Professional Documents
Culture Documents
21 MasterRC Pile Cap Design and Detailing
21 MasterRC Pile Cap Design and Detailing
21 MasterRC Pile Cap Design and Detailing
Pile caps are analysed and designed to BS 8110 or SABS 0100 for concentrically,
axially loaded standard shaped pile caps with up to 9 piles in the group.
As input data is altered, the calculations and graphics update immediately.
The general form of the pile caps follows the conventions established by Whittle and
Beattie (Concrete, 1972).
The reinforcement in the pile cap is automatically detailed and can be printed to the
printer or exported to a DXF file or to the MasterRC detailing package.
Several pile caps can be contained within one file.
19-1
19-2
The following data is input: pile diameter for a circular pile (or width for a square pile)
safe working load (in kilonewtons)
pile spacing (no. of pile diameters)
overall pile cap depth (mm)
minimum number of piles required for each design or opt to have the program
calculate the minimum number
dead and live loads (kN)
relevant factors of safety
Concrete details and reinforcement grades, diameters and spacings are entered. There
is also an option to use square piles rather than circular. The overhang dimension from
the edge of the pile to the edge of the pile cap is also entered. The minimum dimension
is normally150mm for a circular or square pile. The program allows for the square pile to
MasterRC Pile Cap Design
19-3
have been driven rotated at 45 degrees on plan (worst orientation), hence giving a
distance of (0.707x pile dia + overhang dimension) from the centre of the pile to the
edge of the cap.
The Top margin box allows the overall drawing location to be modified on screen. Enter
a positive value to move the drawings up or a negative value to move them down.
Note that you can have several pile caps (briefs) in one file. Hence, all piles caps in one
project can be easily managed. If all the pile caps are saved in the same file, then a
single schedule will be created for all the caps, with the bars being rationalised.
To add a new brief to a file, click on the
button, give the new brief a relevant title
and continue the design by entering the data for that new pile cap. Use the
and
buttons to manage the briefs for each file. You can navigate through the briefs
using the up and down arrows to the right of the brief title area or by dropping the list
and selecting the brief you wish to work on.
21.5 Side and Upper Reinforcement Details
19-4
The side reinforcement information is entered including side bar detailing style. A top
nominal reinforcement cage can be added if desired.
21.6 Printing Results
Graphics and calculations can be printed out using the Print option from the top menu,
to print a single brief or all the briefs in a file. You can also use the icons below the top
menu. If you have PowerPad the results can be exported to a Word document.
Switch graphics on or off when exporting or printing.
Edit project title and job references.
Print current or all briefs to printer.
Export current or all briefs to Word (PowerPad users only).
19-5
Typical Schedule
19-6