
using the on-line GIS mapping tool. The POD listing was used to create a tailored list of water
rights within the area of interest (see Table B-4).
Figure 2.2: SWRCB eWRIMS Interface
The SWRCB Water Rights Order 98-08, Declaration of Fully Appropriated Stream Systems in
California, identifies those stream segments which cannot support additional authorizations for
diversion. Neither the Blanco Drain nor the Lower Salinas River were listed in that decision, so
there is no regulatory prohibition on requesting a water right on this stream.
The water rights listing includes several water right types:
12
12/31/2014
Monterey Peninsula
Water Management District
Statements of Diversion and Use, for reporting riparian use of surface water and for the
use of groundwater. Statements of Diversion and Use are also used for claims of pre1914 appropriative water rights. The limitation of the eWRIMS database is that most
Claimed water rights do not appear with a Face Amount the way Appropriative Rights
are listed.
There are no surface water rights or claims listed within the Blanco Drain watershed. The
existing points of diversion within the Blanco Drain watershed are all for groundwater use. The
sources for these are listed as Salinas River Underflow. The shallow A-Aquifer
groundwater in this area is not used due to poor water quality. Wells in this area tap the Pressure
subarea of the Salinas Valley Groundwater Basin (SVGB), which is recharged in the Forebay
and Upper Valley subareas. Diverting surface water for this project should not affect
groundwater yields from the SVGB.
The Blanco Drain is tributary to the Salinas River, just above the SRDF (small blue square on the
map above). The MCWRA has three water rights (Permits 10137, 21089 and 12261) for water
diversion and storage in San Antonio and Nacimiento Reservoirs, with authorized points of
rediversion at the SRDF (see Table B-5). There are no surface water rights with points of
diversion below the SRDF. MCWRA has a fourth water right, Permit 11043, for run-of-river
flows with two authorized points of diversion upstream of the Blanco Drain. This fourth water
right has not been used but has a priority date of July 11, 1949.
13
12/31/2014
Monterey Peninsula
Water Management District
As stated in the Project Description, water supplies for the GWR Project will be conveyed to the
RTP using existing excess capacity in the MRWPCA interceptor system. There are no
interceptor facilities near the Blanco Drain, so a new pipeline will be required to convey flows to
the RTP. There is an existing diversion pump station on the Blanco Drain, used to lift flows
from the Drain to the Salinas River while the SRDF rubber dam is inflated. The station consists
of a concrete weir with a slide gate, a concrete-box intake structure in the channel bottom, a
concrete manhole to house the pumps, a concrete deck above the manhole for the electrical panel
and concrete stairs for maintenance operation. As can be seen in the photo below, the current
station has a small static lift and a free discharge just below the weir. The plan and profile
design drawings are included as Figures C-1 and C-2 in Appendix C.
Figure 3.1: Existing Blanco Drain Pump Station
A similar pump station would be required to divert flows for the GWR project. Significantly
larger pumps will be needed due to the increased static lift and force main length. The proposed
force main is approximately 9,500 LF, from the existing pump station to the head-works side of
the RTP (see Figure C-3). A static lift of 140-ft is estimated from the Blanco Drain to the highest
point along the force main alignment.
Several flow rates and force main sizes were considered. The force main should be sized for a
minimum velocity of 2 ft/s to prevent solids from settling out in the pipeline, and a maximum
14
12/31/2014
Monterey Peninsula
Water Management District
velocity of 8 ft/s to limit the friction losses. For a 2.99 cfs diversion (nominally 1350 gpm), an
88 hp pump and a 16-in force main are required (see Figure 3.2). For the peak flow rate of 6 cfs
(nominally 2700 gpm), a 143 hp pump and a 20-inch force main are required (see Figure 3.3).
System head tables are provided in Appendix C.
Figure 3.2: System Curve for a 16-inch Force Main
System Curve, Blanco Drain Pump Station, 16" FM
300.00
350
300
250.00
250
200.00
Pump HP
TDH (ft)
200
150.00
150
100.00
100
50.00
50
0.00
0
500
1,000
1,500
2,000
2,500
3,000
3,500
4,000
0
4,500
Flow (gpm)
System Curve, Blanco Drain Pump Station
Pump HP
It may be possible to modify the existing pump station to also serve the GWR Project, rather than
construct a duplicate pump station next to the existing MCWRA facility. A new wet well may
be constructed adjacent to and connected to the existing wet well. This would allow for shared
use of the existing inlet structure and pipeline. A second option would be to construct a mirror
station on the opposite bank, sharing only the inlet box. Either option would use the existing
pump station to move excess Blanco Drain flows that exceed the GWR Project diversions into
the Salinas River. Conceptual site plan diagrams are provided as Figures C-4 and C-5 in
Appendix C.
15
12/31/2014
Monterey Peninsula
Water Management District
350
180.00
300
160.00
250
140.00
120.00
Pump HP
TDH (ft)
200
100.00
150
80.00
60.00
100
40.00
50
20.00
0.00
0
500
1,000
1,500
2,000
2,500
3,000
3,500
4,000
0
4,500
Flow (gpm)
System Curve, Blanco Drain Pump Station
Pump HP
The inlet structure consists of a concrete box with a screened inlet. The inlet must be sized to
allow full flow through the screen with a maximum velocity of 1 ft/s to allow fish to escape.
Assume the screen has an open area of 50%, and that 50% of the screen is blinded by
trash/vegetation. For a maximum flow of 6 cfs:
Ascreen = 6 cfs / [(1 ft/s) x (50% screen openings) x (50% blinded)] = 24 sq-ft
Minimum dimensions: 4-ft wide x 6-ft long
The existing inlet box is 8-ft x 8-ft, so it exceeds the required minimum.
The channel invert surrounding the intake should be concrete lined to prevent scour during high
flow periods. Similarly, the channel banks above the inlet structure should be protected with
grouted rip-rap to prevent scour and potential bank sloughing into the inlet. As can be seen in
Figure 3.1, the channel bank at the existing pump station is experiencing some erosion within the
first year of operation.
The inlet will connect to the wet well through a large diameter pipe, sloped towards the wet well.
A new wet well may be connected to the northwest side of the existing wet well (opposite the
inlet pipe). The new wet well would be an 8-ft diameter manhole, with mounting rails to
16
12/31/2014
Monterey Peninsula
Water Management District
facilitate the installation and removal of the submersible pumps. Within the wet well, the pumps
will be set below the inlet pipe elevation. The pump operation may be controlled by a pressure
transducer in the wet well, with float switches for backup control and alarms. Because the
system will be discharging to the RTP head works, a SCADA radio connection to the MRWPCA
controls system is recommended so that this station may be shut down to facilitate maintenance
at the RTP.
The force main to the RTP must be pressure pipe (typically HDPE, PVC or ductile iron), with a
check valve and isolation valve located outside the wet well in a separate vault. The pipeline
should be installed with a minimum of 4-ft of cover in the pipe trench. The segment crossing
the Salinas River must be installed using trenchless methods. Directional drilling is the most
likely method, but the RWQCB may prescribe a different method for the river crossing. The
CSIP supply pipeline crosses the river near the SRDF facility. This crossing should be made
upstream of the SRDF to avoid potential conflicts.
The pumps may operate at fixed speed or under variable speed control. Operation under fixed
speed is simpler to design, but may require excessive cycling if the inflow rates are significantly
lower than the pump design point. Variable speed control will allow the pumps to start and stop
less frequently.
The proposed pump station is located in a FEMA floodway (Salinas River Overbank). The
proposed submersible pumps will not be affected by storm inundation, but the power and control
equipment must be elevated above the base flood elevation of 27-ft3.
The Blanco Drain is within a 40-ft wide parcel, owned by Monterey County. As can be seen on
the existing facility drawing, that parcel does not reach to the top of the existing bank. An
easement with the adjacent property owner was required for the existing pump station, and an
additional easement must be obtained for a GWR pump station and force main.
Construction of the pump station will require regulatory permits from many agencies, including
the Army Corps of Engineers (Clean Water Act, Section 404), the CC RWQCB (Clean Water
Act, Section 401) and the California Department of Fish and Wildlife. The National Marine
Fisheries Service may be required to prepare a Biological Opinion as well.
FEMA Flood Insurance Rate Map, Map Panels 06053C0205G and 06053C0185G, April 2009 (see
Appendix A)
3
17
12/31/2014
Monterey Peninsula
Water Management District
3.2
Costs
Capital costs were estimated for two pump station configurations, a 3 cfs station with a 16-inch
force main, and a 6 cfs station with a 20-inch force main, summarized in Table 3-1, below. The
cost of constructing the force main from the pump station to the MRWPCA RTP is just over half
of the total capital cost. Detailed estimates are provided in Tables C-3 and C-4 in Appendix C.
Non-construction costs (design, permitting, legal, etc.) were estimated as 40% of the construction
cost.
Right-of-way acquisition costs were not included in the capital cost estimates. Easements across
private property must be negotiated with landowners. The affected agricultural lands are
typically in active cultivation during the construction season, so a premium cost should be
anticipated.
Table 3-1: Estimated Capital Costs
3 cfs
Pump Station
$1,789,420
$268,000
$358,000
6 cfs
Pump Station
$2,280,420
$342,000
$456,000
$2,415,000
$3,078,000
$966,000
$1,232,000
The MRWPCA has standard capacity charges for connection to the regional wastewater system,
based upon the flow rate, the biological oxygen demand (BOD) and the suspended solids
concentration, and monthly charges for wastewater treatment. These fees are not included in this
estimate, because the MRWPCA is a sponsor of the GWR Project. The primary, secondary and
advanced treatment costs for this source of supply will appear in the overall project cost analysis.
Annual operating and debt service costs for each configuration were estimated using the
following planning factors:
Debt service assumes a 30-year bond at 4% annual interest
Annual operation and maintenance of pump stations is estimated at 2.5% of the capital
cost
Annual operation and maintenance of pipelines is estimated at 1% of the capital cost
Electrical power cost is assumed at $0.16 per kWh
Assume the station operates 365 days a year
18
12/31/2014
Monterey Peninsula
Water Management District
The factors above provide an order-of-magnitude estimate of annual costs, which may be used in
comparing project configurations. The estimated annual costs are provided below.
Table 3-2: Estimated Annual Costs, 3 cfs Pump Station
Category
Capital Repayment
Assume 30-year bond at 4%
Annual Operation and Maintenance
Assume 2.5% of Pump Station Capital Cost
Assume 1.0% of Pipeline Capital Cost
Electrical Power
Number of operating days/year
Pumps: 88 HP (0.7457 kW/hp)
Estimated annual kWh
Assumed cost per KWH
Basis
Annual $
$2,415,000.00
$139,659.69
$795,000.00
$1,620,000.00
$19,875.00
$40,500.00
365
65.6
574,845
$0.16
$91,975.23
$292,000.00
Basis
Annual $
$3,078,000.00
$178,001.05
$1,093,500.00
$1,984,500.00
$27,337.50
$49,612.50
365
106.6
934,123
$0.16
$149,459.76
$404,400.00
19
12/31/2014
Monterey Peninsula
Water Management District
The Central Coast Regional Water Quality Control Board (CCRWQCB) Water Quality Control
Plan for the Central Coast Basin (Basin Plan) designated beneficial uses of the Blanco Drain as
including water contact recreation, non-contact water recreation, wildlife habitat, warm water
fish habitat and commercial or sport fishing. These are the minimum uses listed for all inland
water bodies within the region, unless specific water quality information caused the RWQCB to
remove a specific use (e.g., not listing water contact recreation for a stream segment listed for
fecal coliform contamination).
The Blanco Drain is listed as an impaired water body pursuant to Section 303(d) of the Clean
Water Act for pesticides, nitrate and low dissolved oxygen. Water quality has been sampled and
monitored for the past 15 years under various programs, including the Central Coast Ambient
Monitoring Program (CCAMP) under the RWQCB, the Central Coast Watershed Studies
(CCoWS) program of the Watershed Institute at California State University Monterey Bay, and
the Cooperative Monitoring Program under the Conditional Waiver of Waste Discharges from
Irrigated Lands (Ag Waiver). The results of these programs have been consolidated in Table B6, Stream Water Quality, for the Blanco Drain and all downstream inland water bodies. Figure
A-6 shows the primary sampling locations.
The Blanco Drain is not designated for use as municipal or domestic water supply, so Total
Maximum Daily Loads (TMDL) for pollutants had to be established by the RWQCB. The
Central Coast RWQCB adopted order R3-2013-0008 to establish certain TMDLs for the lower
Salinas River Basin in 2013. These and other applicable water quality standards are consolidated
in Table B-6, Total Maximum Daily Loads. A summary of the key parameters for the Blanco
Drain are shown in Table 4-1, below.
Table 4-1: Water Quality Parameters, Blanco Drain above Salinas River
Parameter
Ammonia as N, Unionized
Ammonia as NH3
Chlorophyll a, water column
Chlorpyrifos
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Oxygen, Dissolved
Turbidity
Units
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
NTU
Mean
0.014
0.20
0.0021
0.0009
0.01
2,019
65.27
0.85
0.20
66.48
20
Max
0.26
4.96
0.028
0.018
0.17
2,250
325.00
4.40
2.52
1,210.00
Standard
0.025
0.025
0.015
0.00025
0.00016
1,000
8.0
0.3
> 5.0
10
12/31/2014
Monterey Peninsula
Water Management District
4.2
In the Biological Opinion for the SRDF Project, NMFS recommended diverting the Blanco
Drain flows to the RTP as a means of improving the habitat in the Salinas River Lagoon.
Removing water from the drain will carry dissolved pollutants out of the environment along with
the water. The quantity removed may be estimated using the conversion factor 1 mg/L = 2.7
lb/AF. The tables below show the estimated annual pollutant removal, assuming average annual
flow conditions and historic average pollutant concentrations for two conditions: a 6 cfs pumping
capacity and a 3 cfs pumping capacity.
Table 4-2: Estimated Pollutant Removal at Blanco Drain, 6 cfs capacity
Pollutant
Ammonia as N, Unionized
Ammonia as NH3
Chlorophyll a, water column
Chlorpyrifos
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Average
Conc.
Average
Annual
Flow
Average
Pollutant
Load
Diverted
Flow
Diverted
Pollutant
Load
(mg/L)
(AFY)
(lb/yr)
(AFY)
(lb/yr)
0.014
2,620
98
2,620
98
0.20
2,620
1,432
2,620
1,432
0.0021
2,620
15
2,620
15
0.00085
2,620
2,620
0.011
2,620
76
2,620
76
2019.7
2,620
14,287,358
2,620
14,287,358
65.27
2,620
461,726
2,620
461,726
0.85
2,620
6,026
2,620
6,026
Pollutant
Ammonia as N, Unionized
Ammonia as NH3
Chlorophyll a, water column
Chlorpyrifos
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Average
Conc.
Average
Annual
Flow
Average
Pollutant
Load
Diverted
Flow
Diverted
Pollutant
Load
(mg/L)
(AFY)
(lb/yr)
(AFY)
(lb/yr)
0.014
2,620
98
2,110
79
0.20
2,620
1,432
2,110
1,153
0.0021
2,620
15
2,110
12
0.00085
2,620
2,110
0.011
2,620
76
2,110
61
2019.7
2,620
14,287,358
2,110
11,506,231
65.27
2,620
461,726
2,110
371,848
0.85
2,620
6,026
2,110
4,853
21
12/31/2014
Monterey Peninsula
Water Management District
12/31/2014
Monterey Peninsula
Water Management District
d. Would the project place within a 100-year flood hazard area structures that would impede
or redirect flood flows?
The Project would add a diversion pump station on the Blanco Drain adjacent to an existing
pump station which would be located within a 100-year flood hazard area. The proposed Blanco
Drain pump station intake would be located at the channel bottom, and would be configured to
not alter the conveyance capacity of the Blanco Drain. The pump station would not impede or
reduce flood flows because they are low profile, small (less than 500 square-feet of vertical
structures) and would be located at sites that currently contain similar above-ground structures of
similar size and profile.
23
12/31/2014
Monterey Peninsula
Water Management District
Appendix A: Figures
A-1
December 2014
Monterey Peninsula
Water Management District
Monterey Peninsula
Water Management District
Monterey Peninsula
Water Management District
Pump
Station and
F.M.
Locations
F.M.
Location
ZONE
AE, A1-A30
DESCRIPTION
Areas subject to inundation by the 1-percent-annual-chance flood event. Because detailed hydraulic analyses
have not been performed, no Base Flood Elevations (BFEs) or flood depths are shown.
Areas subject to inundation by the 1-percent-annual-chance flood event determined by detailed methods. BFEs
are shown within these zones. (Zone AE is used on new and revised maps in place of Zones A1A30.)
AH
Areas subject to inundation by 1-percent-annual-chance shallow flooding (usually areas of ponding) where
average depths are 13 feet. BFEs derived from detailed hydraulic analyses are shown in this zone.
AO
Areas subject to inundation by 1-percent-annual-chance shallow flooding (usually sheet flow on sloping terrain)
where average depths are 13 feet. Average flood depths derived from detailed hydraulic analyses are shown
within this zone.
AR
Areas that result from the decertification of a previously accredited flood protection system that is determined to
be in the process of being restored to provide base flood protection.
A99
Areas subject to inundation by the 1-percent-annual-chance flood event, but which will ultimately be protected
upon completion of an under-construction Federal flood protection system. These are areas of special flood
hazard where enough progress has been made on the construction of a protection system, such as dikes, dams,
and levees, to consider it complete for insurance rating purposes. Zone A99 may be used only when the flood
protection system has reached specified statutory progress toward completion. No BFEs or flood depths are
shown.
ZONE
DESCRIPTION
Areas along coasts subject to inundation by the 1-percent-annual-chance flood event with additional hazards
associated with storm-induced waves. Because detailed coastal analyses have not been performed, no BFEs or
flood depths are shown.
VE, V1-V30
Areas along coasts subject to inundation by the 1-percent-annual-chance flood event with additional hazards due
to storm-induced velocity wave action. BFEs derived from detailed hydraulic coastal analyses are shown within
these zones. (Zone VE is used on new and revised maps in place of Zones V1V30.)
ZONE
DESCRIPTION
B, X (shaded)
Moderate risk areas within the 0.2-percent-annual-chance floodplain, areas of 1-percent-annual-chance flooding
where average depths are less than 1 foot, areas of 1-percent-annual-chance flooding where the contributing
drainage area is less than 1 square mile, and areas protected from the 1-percent-annual-chance flood by a
levee. No BFEs or base flood depths are shown within these zones. (Zone X (shaded) is used on new and
revised maps in place of Zone B.)
C, X (unshaded)
Minimal risk areas outside the 1-percent and .2-percent-annual-chance floodplains. No BFEs or base flood
depths are shown within these zones. (Zone X (unshaded) is used on new and revised maps in place of Zone
C.)
DESCRIPTION
Unstudied areas where flood hazards are undetermined, but flooding is possible. No mandatory flood insurance
purchase requirements apply, but coverage is available in participating communities.
Monterey Peninsula
Water Management District
Monterey Peninsula
Water Management District
Appendix B: Tables
B-1
December 2014
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
2010_USEPA_approv_303d_List_Final_122311wsrcs.xls/Matrix (2)
X
X
X
X
X
X
Unknown Toxicity
Turbidity
Toxaphene
Total Coliform
Temperature, water
Sodium
Sedimentation/Siltation
Sediment Toxicity
Priority Organics
pH
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
Pesticides
Pathogens
X
X
X
X
X
X
X
Nutrients
X
X
X
X
X
X
X
X
Nitrate
Nickel
Fecal Coliform
Enterococcus
Electrical Conductivity
Dieldrin
Diazinon
DDD (Dichlorodiphenyldichloroethane)
Copper
Chlorpyrifos
Chlorophyll-a
Chloride
Chlordane
Listed for:
Water Body
Alisal Creek (Monterey County)
Alisal Slough (Monterey County)
Blanco Drain
Espinosa Lake
Espinosa Slough
Gabilan Creek
Merrit Ditch
Moss Landing Harbor
Natividad Creek
Old Salinas River
Old Salinas River Estuary
Salinas Reclamation Canal
Salinas River (lower, estuary to near Gonzales Rd
crossing, watersheds 30910 and 30920)
Salinas River Lagoon (North)
Santa Rita Creek (Monterey County)
Tembladero Slough
Ammonia (Unionized)
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
4/1/2014
Jun-07
1,523
0
1,874
3,397
0.0
0
3,397
Jul-07
1,517
0
1,957
3,474
0.0
0
3,474
Aug-07
1,115
0
1,927
3,042
0.0
0
3,042
Sep-07
380
0
1,616
1,996
0.4
400
2,396
Oct-07
125
0
1,129
1,254
1.1
1100
2,354
Jul-10
267
1,035
1,889
3,191
0.0
0
3,191
Aug-10
272
968
1,902
3,142
0.0
0
3,142
Sep-10
191
478
1,821
2,490
0.0
0
2,490
May-11
284
593
1,694
2,571
0.7
700
3,271
Jun-11
428
1,020
1,713
3,161
0.3
300
3,461
Jul-11
316
1,145
1,869
3,330
0.0
0
3,330
Scale to 6,000 ac
1698.5
1737
1521
1198
1177
1595.5
1571
1245
1635.5
1730.5
1665
114.2
1584.3
6.7%
312.2
1424.8
18.0%
229.2
1291.8
15.1%
178.7
1019.3
14.9%
72.1
1104.9
6.1%
106.8
1488.7
6.7%
355.1
1215.9
22.6%
225.9
1019.1
18.1%
362.8
1272.7
22.2%
363
1367.5
21.0%
319.7
1345.3
19.2%
CSIP-Wells (AF)
SRDF-River (AF)
SVRP-Recycled (AF)
Total Irrig (AF)
Precip (in)
Precip (AF)
Total (AF)
Net Loss
Percent Return
Notes:
CSIP/SRDF/SVRP data from MCWRA
CSIP Service area approx 12,000 acres
Blanco Drain area approx 6,000 acres
Rainfall measured at Salinas Airport gage
Measured flow from weir (2007) and Blanco Drain pump station (2010-2012)
April and October are omitted from summary (partial month data)
AVG
1175
17.3%
Blanco_Flow_Data.xlsx/Return Flows
MAX
1886
24.6%
MIN
577
3.4%
12/31/2014
Sep-11
419
0
1,617
2,036
0.0
0
2,036
Apr-12
80
0
1,044
1,124
1.9
1900
3,024
May-12
125
618
1,745
2,488
0.1
100
2,588
Jun-12
276
906
1,764
2,946
0.2
200
3,146
Jul-12
214
992
1,834
3,040
0.0
0
3,040
Aug-12
311
799
1,847
2,957
0.0
0
2,957
Sep-12
135
314
1,734
2,183
0.0
0
2,183
Oct-12
16
65
1,168
1,249
0.2
200
1,449
Nov-12
72
0
731
803
3.1
3100
3,903
Aug-13
263
220
1803
2,286
0
0
2,286
Sep-13
248
537
1725
2,510
0.1
100
2,610
Oct-13
165
133
1548
1,846
0.2
200
2,046
1575
1018
1512
1294
1573
1520
1478.5
1091.5
724.5
1951.5
1143
1305
1023
301.3
1273.7
19.1%
226.1
791.9
22.2%
333.2
1178.8
22.0%
307.4
986.6
23.8%
333.2
1239.8
21.2%
325.9
1194.1
21.4%
295.1
1183.4
20.0%
214.2
877.3
19.6%
147.6
576.9
20.4%
65.5
1886
3.4%
281.2
861.9
24.6%
202.9
1102.1
15.5%
107.5
915.5
10.5%
Blanco_Flow_Data.xlsx/Return Flows
12/31/2014
Table B-3: Applied Irrigation and Recorded Rainfall within the CSIP Service Area (Acre Feet)
MCWRA & NOAA DATA
Source
Scale to
6000 ac
17%
return
AVG
3,258
1,629
277
Aug-13
263
220
1,803
0.0
2,286
AVG
2,872
1,436
244
Sep-12
135
314
1,734
0.0
2,183
Sep-13
248
537
1,725
0.1
2,610
AVG
2,160
1,080
184
Oct-11
54
0
733
1.5
2,287
Oct-12
16
65
1,168
0.2
1,449
Oct-13
165
133
1,548
0.2
2,046
AVG
1,978
989
168
Nov-10
246
0
179
2.0
2,425
Nov-11
238
0
224
1.8
2,262
Nov-12
72
0
731
3.1
3,903
Nov-13
35
0
1,127
0.5
1,662
AVG
1,564
782
133
Jan-00
194
0
0
1.6
1,794
Dec-00
69
0
0
3.0
3,069
Dec-01
723
0
0
0.0
723
Dec-02
44
0
0
3.3
3,344
Dec-03
730
0
88
0.2
1,018
AVG
2,175
1,088
185
Jan-09
485
0
0
1.3
1,785
Jan-10
100
0
0
4.0
4,100
Jan-11
333
0
26
1.7
2,059
Jan-12
1,067
0
0
1.6
2,667
Jan-13
253
0
0
1.0
1,253
Jan-14
AVG
2,458
1,229
209
Feb-08
171
0
173
0.9
1,244
Feb-09
235
0
112
3.5
3,847
Feb-10
143
0
0
3.1
3,243
Feb-11
100
0
580
2.9
3,580
Feb-12
162
0
1,031
0.8
1,993
Feb-13
334
0
692
0.6
1,626
Feb-14
AVG
2,628
1,314
223
Mar-07
459
0
1,099
0.5
2,058
Mar-08
520
0
1,602
0.3
2,422
Mar-09
408
0
676
1.8
2,884
Mar-10
529
0
49
2.4
2,978
Mar-11
154
0
450
4.2
4,804
Mar-12
211
0
929
2.6
3,740
Mar-13
218
0
1,561
0.4
2,179
Mar-14
AVG
2,892
1,446
246
Apr-06
195
0
328
2.9
3,423
Apr-07
496
0
1,642
1.0
3,138
Apr-08
1,513
0
1,806
0.2
3,519
Apr-09
1,054
0
1,702
0.2
2,956
Apr-10
143
0
839
3.4
4,382
Apr-11
544
0
1,650
0.1
2,294
Apr-12
80
0
1,044
1.9
3,024
Apr-13
239
501
1,679
0.3
2,719
Apr-14
AVG
2,961
1,481
252
May-05
388
0
1,770
0.8
2,958
May-06
249
0
1,751
0.7
2,700
May-07
417
0
1,907
0.1
2,424
May-08
939
0
1,914
0.0
2,853
May-09
822
0
1,717
0.3
2,839
May-10
150
375
1,737
0.6
2,862
May-11
284
593
1,694
0.7
3,271
May-12
125
618
1,745
0.1
2,588
May-13
239
1,219
1,799
0.0
3,257
May-14
AVG
2,647
1,323
225
Jun-04
1,653
0
1,913
0.0
3,566
Jun-05
1,402
0
1,833
0.2
3,435
Jun-06
1,394
0
1,903
0.0
3,297
Jun-07
1,523
0
1,874
0.0
3,397
Jun-08
1,726
0
1,797
0.0
3,523
Jun-09
1,391
0
1,750
0.1
3,241
Jun-10
570
944
1,838
0.0
3,352
Jun-11
428
1,020
1,713
0.3
3,461
Jun-12
276
906
1,764
0.2
3,146
Jun-13
363
1,224
1,677
0.0
3,264
Jun-14
AVG
3,226
1,613
274
FY 03-04
8,109
0
13,873
10
32,082
FY 04-05
6,817
0
10,937
20
37,454
FY 05-06
5,798
0
10,865
15
31,963
FY 06-07
7,084
0
14,165
8
29,549
FY 07-08
9,234
0
13,921
9
32,455
FY 08-09
7,703
0
13,886
11
32,589
FY 09-10
5,838
1,319
10,198
17
34,655
FY 10-11
2,908
4,174
12,910
16
35,492
FY 11-12
4,239
3,378
12,829
11
30,946
FY 12-13
2,438
5,114
14,722
9
31,174
FY 12-13
1,539
2,150
8,077
1
12,766
Scaled
to 6000 ac
17%
Return
14,884
2,530
Dry
Dry
FY 98-99
FY 99-00
FY 00-01
FY 01-02
FY 02-03
FY 03-04
FY 04-05
FY 05-06
FY 06-07
FY 07-08
FY 08-09
FY 09-10
FY 10-11
FY 11-12
FY 12-13
FY 12-13
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Jul-98
772
0
1,114
0.0
1,886
Jul-99
1,318
0
1,870
0.0
3,188
Jul-00
1,234
0
1,886
0.0
3,120
Jul-01
1,535
0
1,879
0.0
3,414
Jul-02
1,363
0
1,900
0.0
3,263
Jul-03
1,821
0
1,898
0.0
3,719
Jul-04
1,565
0
1,957
0.0
3,522
Jul-05
1,507
0
1,906
0.0
3,413
Jul-06
1,424
0
1,931
0.0
3,355
Jul-07
1,517
0
1,957
0.0
3,474
Jul-08
1,590
0
1,943
0.0
3,533
Jul-09
1,699
0
1,837
0.0
3,536
Jul-10
267
1,035
1,889
0.0
3,191
Jul-11
316
1,145
1,869
0.0
3,330
Jul-12
214
992
1,834
0.0
3,040
Jul-13
98
1,260
1,786
0.0
3,144
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Aug-98
748
0
1,118
0.0
1,866
Aug-99
899
0
1,772
0.0
2,671
Aug-00
774
0
1,843
0.1
2,717
Aug-01
1,105
0
1,944
0.0
3,049
Aug-02
1,073
0
1,877
0.0
2,950
Aug-03
1,283
0
1,889
0.1
3,272
Aug-04
1,145
0
1,954
0.0
3,099
Aug-05
770
0
1,838
0.0
2,608
Aug-06
1,103
0
1,925
0.0
3,028
Aug-07
1,115
0
1,927
0.0
3,042
Aug-08
969
0
1,906
0.0
2,875
Aug-09
1,107
0
1,839
0.3
3,246
Aug-10
272
968
1,902
0.0
3,142
Aug-11
568
709
1,873
0.0
3,150
Aug-12
311
799
1,847
0.0
2,957
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Sep-98
226
0
989
0.1
1,315
Sep-99
368
0
1,398
0.0
1,766
Sep-00
517
0
1,460
0.1
2,077
Sep-01
417
0
1,505
0.1
2,022
Sep-02
793
0
1,435
0.0
2,228
Sep-03
561
0
1,750
0.0
2,311
Sep-04
727
0
1,821
0.0
2,548
Sep-05
337
0
1,689
0.0
2,026
Sep-06
342
0
1,782
0.0
2,124
Sep-07
380
0
1,616
0.4
2,396
Sep-08
545
0
1,683
0.0
2,228
Sep-09
509
0
1,594
0.1
2,203
Sep-10
191
478
1,821
0.0
2,490
Sep-11
419
0
1,617
0.0
2,036
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Oct-98
309
0
432
0.5
1,241
Oct-99
370
0
1,017
0.1
1,487
Oct-00
450
0
475
2.5
3,425
Oct-01
164
0
1,276
0.0
1,440
Oct-02
162
0
1,316
0.0
1,478
Oct-03
174
0
1,371
0.2
1,745
Oct-04
183
0
862
2.8
3,845
Oct-05
115
0
1,241
0.1
1,456
Oct-06
172
0
1,509
0.0
1,681
Oct-07
125
0
1,129
1.1
2,354
Oct-08
140
0
1,378
0.2
1,718
Oct-09
119
0
465
1.7
2,284
Oct-10
20
80
1,006
0.6
1,706
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Nov-98
77
0
32
2.3
2,409
Nov-99
82
0
153
1.1
1,335
Nov-00
230
0
0
0.2
430
Nov-01
11
0
260
0.9
1,171
Nov-02
183
0
184
0.9
1,267
Nov-03
134
0
149
0.8
1,083
Nov-04
171
0
0
0.4
571
Nov-05
330
0
209
0.4
939
Nov-06
90
0
342
1.3
1,732
Nov-07
692
0
0
0.4
1,092
Nov-08
35
0
730
1.3
2,065
Nov-09
575
0
0
0.1
675
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Dec-98
72
0
0
0.9
972
Dec-99
215
0
0
0.1
315
Dec-00
397
0
0
0.7
1,097
Dec-01
10
0
0
1.6
1,610
Dec-02
107
0
0
2.8
2,907
Dec-03
40
0
0
3.9
3,940
Dec-04
150
0
0
3.8
3,950
Dec-05
85
0
0
3.3
3,385
Dec-06
119
0
0
2.3
2,419
Dec-07
445
0
0
1.2
1,645
Dec-08
29
0
289
2.3
2,618
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Jan-99
169
0
22
2.6
2,791
Jan-00
202
0
0
4.9
5,102
Jan-01
189
0
0
2.9
3,089
Jan-02
151
0
0
0.2
351
Jan-03
130
0
0
0.7
830
Jan-04
179
0
0
1.5
1,679
Jan-05
83
0
0
2.7
2,783
Jan-06
109
0
0
2.0
2,109
Jan-07
687
0
0
0.7
1,387
Jan-08
91
0
0
4.8
4,891
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Feb-99
52
0
58
3.1
3,210
Feb-00
43
0
0
4.2
4,243
Feb-01
128
0
0
3.0
3,128
Feb-02
358
0
385
0.3
1,043
Feb-03
345
0
32
0.7
1,077
Feb-04
121
0
1
3.1
3,222
Feb-05
280
0
0
3.4
3,680
Feb-06
583
0
0
0.9
1,483
Feb-07
252
0
154
2.4
2,806
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Mar-99
138
0
35
1.8
1,973
Mar-00
651
0
11
1.7
2,362
Mar-01
529
0
422
1.6
2,551
Mar-02
233
0
791
0.4
1,424
Mar-03
473
0
1,184
0.6
2,257
Mar-04
455
0
1,121
0.5
2,076
Mar-05
241
0
0
4.3
4,541
Mar-06
124
0
0
5.0
5,124
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Apr-99
601
0
586
1.4
2,587
Apr-00
678
0
1,136
0.4
2,214
Apr-01
587
0
1,332
1.8
3,719
Apr-02
564
0
1,763
0.1
2,427
Apr-03
190
0
1,381
1.2
2,771
Apr-04
878
0
1,848
0.0
2,726
Apr-05
482
0
740
1.3
2,522
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
May-99
313
0
1,561
0.0
1,874
May-00
439
0
1,283
0.6
2,322
May-01
531
0
1,805
0.0
2,336
May-02
446
0
1,770
0.0
2,216
May-03
535
0
1,722
0.2
2,457
May-04
810
0
1,933
0.0
2,743
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
Jun-99
743
0
1,615
0.1
2,458
Jun-00
1,051
0
1,793
0.0
2,844
Jun-01
1,359
0
1,877
0.0
3,236
Jun-02
1,256
0
1,664
0.0
2,920
Jun-03
1,435
0
1,808
0.0
3,243
Totals
CSIP-Wells
SRDF-River
SVRP-Recycled
Precip (in)
Total Irrig (AF)
FY 98-99
4,220
0
7,562
13
24,582
FY 99-00
6,316
0
10,433
13
29,849
FY 00-01
6,925
0
11,100
13
30,925
FY 01-02
6,250
0
13,237
4
23,087
FY 02-03
6,789
0
12,839
7
26,728
Dry
Dry
Year Type
Normal
5.8
Normal
7.0
Normal
7.3
5.4
6.3
Normal
7.5
Wet
8.8
Normal
7.5
6.9
7.6
Normal
7.7
Wet
8.1
Normal
8.3
Normal
7.3
AVG
29,769
Dry
7.3
Sum of monthly values:
15,410
2,620
Year
Type
Wet
Normal
Dry
Blanco_Flow_Data.xlsx/MCWRA
Average
Total Irrig
(AF)
36,055
31,054
28,599
Scale to
6,000 ac
(AF)
18,027
15,527
14,299
17%
Return
(AF)
3,065
2,640
2,431
4/9/2014
Table B-4: Water Rights Database GIS Capture, PODs near Salinas
Application ID
A013225
A016124
A016761
A030532
S014817
S014826
S014867
S014868
S014869
S014870
S014872
S014873
S014874
S014875
S014876
S014877
S014878
S014879
S014880
S014881
S014882
S014883
S014884
S014885
S014886
S014887
S014888
S014889
S014890
S014892
S014893
S014894
S014895
S014896
S016592
S021637
S021638
S021639
S021641
S021642
S023945
S023947
MPMW01_WaterRightsData.xlsx/Results-Salinas
Water
Right
Type ID
84
84
84
84
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
92
Status
Permitted
Licensed
Licensed
Permitted
Inactive
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Inactive
Inactive
Inactive
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Claimed
Holder Name
MONTEREY COUNTY WATER RESOURCES AGENCY
MONTEREY COUNTY WATER RESOURCES AGENCY
MONTEREY COUNTY WATER RESOURCES AGENCY
MONTEREY COUNTY WATER RESOURCES AGENCY
STEPHEN JENSEN
ELMER N JENSEN & ELSIE R JENSEN LIVING TRUST
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA & ANTLE INC
TANIMURA & ANTLE INC
TANIMURA & ANTLE INC
T. Yuki Farms, LPII
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
Robert Tanimura 1980 IrrevocableTrust; et al
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
TANIMURA LAND COMPANY LLC
Tanimura & Antle Partnership; et al
Tanimura & Antle Partnership; et al
Tanimura & Antle Partnership; et al
Tanimura & Antle Partnership; et al
Tanimura & Antle Partnership; et al
TANIMURA LAND COMPANY LLC
PORTER FAMILY PARTNERSHIP, LP
PORTER FAMILY PARTNERSHIP, LP
M.B.T. FAMILY PARTNERSHIP
THE HARDY FAMILY TRUST, ET AL.
THE HARDY FAMILY TRUST, ET AL.
TANIMURA & ANTLE
TANIMURA & ANTLE
Date
Face Amt
County
Watershed
Source
7/11/1949
168,538.0 Monterey
SALINAS,<br>SALINAS
SALINAS RIVER
11/4/1954
350,000.0 Monterey, San Luis
SALINAS,<br>SALINAS
Obispo
NACIMIENTO RIVER, Salinas River
12/2/1955
220,000.0 Monterey
SALINAS,<br>SALINAS
SAN ANTONIO RIVER, Salinas River
3/25/1996
27,900.0 Monterey, San Luis
SALINAS,<br>SALINAS
Obispo
NACIMIENTO RIVER, Salinas River
7/5/2000
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
5/28/1997
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
6/28/2013
Monterey
SALINAS
GROUNDWATER USE
6/28/2013
Monterey
SALINAS
GROUNDWATER USE
6/28/2013
Monterey
SALINAS
GROUNDWATER USE
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
5/30/2013
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
1/22/1998
Monterey
SALINAS
SALINAS RIVER UNDERFLOW
7/6/2010
192.4 Monterey
SALINAS
Salinas River Underflow
7/6/2010
136,339.0 Monterey
SALINAS
Salinas River Underflow
7/6/2010
107,448.0 Monterey
SALINAS
Salinas River Underflow
7/6/2010
202,417.0 Monterey
SALINAS
Salinas River Underflow
7/6/2010
262.5 Monterey
SALINAS
Salinas River Underflow
7/6/2010
333.8 Monterey
SALINAS
Salinas River Underflow
7/2/2013
Monterey
SALINAS
Salinas Valley Basin
7/2/2013
Monterey
SALINAS
Salinas Valley Basin
4/10/2014
Table B-5: Surface Water Rights and Claims in the Salinas River below Spreckels
Water Right ID
Source
Totals
Direct
Diversion
Rate (cfs)
Face Value
Direct Diversion Direct Diversion
Season
Amount Oct. 1Mar. 31 (af)
Face Value
Storage
Amount (af)
Storage Season
350,000
220,000
27,900
135,000
197,000
26,410
84,270
158,633
72,175
-
732,900
712,900
307,680
230,808
M, D, I, J, R
M, D, I, J, R
M, D, I, J, R
I, M
MPMW01_WaterRightsData.xlsx/Table B-5
4/9/2014
Stream
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Blanco Drain
Location
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
above Salinas River
Analyte Name
Ammonia as N, Unionized
Ammonia as NH3
Chlorophyll a, water column
Chlorpyrifos
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Oxygen, Dissolved
Turbidity
No.
Samples
53
37
54
55
59
60
98
99
55
94
Units
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
NTU
Mean
0.014
0.20
0.0021
0.0009
0.01
2,019.70
65.27
0.85
0.20
66.48
Min
0.0009
0.00
0.00
0.00
0.00
1,450.00
0.01
0.01
0.00
0.10
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
Salinas River
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
below Spreckels
Ammonia as N, Unionized
Ammonia as NH3
Chlorophyll a, water column
Chlorpyrifos
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Oxygen, Dissolved
Turbidity
37
38
36
32
32
38
76
75
37
58
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
mg/L
NTU
0.02
0.12
0.0033
0.0011
0.008
369.60
5.08
0.23
0.36
118.66
0.0007
0.00
0.0003
0.00
0.00
230.00
0.002
0.0075
0.00
1.40
0.13
0.98
0.023
0.029
0.22
610.00
78.00
2.60
2.66
2,584.00
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Salinas Lagoon
Ammonia as NH3
Chlorpyrifos
Diazinon
Nitrate as N
OrthoPhosphate as P
Turbidity
32
28
24
32
33
18
mg/L
mg/L
mg/L
mg/L
mg/L
NTU
0.05
0.000064
0.000036
11.31
0.31
29.77
0.00
0.00
0.00
0.06
0.00
3.76
0.52
0.00021
0.00020
67.00
1.09
76.70
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
above Potrero Rd
Ammonia as N, Unionized
Ammonia as NH3
Chloride
Chlorophyll a, water column
Chlorpyrifos
Coliform, Fecal
Coliform, Total
Diazinon
Dissolved Solids, Total
Nitrate as N
OrthoPhosphate as P
Oxygen, Dissolved
Suspended Solids, Total
Turbidity
0.0075
0.24
2,504.48
0.029
0.00022
3,222.87
19,573.45
0.011
5,964.12
19.50
0.42
1.02
113.33
183.41
0.0002
0.00
79.00
0.00045
0.000044
23.00
260.00
0.00
193.00
0.00
0.00
0.00
5.00
0.10
0.027
1.17
17,000.00
0.24
0.0010
92,000.00
240,000.00
0.21
59,000.00
64.00
2.40
18.03
578.00
4,869.00
96
mg/L
22
mg/L
109
mg/L
134
mg/L
33
mg/L
106 MPN/100 ml
106 MPN/100 ml
31
mg/L
116
mg/L
138
mg/L
138
mg/L
138
mg/L
114
mg/L
158
NTU
Max
0.26
4.96
0.028
0.018
0.17
2,250.00
325.00
4.40
2.52
1,210.00
WQ_Summary_Tables.xlsx/Tables-Blanco
4/9/2014
Units
mg/L
mg/L
mg/L
mg/L
Chlorpyrifos
Coliform, Fecal
Coliform, Total
mg/L
MPN/100 ml
MPN/100 ml
Diazinon
Dissolved Solids, Total
Nitrate as N (all streams with MUN use)
mg/L
mg/L
mg/L
mg/L
mg/L
Oxygen, Dissolved
Suspended Solids, Total
Turbidity
mg/L
mg/L
NTU
mg/L
Standard
0.025
0.025
150
0.015
CMC 0.00025
CCC 0.00015
400
10,000
CMC 0.00016
CCC 0.00010
1000
10
1.4 (dry season)
8.0 (wet season)
6.4 (dry season)
8.0 (wet season)
3.1 (dry season)
8.0 (wet season)
0.07 (dry season)
0.30 (wet season)
0.13 (dry season)
0.30 (wet season)
>7.0 and <13.0 (Cold)
>5.0 and <13.0 (Warm)
500
10
Reference
Board Order R3-2013-0008
CCAMP Proposed
Basin Plan
Board Order R3-2013-0008
Board Decision 2011
Basin Plan, Water Body Contact
US EPA
CC RWQCB Decision 2011
CCAMP Proposed
Board Order R3-2013-0008
Board Order R3-2013-0008
WQ_Summary_Tables.xlsx/Standards
4/9/2014
Monterey Peninsula
Water Management District
C-1
December 2014
Table C-1: Blanco Drain Diversion Pump Station, 16-inch Force Main
System Head Calculations
Number of Pumps in Parallel
Pump Discharge Diameter (inches)
Length of Pump Discharge (feet)
Discharge Hazen-Williams Coefficient (C)
Force Main Diameter in PS#2 (inches)
Force Main Length in PS#2 (feet)
Force Main Diameter from PS#2 to MH (inches)
Force Main Length from PS#2 to MH (feet)
Force Main Hazen-Williams Coefficient (C)
Outfall Elevation (feet)
Wetwell Pumping Level (feet)
Static Lift (feet)
Flow
(gpm)
Velocity
(fps)
0
0.00
100
0.28
200
0.57
300
0.85
400
1.13
500
1.42
600
1.70
700
1.99
800
2.27
900
2.55
1,000
2.84
1,100
3.12
1,200
3.40
1,300
3.69
1,400
3.97
1,500
4.26
1,600
4.54
1,700
4.82
1,800
5.11
1,900
5.39
2,000
5.67
2,100
5.96
2,200
6.24
2,300
6.53
2,400
6.81
2,500
7.09
2,600
7.38
2,700
7.66
2,800
7.94
2,900
8.23
3,000
8.51
3,100
8.79
3,200
9.08
3,300
9.36
3,400
9.65
3,500
9.93
3,600
10.21
3,700
10.50
3,800
10.78
3,900
11.06
4,000
Schaaf and Wheeler11.35
Velocity
Head
(ft)
Friction
Loss
(ft)
0.00
0.00
0.00
0.01
0.02
0.03
0.04
0.06
0.08
0.10
0.12
0.15
0.18
0.21
0.24
0.28
0.32
0.36
0.40
0.45
0.50
0.55
0.60
0.66
0.72
0.78
0.84
0.91
0.98
1.05
1.12
1.20
1.28
1.36
1.44
1.53
1.62
1.71
1.80
1.90
2.00
0.00
0.00
0.01
0.01
0.02
0.03
0.04
0.05
0.07
0.08
0.10
0.12
0.14
0.17
0.19
0.22
0.24
0.27
0.30
0.33
0.37
0.40
0.44
0.48
0.52
0.56
0.60
0.64
0.69
0.73
0.78
0.83
0.88
0.93
0.98
1.04
1.09
1.15
1.21
1.27
1.33
K:
Flare
Elbow
0
(ft)
Suction
Elbow
0
(ft)
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Fitting
45 Elbow
90 Elbow
22.5 Elbow
11.25 Elbow
GV
CV
Reducer
FR Elbow
Tee branch
1
12
40
130
16
0
16
9500
120
143.00
3.00
140.00
Force Main in PS
Minor Losses
Discharge
Tee
Elbows
Branch
0.8
0
(ft)
(ft)
0.00
0.00
0.00
0.01
0.02
0.02
0.04
0.05
0.06
0.08
0.10
0.12
0.14
0.17
0.20
0.22
0.26
0.29
0.32
0.36
0.40
0.44
0.48
0.53
0.58
0.62
0.68
0.73
0.78
0.84
0.90
0.96
1.02
1.09
1.16
1.22
1.30
1.37
1.44
1.52
1.60
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Gate
Valve
0.3
(ft)
Check
Valve
2.5
(ft)
Total
Minor
Losses
(ft)
Flow
(gpm)
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.02
0.02
0.03
0.04
0.05
0.05
0.06
0.07
0.08
0.10
0.11
0.12
0.14
0.15
0.17
0.18
0.20
0.22
0.23
0.25
0.27
0.29
0.32
0.34
0.36
0.38
0.41
0.43
0.46
0.49
0.51
0.54
0.57
0.60
0.00
0.00
0.01
0.03
0.05
0.08
0.11
0.15
0.20
0.25
0.31
0.38
0.45
0.53
0.61
0.70
0.80
0.90
1.01
1.13
1.25
1.38
1.51
1.65
1.80
1.95
2.11
2.28
2.45
2.63
2.81
3.00
3.20
3.40
3.61
3.83
4.05
4.28
4.51
4.75
5.00
0.00
0.00
0.02
0.04
0.07
0.11
0.16
0.22
0.29
0.36
0.45
0.54
0.65
0.76
0.88
1.01
1.15
1.30
1.46
1.62
1.80
1.98
2.18
2.38
2.59
2.81
3.04
3.28
3.53
3.78
4.05
4.32
4.61
4.90
5.20
5.51
5.83
6.16
6.50
6.84
7.20
0
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
K Value
0.2
0.3
0.075
0
0.3
2.5
0.03
0.3
0.75
Velocity
(fps)
Velocity
Head
(ft)
Friction
Loss
(ft)
0.0
Minor
Losses
(ft)
0.00
0.16
0.32
0.48
0.64
0.80
0.96
1.12
1.28
1.44
1.60
1.76
1.91
2.07
2.23
2.39
2.55
2.71
2.87
3.03
3.19
3.35
3.51
3.67
3.83
3.99
4.15
4.31
4.47
4.63
4.79
4.95
5.11
5.27
5.43
5.59
5.74
5.90
6.06
6.22
6.38
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.02
0.03
0.03
0.04
0.05
0.06
0.07
0.08
0.09
0.10
0.11
0.13
0.14
0.16
0.17
0.19
0.21
0.23
0.25
0.27
0.29
0.31
0.33
0.36
0.38
0.40
0.43
0.46
0.48
0.51
0.54
0.57
0.60
0.63
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Flow
(gpm)
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
Velocity
(fps)
Velocity
Head
(ft)
Friction
Loss
(ft)
0.3
Minor
Losses
(ft)
Total
Loss
(ft)
TDH
(ft)
Pump
Flow
(gpm)
0.00
0.16
0.32
0.48
0.64
0.80
0.96
1.12
1.28
1.44
1.60
1.76
1.91
2.07
2.23
2.39
2.55
2.71
2.87
3.03
3.19
3.35
3.51
3.67
3.83
3.99
4.15
4.31
4.47
4.63
4.79
4.95
5.11
5.27
5.43
5.59
5.74
5.90
6.06
6.22
6.38
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.02
0.03
0.03
0.04
0.05
0.06
0.07
0.08
0.09
0.10
0.11
0.13
0.14
0.16
0.17
0.19
0.21
0.23
0.25
0.27
0.29
0.31
0.33
0.36
0.38
0.40
0.43
0.46
0.48
0.51
0.54
0.57
0.60
0.63
0.00
0.10
0.35
0.75
1.27
1.92
2.70
3.59
4.59
5.71
6.94
8.27
9.72
11.27
12.92
14.68
16.55
18.51
20.57
22.74
25.00
27.36
29.82
32.38
35.03
37.78
40.62
43.56
46.59
49.72
52.93
56.24
59.65
63.14
66.73
70.40
74.17
78.02
81.97
86.01
90.13
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.01
0.01
0.02
0.02
0.02
0.03
0.03
0.03
0.04
0.04
0.05
0.05
0.06
0.06
0.07
0.07
0.08
0.09
0.09
0.10
0.11
0.11
0.12
0.13
0.14
0.15
0.15
0.16
0.17
0.18
0.19
0.00
0.10
0.38
0.80
1.37
2.07
2.90
3.86
4.95
6.17
7.50
8.95
10.53
12.21
14.02
15.94
17.97
20.12
22.37
24.74
27.22
29.80
32.50
35.30
38.21
41.22
44.34
47.57
50.90
54.33
57.87
61.51
65.25
69.10
73.05
77.09
81.24
85.49
89.85
94.30
98.85
140.00
140.10
140.38
140.80
141.37
142.07
142.90
143.86
144.95
146.17
147.50
148.95
150.53
152.21
154.02
155.94
157.97
160.12
162.37
164.74
167.22
169.80
172.50
175.30
178.21
181.22
184.34
187.57
190.90
194.33
197.87
201.51
205.25
209.10
213.05
217.09
221.24
225.49
229.85
234.30
238.85
0
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
HP at
75% eff.
HP
0
5
9
14
19
24
29
34
39
44
50
55
61
67
73
3 cfs
79
85
92
98
105
113
120
128
136
5 cfs
144
153
161
171
180
190
200
210
221
7 cfs
232
244
256
268
281
294
308
322
July 12, 2005
Table C-2: Blanco Drain Divserion Pump Station, 20-inch Force Main
System Head Calculations
Number of Pumps in Parallel
Pump Discharge Diameter (inches)
Length of Pump Discharge (feet)
Discharge Hazen-Williams Coefficient (C)
Force Main Diameter in PS#2 (inches)
Force Main Length in PS#2 (feet)
Force Main Diameter from PS#2 to MH (inches)
Force Main Length from PS#2 to MH (feet)
Force Main Hazen-Williams Coefficient (C)
Outfall Elevation (feet)
Wetwell Pumping Level (feet)
Static Lift (feet)
Flow
(gpm)
Velocity
(fps)
0
0.00
100
0.21
200
0.42
300
0.63
400
0.83
500
1.04
600
1.25
700
1.46
800
1.67
900
1.88
1,000
2.08
1,100
2.29
1,200
2.50
1,300
2.71
1,400
2.92
1,500
3.13
1,600
3.33
1,700
3.54
1,800
3.75
1,900
3.96
2,000
4.17
2,100
4.38
2,200
4.59
2,300
4.79
2,400
5.00
2,500
5.21
2,600
5.42
2,700
5.63
2,800
5.84
2,900
6.04
3,000
6.25
3,100
6.46
3,200
6.67
3,300
6.88
3,400
7.09
3,500
7.30
3,600
7.50
3,700
7.71
3,800
7.92
3,900
8.13
4,000
8.34
Schaaf and Wheeler
Velocity
Head
(ft)
Friction
Loss
(ft)
0.00
0.00
0.00
0.01
0.01
0.02
0.02
0.03
0.04
0.05
0.07
0.08
0.10
0.11
0.13
0.15
0.17
0.19
0.22
0.24
0.27
0.30
0.33
0.36
0.39
0.42
0.46
0.49
0.53
0.57
0.61
0.65
0.69
0.73
0.78
0.83
0.87
0.92
0.97
1.03
1.08
0.00
0.00
0.00
0.01
0.01
0.01
0.02
0.02
0.03
0.04
0.05
0.06
0.07
0.08
0.09
0.10
0.12
0.13
0.14
0.16
0.17
0.19
0.21
0.23
0.24
0.26
0.28
0.30
0.32
0.35
0.37
0.39
0.41
0.44
0.46
0.49
0.52
0.54
0.57
0.60
0.63
K:
Flare
Elbow
0
(ft)
Suction
Elbow
0
(ft)
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Fitting
K Value
45 Elbow
0.2
90 Elbow
0.3
22.5 Elbow
0.075
11.25 Elbow
0
GV
0.3
CV
2.5
Reducer
0.03
FR Elbow
0.3
Tee branch
0.75
1
14
40
130
16
0
20
9500
120
143.00
3.00
140.00
Force Main in PS
Minor Losses
Discharge
Tee
Elbows
Branch
0.8
0
(ft)
(ft)
0.00
0.00
0.00
0.00
0.01
0.01
0.02
0.03
0.03
0.04
0.05
0.07
0.08
0.09
0.11
0.12
0.14
0.16
0.17
0.19
0.22
0.24
0.26
0.29
0.31
0.34
0.36
0.39
0.42
0.45
0.49
0.52
0.55
0.59
0.62
0.66
0.70
0.74
0.78
0.82
0.86
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Gate
Valve
0.3
(ft)
Check
Valve
2.5
(ft)
Total
Minor
Losses
(ft)
Flow
(gpm)
0.00
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.01
0.02
0.02
0.02
0.03
0.03
0.04
0.05
0.05
0.06
0.07
0.07
0.08
0.09
0.10
0.11
0.12
0.13
0.14
0.15
0.16
0.17
0.18
0.19
0.21
0.22
0.23
0.25
0.26
0.28
0.29
0.31
0.32
0.00
0.00
0.01
0.02
0.03
0.04
0.06
0.08
0.11
0.14
0.17
0.20
0.24
0.29
0.33
0.38
0.43
0.49
0.55
0.61
0.67
0.74
0.82
0.89
0.97
1.05
1.14
1.23
1.32
1.42
1.52
1.62
1.73
1.84
1.95
2.07
2.19
2.31
2.44
2.57
2.70
0.00
0.00
0.01
0.02
0.04
0.06
0.09
0.12
0.16
0.20
0.24
0.29
0.35
0.41
0.48
0.55
0.62
0.70
0.79
0.88
0.97
1.07
1.18
1.28
1.40
1.52
1.64
1.77
1.90
2.04
2.19
2.33
2.49
2.64
2.81
2.97
3.15
3.32
3.51
3.69
3.89
0
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
Velocity
(fps)
Velocity
Head
(ft)
Friction
Loss
(ft)
0.0
Minor
Losses
(ft)
0.00
0.16
0.32
0.48
0.64
0.80
0.96
1.12
1.28
1.44
1.60
1.76
1.91
2.07
2.23
2.39
2.55
2.71
2.87
3.03
3.19
3.35
3.51
3.67
3.83
3.99
4.15
4.31
4.47
4.63
4.79
4.95
5.11
5.27
5.43
5.59
5.74
5.90
6.06
6.22
6.38
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.02
0.03
0.03
0.04
0.05
0.06
0.07
0.08
0.09
0.10
0.11
0.13
0.14
0.16
0.17
0.19
0.21
0.23
0.25
0.27
0.29
0.31
0.33
0.36
0.38
0.40
0.43
0.46
0.48
0.51
0.54
0.57
0.60
0.63
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Flow
(gpm)
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
Velocity
(fps)
Velocity
Head
(ft)
Friction
Loss
(ft)
0.3
Minor
Losses
(ft)
Total
Loss
(ft)
TDH
(ft)
Pump
Flow
(gpm)
HP at
75% eff.
HP
0.00
0.10
0.20
0.31
0.41
0.51
0.61
0.71
0.82
0.92
1.02
1.12
1.23
1.33
1.43
1.53
1.63
1.74
1.84
1.94
2.04
2.14
2.25
2.35
2.45
2.55
2.66
2.76
2.86
2.96
3.06
3.17
3.27
3.37
3.47
3.57
3.68
3.78
3.88
3.98
4.09
0.00
0.00
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.01
0.02
0.02
0.02
0.03
0.03
0.04
0.04
0.05
0.05
0.06
0.06
0.07
0.08
0.09
0.09
0.10
0.11
0.12
0.13
0.14
0.15
0.16
0.17
0.18
0.19
0.20
0.21
0.22
0.23
0.25
0.26
0.00
0.03
0.12
0.25
0.43
0.65
0.91
1.21
1.55
1.93
2.34
2.79
3.28
3.80
4.36
4.96
5.59
6.25
6.95
7.68
8.44
9.24
10.07
10.93
11.83
12.76
13.72
14.71
15.73
16.79
17.87
18.99
20.14
21.32
22.53
23.77
25.04
26.35
27.68
29.04
30.43
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.01
0.01
0.01
0.01
0.01
0.01
0.01
0.02
0.02
0.02
0.02
0.02
0.03
0.03
0.03
0.03
0.04
0.04
0.04
0.04
0.05
0.05
0.05
0.06
0.06
0.06
0.07
0.07
0.07
0.08
0.00
0.04
0.13
0.28
0.48
0.72
1.02
1.36
1.74
2.17
2.64
3.15
3.71
4.30
4.94
5.62
6.34
7.09
7.89
8.73
9.61
10.52
11.48
12.47
13.50
14.57
15.67
16.82
18.00
19.22
20.47
21.76
23.09
24.46
25.86
27.30
28.77
30.28
31.83
33.41
35.02
140.00
140.04
140.13
140.28
140.48
140.72
141.02
141.36
141.74
142.17
142.64
143.15
143.71
144.30
144.94
145.62
146.34
147.09
147.89
148.73
149.61
150.52
151.48
152.47
153.50
154.57
155.67
156.82
158.00
159.22
160.47
161.76
163.09
164.46
165.86
167.30
168.77
170.28
171.83
173.41
175.02
0
100
200
300
400
500
600
700
800
900
1,000
1,100
1,200
1,300
1,400
1,500
1,600
1,700
1,800
1,900
2,000
2,100
2,200
2,300
2,400
2,500
2,600
2,700
2,800
2,900
3,000
3,100
3,200
3,300
3,400
3,500
3,600
3,700
3,800
3,900
4,000
0
5
9
14
19
24
28
33
38
43
48
53
58
63
68
74
79
84
90
95
101
106
112
118
124
130
136
143
149
155
162
169
176
183
190
197
205
212
220
228
236
5 cfs
6 cfs
7 cfs
Table C-3: Estimated Cost of Construction of the Blanco Drain Diversion Pump Station
16" Force Main
Preliminary Design Cost Estimate
Item of Work
Unit
Unit Cost
Quantity
Mobilization / Demobilization
~ 5% of of project cost. This cost includes
permits, fees, temporary structures,
equipment rental and various misc. items
April-14
By: Josh Tabije
Subtotal
$86,000
Structures
96" Precast Manhole
Cast-In-Place Concrete
Concrete Dowel Inserts
Wetwell Inlet Pipe
EA
CY
EA
LF
$30,000
$1,000
$300
$300
1
40
30
80
$30,000
$40,000
$9,000
$24,000
$79,000
CY
SF
CY
CY
CY
CY
$140
$3
$410
$340
$420
$160
180
1200
20
4
4
38
$25,200
$3,600
$8,200
$1,360
$1,680
$6,080
$46,120
EA
LS
LF
EA
LS
$79,200
$12,000
$200
$17,900
$12,000
2
1
50
1
1
$158,400
$12,000
$10,000
$17,900
$12,000
$210,300
Force Main
16-Inch C900 PVC with Trench and Backfill
16-Inch C900 PVC HDD
LF
LF
$100
$600
9000
500
$900,000
$300,000
$1,200,000
Electrical Equipment
Electrical Equipment (Including Installation)
Electrical Conduit Run
LS
LF
$158,000
$100
1
100
$158,000
$10,000
$168,000
$1,789,420
$268,000
$358,000
$2,415,000
$966,000
This estimate of construction cost is a professional opinion, based upon the engineer's experience with the design and construction of
similar projects. It is prepared only as a guide and is subject to change. Schaaf & Wheeler and its subconsultants make no warranty,
whether expressed or implied, that the actual costs will not vary from these estimated costs, and assumes no liability for such variances.
This estimate specifically excludes any costs associated with designing for handling and disposal of hazardous wastes and contaminated
materials. Costs associated with land, right-of-way, or easement purchase are not included in this estimate.
Table C-4: Estimated Cost of Construction of the Blanco Drain Diversion Pump Station
20" Force Main
Preliminary Design Cost Estimate
Item of Work
Unit
Unit Cost
Quantity
Mobilization / Demobilization
~ 5% of of project cost. This cost includes
permits, fees, temporary structures,
equipment rental and various misc. items
2-Apr-14
By: Josh Tabije
Subtotal
$109,000
Structures
96" Precast Manhole
Cast-In-Place Concrete
Concrete Dowel Inserts
Wetwell Inlet Pipe
EA
CY
EA
LF
$30,000
$1,000
$300
$300
1
40
30
80
$30,000
$40,000
$9,000
$24,000
$79,000
CY
SF
CY
CY
CY
CY
$140
$3
$410
$340
$420
$160
180
1200
20
4
4
38
$25,200
$3,600
$8,200
$1,360
$1,680
$6,080
$46,120
EA
LS
LF
EA
LS
$128,700
$12,000
$200
$17,900
$12,000
2
1
50
1
1
$257,400
$12,000
$10,000
$17,900
$12,000
$309,300
Force Main
20-Inch C900 PVC with Trench and Backfill
20-Inch C900 PVC HDD
LF
LF
$130
$600
9000
500
$1,170,000
$300,000
$1,470,000
Electrical Equipment
Electrical Equipment (Including Installation)
Electrical Conduit Run
LS
LF
$257,000
$100
1
100
$257,000
$10,000
$267,000
$2,280,420
$342,000
$456,000
$3,078,000
$1,232,000
This estimate of construction cost is a professional opinion, based upon the engineer's experience with the design and construction of
similar projects. It is prepared only as a guide and is subject to change. Schaaf & Wheeler and its subconsultants make no warranty,
whether expressed or implied, that the actual costs will not vary from these estimated costs, and assumes no liability for such variances.
This estimate specifically excludes any costs associated with designing for handling and disposal of hazardous wastes and contaminated
materials. Costs associated with land, right-of-way, or easement purchase are not included in this estimate.
Monterey Peninsula
Water Management District
Appendix D: References
California Coastal Commission
Permit 3-01-019, Old Salinas River Channel Dredging
Permit 3-95-58, Salinas River Lagoon Culvert Replacement
California Department of Water Resources:
California
Irrigation
www.cimis.water.gov
Management
Information
System
(CIMIS)
website,
D-1
December 2014
Monterey Peninsula
Water Management District
Old Salinas River Channel, Fish Screen Hydraulic Study, prepared by Schaaf & Wheeler,
March 2009
Potrero Road Tide Gate Configuration and Performance Study, prepared by Schaaf &
Wheeler, September 2000
Protective Elevations to Control Seawater Intrusion in the Salinas Valley, CA, prepared by
Geoscience Support Services, Inc., November 2013
Reclamation Ditch Watershed Assessment and Management Strategy, prepared by The
Watershed Institute, California State University Monterey Bay,
Salinas River Stream Maintenance Program, Final EIR, prepared by Cardno ENTRIX,
September 2013
Salinas Valley Water Project, Final EIR, prepared by EDAW, Inc. April 2002
Salinas Valley Water Project, Annual Flow Monitoring Reports for Water Years 2010,
2011, 2012 and 2013
Salinas Valley Water Project, Flow Prescription for Steelhead Trout in the Salinas River,
prepared by MCWRA Staff and Hagar Environmental Science, October 2005
Zone 2B Proposition 218 Engineers Report, prepared by RMC Water and Environment,
November 2007
Zone 9 and Reclamation Ditch Drainage System Operations Study, prepared by Schaaf &
Wheeler, May 1999
Monterey Regional Water Pollution Control Agency:
Member Agencies Projected Needs Inventory, prepared by EMC Planning Group, April
2013
Monterey Peninsula Groundwater Replenishment Project, Draft Source Water Alternatives
Report, prepared by Kimley-Horn and Associates, September 2013
NOAA Rainfall Records Station USW00023233, SALINAS MUNICIPAL AIRPORT CA US
USDA Natural Resources Conservation Service, Technical Release 55, Urban Hydrology for
Small Watersheds, June 1986
U.S. Geologic Survey, Stream Gage Station Records, Station 11152500 SALINAS R NR
SPRECKELS CA
D-2
December 2014
Monterey Peninsula
Water Management District
D-3
December 2014