Professional Documents
Culture Documents
Solved Paper Kerala Water Authority
Solved Paper Kerala Water Authority
Solved Paper
Operator: Ken
Water Authority
could be achieved by using a con- (a) Alternating current
troller with :
(b) Direct current
(a) Dynamic brake push-button
(c) Pulsating current
(b) Regenerative brake push-button (d) Oscillating current
(c) l)elay push-button
65. When an electric train moves
(d) Jogging push-button
down a hill, the DC series motor
51. Degaussing is the process of:
then act as:
(a) Removing gases from a material (a) DC shunt motor
(b) Removing impurities from a (b) DC shunt generator
magnetic material
(c) DC series motor
(c) Demagnetizing a metallic part
(d) DC series generator
(d) Demagnetizing a magnet
66. Wheat stone bridge works on the
52. HRC fuse is superior protective
principle of:
device as compared to circuit
Ohms Law
breaker and relay as far as:
Kirchoff 's Laws
(a) Electromagnetic stresses are (e) Joules Law
concerned
(d) Faraday's Law
(b) Thermal stresses are concerned
67. In DC machines for more voltage
(c) Both electromagnetic and therusually winding is done in:
mal stresses are concerned
(a) Lap winding
(d) None of the above
(b) Double Layer winding
53. Which of the following material (c) Wave winding
has a negative temperature co- (d) Concentric winding
efficient of resistance?
68. The curve representing ohm's
(a) Carbon
(b) Brass
law is:
(c) Copper
(d) Aluminium
(a) A parabola
(b) Line functions
54. By inserting reactance in the (c) Linear
(d) A hyperbola
rotor circuit:
69. The capacity of a Lead acid cell
(a) Reduces starting torque as well
is usually expressed in:
as maximum torque
(a) Ampere hour (b) Voltage
(b) Increases starting torque but (c) Watts
(d) Ampere
maximum
torque
remains 70. The output voltage of ignition
unchanged
coil in an automobile is given to:
(c) Increases starting torque as well (a) Battery
(b) Distributer
as maximum torque
(c) Headlight
(d) Spark plug
(d) Increases starting torque but 71. When power factor is unity, the
maximum torque reduces
phase angle between voltage and
55. In three phase power measurecurrent?
ment by two wattmeter method, (a) 45 (b) 90 (c) 60 (d) 0
reading of one wattmeter found 72. In a water turbine alternator the
negative. Then the P.F of the load
speed will be:
is:
(a) Low
(b) Medium
(a) 0.4 lagging
(b) 0.5 lagging
(c) High
(d) Very high
(c) 0.8 lagging
(d) Unity
73. The speed of a DC series motor is
56. Eposy cable joint is used where
dangerously high at no load
(a) H.T cable joints
because:
(b) Heating of the cable is not permitted (a) Back emf is high
(c) Temporary joint
Armature voltage is low
T' jointsonly
(c) Flux is very low
57. At the suction stroke in a recip- (d) Armature current is high
rocating pump, the valve closes 74. Which caliper is used for scriband valve opens.
ing line along curved edges?
(a) Foot, Non return
(a) Inside caliper
(b) Non return, Foot
Outside caliper
(c) Delivery, Suction
(c) Spring joint caliper
(d) Suction, Delivery
(d) Jenny caliper
58. Voltage stabilizers having auto 75. This is not the reason for no light
transformer in servo stabilizer is of
from the bulb in an automobile
(a) Core type
lighting system :
(b) Shell type
(a) Overcharged battery
(c) 1)istributed core type
(b) Defective light switch
(d) Toroidal type
(c) hised bulb
59. The ripple factor of a capacitor (d) Blown fuse
76. If a contactor is in the open posifilter may be decreased by
(a) Decreasing RI
tion, the armature is at its great(h) Increasing RI
est distance from the core and
Increasing C
the impedance of the coil is:
Increasing both RI and C
(a) Zero
(b) Low
60. On doubling the supply frequenHigh
cy, the eddy current will
Half the normal value
(a) Become half of their former value 77. For a given VA rating cross-secBecome four times of their former
tion area of core will be less if the
value
following metal is used:
(c) Remains unaffected
(a) Dynamo sheet
(d) Become eight times of their forHigh alloy sheet
mer value
Normal iron sheet
61. If three persons take reading in (d) Stalloy sheet
horizontally placed meter at the 78. Which of the following is not
same instant, whose reading is
used for etching?
correct?
(a) Ferric Chloride
(a) The reading taken by the left (b) Cupric Chloride
hand side person
(c) Alkaline Ammonia
(b) The reading taken by the middle (d) Carbon Tetra Chloride
79. ith AC or DC electric motor can
person
The reading taken by the right
be used to automatically:
hand side pe rson
(a) Charge the spring
The reading taken by three per- (h) To release the spring
sons simultaneously
To discharge the spring
62. If the end of the shaft of a
To load the circuit break er
grinder motor turn blue it is an 80. Air pollution is the least in this
indication of:
type of energy converter:
(a) Over heating (b) Scoring
Bio gas energy converters
(c) Freezing
(d) Burring
Diesel generating sets
63. In black cotton soil, where water
Solar cell energy converter
level is encountered within the:
Thermal electric generating stations
pole pit, it is better to use:
81. Which is the largest fresh water
lake in Kerala?
Concrete foundation
(a) Astaniudi
(b) Vembanad
Earthen foundation
Embankment only
(c) Wular
(d) Kolleru
Mass concrete and embankment 82. What is the total cost length of
64. For testing insulation resistance
Kerala?
the most suited electrical supply is: (a) 290. (b)490 (c) 590 (d) 440
Answer Key
lB 20, 30, 4A, 5D, 6B, 7-, 8B,
9A, 10- I1B 12B 13A 14C
15D 16C 17- 18A 19D 20A
21D' 22B' 23A 24d 25A 26B'
OVA ' OQA
cnn 0')
i
)AD
OOtt, Y*D OU'
1
- 'JQD,
) IJJ
O'J
'
'
'
'
'