Professional Documents
Culture Documents
C200H LK201 and RS232 Comm With LSS and SCADA
C200H LK201 and RS232 Comm With LSS and SCADA
C200H LK201 and RS232 Comm With LSS and SCADA
Helpsheets
COMM0004.2
1
PROBLEM:
This helpsheet describes how to get RS232 communications with the Host Link protocol going with a C200HLK201. This protocol is used with LSS and many SCADA (Supervisory Control And Data Acquisition) packages.
Cable requirements
The following connections will enable a PC to be connected to the C200H-LK201 RS232 port. Where the type
of connector is specified, this refers to the connector to put on the cable.
C200H-LK201
(25 pin male connector)
IBM-PC/Compatible
(female connector)
25 9
pin pin
3
2
7
4
5
2
3
5
7
8
2
3
4
5
7
Rear of LK201
On Off
SW1
SW3
0 0
SW2
5 2
SW4
2
3
4
RS232
CTS
0V
Page 1 of 2
Omron Electronics Factory Automation Technical Support Tel:0181 450 4646 Fax:0181 450 8087
OMRON
Helpsheets
COMM0004.2
1
Manual references:
C200H-LK201 port pin assignments:
W143-E1-4, page 8
C200H-LK201 DIP switch settings:
W143-E1-4, page 22
LSS off-line/on-line and Monitor Data: W237-E1-1A, pages 173-177
Page 2 of 2
Omron Electronics Factory Automation Technical Support Tel:0181 450 4646 Fax:0181 450 8087