Professional Documents
Culture Documents
TPS07-004 Rev1.2 A8 Quick Configuration Guide
TPS07-004 Rev1.2 A8 Quick Configuration Guide
doc
(a) INTRODUCTION
This manual is to introduce a quick way to configure ALTAI A8 BTS through web-admin interface.
It is applicable for the following model, hardware and firmware version:
Product name
: A8 802.11ab/g AP BS/Bridge AC
Model number
: WA8011A-A
Hardware Platform : R2
Firmware version
: 1.4.0.11
FPGA version
: 0x3e
For the details, please refer to the Altai A8 WiFi Base Station Cable Configuration Guide.
Through Wireless:
The default SSID of A8 BTS is Altai WiFi Network 0. You could associate to this SSID when
you turn A8 on.
SETUP LOCAL AREA CONNECTION ON YOUR COMPUTER
For Windows XP user,
1. Click the start menu and choose Control Panel.
2. Click Network Connections.
3. Right-click on the Local Area Connection and select Properties.
4. Marking the Internet Protocol (TCP/IP) and click the Properties.
5. Type in an IP address, for example, 192.168.1.2, which is under the same subnet as the
Default IP Address of A8 BTS (192.168.1.222).
6. Using the default Subnet mask (default: 255.255.255.0) setting at the first time.
7. Click OK when you finish setting and close the Window.
Commercially Confidential
TPS07-004_rev1.2_A8_Quick_Configuration_Guide.doc
Default Username
Default Password
: altai
: wag
4. A Menu Bar is located on the left hand side of the front page of web-admin window.
PARAMETER CHANGE
5. Click 2.4GHz Radio under System, you could configure IP address, Subnet, Gateway, etc
You need to click update to save the change (but the change has not been effective yet).
6. Click 2.4GHz Radio under Configuration, you could configure Radio Frequency (i.e.
Channel), SSID, transmit power, etc Again, you need to click update to save the change.
7. Click Reboot under System then click Reboot Base Station to make the change to be effective.
The A8 BTS will take about 20 seconds for startup.
Commercially Confidential