Professional Documents
Culture Documents
SB 11-642
SB 11-642
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
References . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Queries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Illustrations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1.
GENERAL.
Paragraph
1
2
3
4
5
Page
1
2
2
9
9
11
CECOM with an O&R contract from the manufacturer, Honeywell Inc., Military Avionics Division.
O&R provides that any component of the altimeter
set, electronic, furnished under contract referenced in
paragraph 3a, which fails to perform as specified and
which is returned to Honeywell, will be repaired or
replaced by Honeywell during the O&R period.
(3) D U R I N G T H E L I F E O F T H E W A R RANTY PERIOD, THERE IS TO BE NO REPAIR
OF THESE ITEMS WITHIN ARMY MAINTENANCE CHANNELS, AVUM, AVIM, DEPOT, OR
BY FACILITIES OTHER THAN THOSE OF THE
MANUFACTURER.
(4) Aviation units receiving aircraft with the
new subject equipment may requisition spares as
authorized.
2. SCOPE. These instructions provide Army field
commanders, other services, and authorized contract
facilities (including airframe manufacturers and commercial airframe overhaul facilities) involved with
Army aircraft, with the method of disposition, handling, and accounting, under the O&R.
3.
PROCEDURES.
Equipment Under Warranty. Items authorized for Repair and Return under Contract DAAB0786-C-H038 are identified in table 2.
b. Materiel Flow.
(1) A general repair and return warranty flow
diagram for Altimeter Set, Electronic AN/APN209( )(V)( ) is shown in figure 1.
(2) Those components requiring repair will be
returned directly to the contractor addressed and
marked as follows:
Honeywell Inc.
Military Avionics Division
1625 Zarthan Ave
St. Louis Park, MN 55416
ATTN: APN-209 Repair Service
Administrator
(3) Under O&R (Contract DAAB07-86-CH038) for the AN/APN-209( )(V)( ) Electronic
Altimeter Set, the AN/APN-209(V), AN/APN209A(V)( ), and AN/APN-209B(V)( ) Electronic
Altimeter Set configurations shall be retrofit by the
contractor to the AN/APN-209C(V)( ) configuration.
Retrofit shall be accomplished by the modification of
the following components:
(a) Height Indicators ID-1917/APN209(V) and ID-1917A/APN-209(V) shall be retrofit to
the ID-1917B/APN-209(V) configuration.
NOMENCLATURE
DASH NO.
QUANTITY
TYPE NO.
AN/APN-209(V)
AS-2595/APN-194(V)
ID-1917/APN-209(V)
RT-1115/APN-209(V)
AN/APN-209A(V)
AS-2595/APN-194(V)
ID-1917/APN-209(V)
RT-1115A/APN-209(V)
-1-2
2 2
0 1
1 1
-1 -2 -3
2 2 2
0 1 2
1 1 1
AN/APN-209B(V)
-1-2-3-4-5-6-7
AS-2595/APN-194(V)
AS-3586/APN-209A(V)
AS-3831/APN-209(V)
ID-1917A/APN-209(V)
RT-141l/APN-209A(V)
RT-1115B/APN-209(V)
2
0
0
0
0
1
2
0
0
1
0
1
0
2
0
0
1
0
2
0
0
1
1
0
0
0
2
0
0
1
0
0
2
1
0
1
AN/APN-209C(V)
-1 -2 -3 -4 -5 -6
AS-2595/APN-194(V)
AS-3831/APN-209(V)
ID-1917B/APN-209(V)
RT-1411/APN-209A(V)
RT-1115C/APN-209(V)
2
0
0
0
1
2
0
1
0
1
2
0
1
1
0
0
2
0
0
1
0
2
1
0
1
0
0
2
1
1
0
0
2
1
1
0
AN/APN-209D(V)
-1-2-3-4-5-6-7
AS-2595/APN-194(V)
AS-3586/APN-209A(V)
AS-3831/APN-209(V)
ID-1917C/APN-209(V)
RT-1411A/APN-209A(V)
RT-1115D/APN-209(V)
2
0
0
0
0
1
2
0
0
1
0
1
2
0
0
1
1
0
0
0
2
0
0
1
0
0
2
1
0
1
0
0
2
1
1
0
0
2
0
0
1
0
NSN
5841-01-058-7873
5841-01-096-8673
5841-01-140-0941
5841-01-245-9090
5841-01-245-9091
5841-01-140-1700
5841-01-245-9094
5841-01-058-7994
5841-01-037-8445
5841-01-245-9092
5841-01-245-9093
5841-00-181-0330
5841-01-069-7660
5895-01-240-8668
5841-01-020-2281
5841-01-023-1211
5841-01-098-4339
5841-01-099-1796
5841-01-114-6007
5841-01-141-8656
5841-01-147-1064
5841-01-145-9991
5841-01-156-0457
5841-01-216-9468
5841-01-245-9097
5841-01-245-9098
5841-01-248-7482
5841-01-245-9099
5841-01-245-9100
5841-01-245-9101
5841-01-245-9102
5841-01-245-9103
5841-01-245-9104
5841-01-245-9105
5841-01-245-9106
5841-01-245-9107
5841-01-245-9108
5841-01-245-9109
5841-01-247-1145
TYPE NO.
RT-1115/APN-209(V)
RTll15A/APN-209(V)
RTll15B/APN-209(V)
RTll15C/APN-209(V)
RTll15D/APN-209(V)
RT-1411/APN-209A(V)
RT-1411A/APN-209A(V)
ID-1917/APN-209(V)
ID-1917A/APN-209(V)
ID-1917B/APN-209(V)
ID-1917C/APN-209(V)
AS-2595/APN-194-(V)
AS-3586/APN-209A(V)
AS-3831/APN-209(V)
AN/APN-209(V)l
AN/APN-209(V)2
AN/APN-209A(V)l
AN/APN-209A(V)2
AN/APN-209A(V)3
AN/APN-209B(V)l
AN/APN-209B(V)2
AN/APN-209B(V)3
AN/APN-209B(V)4
AN/APN-209B(V)5
AN/APN-209B(V)6
AN/APN-209B(V)7
AN/APN-209C(V)l
AN/APN-209C(V)2
AN/APN-209C(V)3
AN/APN-209C(V)4
AN/APN-209C(V)5
AN/APN-209C(V)6
AN/APN-209D(V)l
AN/APN-209D(V)2
AN/APN-209D(V)3
AN/APN-209D(V)4
AN/APN-209D(V)5
AN/APN-209D(V)6
AN/APN-209D(V)7
NOMENCLATURE
Receiver-Transmitter, Height
Receiver-Transmitter, Height
Receiver-Transmitter, Height
Receiver-Transmitter, Height
Receiver-Transmitter, Height
Receiver-Transmitter
Receiver-Transmitter
Indicator, Height
Indicator, Height
Indicator, Height
Indicator, Height
Antenna
Antenna
Antenna
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Electronic Altimeter Set
Indicator
Indicator
Indicator
Indicator
Indicator
(d)
FAILURE INDICATION.
(e)
DATE INSTALLED.
(f)
DATE REMOVED.
(g)
(h)
MILSTRIP
(i)
DA
NUMBER.
DOCUMENT
NUMBER.
FORM
2407
CONTROL
NUMBER.
(j)
ADDRESS.
NOTE
Failure to provide complete data in the
message will cause delay in forwarding a
replacement component. Omitted data
will have to be obtained from the
returning activity before replacement.
(k) Message will be sent to:
Honeywell Inc.
Military Avionics Division
1625 Zarthan Ave.
St. Louis Park, MN 55416
ATTN: APN-209 Repair Service
Administrator MN 15-2335
f. Documentation (Installed/Removal).
(1) A preaddressed mail warranty card will be
attached to each component (figure 2). Remove this
card at the time of installation. Complete (print legibly) the installation information and place the card in
the mail without delay.
(2) All activities that return any ANIAPN209( )(V)( ) component for warranty or repair are
as follows:
Hours.
2. Item 16- Fill in aircraft type and tail
number.
3. Item 19- YES Block.
4. Item 21- Released for Investigation.
5. Item
22 - In addition to details
describing the problem the following statements must
be included in block 22: Installation/Removal Data
Label has been filled in, and FOR INFORMATION
ONLY - O&R WARRANTY.
(c) Attach one (1) copy to the equipment
being returned to the manufacturer.
(d) Failed items should be returned to
the manufacturer immediately. Normal conditions
call for withholding disposition, pending receipt of
disposition instructions from the Product Assurance
Directorate CECOM; however, for these warranties
immediate return to the contractor is authorized.
(5) An Installation/Removal Data Label and
Instruction Decal are affixed to each Height Indicator
Receiver-Transmitter, Receiver-Transmitter, Height
Indicator, and Antenna. The Installation/Removal
Data label shall be completed legibly, using a ballpoint
pen, by the returning activity. The label and decal are
shown in figure 5.
VOLUME
(CU FT)
CARTON SIZE
(IN) (ID)
Receiver-Transmitter, Height
Indicator
RT-1115/APN-209(V)
RT-1115A/APN-209(V)
RT-1115B/APN-209(V)
RT-1l15C/APN-209(V)
RT-1115D/APN-209(V)
3.25x3.25x9.70
13x14.5x21
2.29
8.0
Receiver-Transmitter
RT-1411/APN-209A(V)
RT-1411A/APN-209(V)
3.45x4.0x5.90
9.5x11.5x11.0
0.70
5.0
Indicator, Height
3.25x3.25x7.00
9.5x11.5x11.0
0.70
5.0
Antenna
AS-2595/APN-194(V)
AS-3586/APN-209(V)
AS-3831/APN-209(V)
5.75x(DIA)x1.8
3.50x3.50x0.90
5.75x(DIA)x1.8
9.5x7.0x6.0
9.5x7.0x6.0
9.5x7.0x6.0
0.23
0.23
0.23
1.0
1.0
1.0
COMPONENT
WEIGHT (LB)
h. Transportation.
(1) The transportation costs for shipments of
failed equipment to the contractors plant or repair
facility are to be borne by the user or shipping
activity.
(2) Special Procedures for Activities
Returning Defective Equipment:
(a) Materiel will be shipped to the contractors plant for repair and return in accordance
with those procedures contained in the equipment
technical manual (TM), along with the documentation prescribed therein.
(b) Equipment returned to contractors
plant will contain only those items covered under this
contract and listed in paragraph 3a above.
(c) All Army and other DOD activities
returning AN/APN-209( )(V)( ) components for
O&R will complete a DD Form 1348-1 as required by
AR 725-50 (Requisitioning, Receipt, and Issue
System).
(d) All items are to be shipped by insured
priority mail with return receipt requested. In addition to the priority mail markings the parcels should
also be marked Fourth Class Mail Enclosed. Authorization for the above exception to AR 340-3 has been
granted for O&R items by Director, Postal Directorate, HGDA. The authorization is contained in
DAAG-MAP (1 Jul 77) 3rd Ind. Subject: Request for
Exception to Permit the Use of Certified Mail and
Return Receipts when Mailing MILSTRIP Parcels
dated 11 April 1978. All failed units are to be shipped
back to the contractor as soon as they are packaged
and all accompanying documents are completed. All
shipments must be insured up to the limit of their
value or permissible maximum allowed by the USPS
(not to exceed the shipment value).
(e) All materiel for repair and return is
to be shipped to the address listed in paragraph 3b(2)
NOTE
Although shipment will be accomplished
through use of one or the other documents listed above (DD Form 1348-1 or
DD Form 1149), accountability for
equipment returned for repair/replacement will be the responsibility of the
USER (returnee) until receipt at the
Contactor Repair Facility, at which time
accountability will be assumed by the
Defense Contracting Administration
Services Office (DCASO) Administrative Contracting Officer (ACO), for contract DAAB07-86-C-H038.
(h) Distribution of DD Form 1348-1 or
DD Form 1149 is as follows:
1. One copy accompanying the equipment returned to the contractor, addressed to:
Honeywell Inc.
Military Avionics Division
1625 Zarthan Ave
St. Louis Park, MN 55416
ATTN: APN-209 Repair Service
Administrator
2.
addressed to:
DCASO Honeywell
2701 Fourth Ave S
Honeywell Plaza
Minneapolis, MN 55402
ATTN: ACO CONTR DAAB07-86-CH038
3. One copy addressed to:
CGUSACECOM
ATTN: AMSEL-PA-E
Fort Monmouth, NJ 07703-5000
b. Equipment Technical Manuals: TM 11-5841284-23&P, Operators Organization, and Direct Support Maintenance Manual (Including Repair Parts
INFORMATION REQUIRED
ADDRESS
Technical
Commander
US Army AVRADA
ATTN: DAVAA-E
Fort Monmouth, NJ 07703-5000
AUTOVON 995-4403
Commercial (201) 544-4403
Maintenance
Commander
US Army CECOM
Maintenance Directorate
ATTN: AMSEL-LC-ME-EW
Fort Monmouth, NJ 07703-5000
AUTOVON 992-3793
Transportation
Commander
US Army CECOM
Material Management Directorate
ATTN: AMSEL-LC-MM-DD-T
Fort Monmouth, NJ 07703-5000
AUTOVON 992-2234
Supply
Commander
US Army CECOM
Material Management Directorate
ATTN: AMSEL-LC-MME-AN
Fort Monmouth, NJ 07703-5000
AUTOVON 992-1626
Commander
US Army AVRADA
ATTN: DAVAA-A/PA
Fort Monmouth, NJ 07703-5000
AUTOVON 995-2844
10
11
12
95-8279/2
MESSAGE EXAMPLE
SUBJECT NOTICE OF AN/APN-209 FAILURE CONTR DAAB07-86-C-H038 - REQUEST REPLACEMENT OR REPAIR OF FOLLOWING COMPONENT:
1. CW-3 JONES, AUTOVON 314-444-1234
2. RT-ll15A/APN-209, SER #235A, NSN 5841-01-058-7873
3. AH-1S 76-22600
4. UNIT WILL NOT TURN ON
5. INSTALLED 11 JAN 85
6. REMOVED 3 OCT 85
7. US POSTAL SYSTEM INSURED RETURN RECEIPT NO 123
8. WK4K6A 9337 00 01
9. FORM 2407 CONTROL #123456
10. 11 AVN BN APO NEW YORK 09165
13
14
15
16
CARL E. VUONO
General, United States Army
Chief of Staff
Official:
WILLIAM J. MEEHAN II
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION :
To be distributed in accordance
requirement for SB 11-642.
with
DA
Form
12-34
PIN:
014842-000