Professional Documents
Culture Documents
Automatic Job Sorting System Depending Murugappa
Automatic Job Sorting System Depending Murugappa
Automatic Job Sorting System Depending Murugappa
ON THEIR HEIGHT
INTRODUCTION;
Nowadays Automation occupies various electronic sections by its
comfortable nature. This is an era of automation where it is broadly defined
as replacement of manual effort by electronic power in all degrees of
automation. The operation remains an essential part of the system although
with changing demand on physical input as the degree o mechanization is
increased.
Degrees of automation are of two types. Viz.,
Full automation
Semi automation
In semi automation a combination of manual effort and electronic
power is required whereas in full automation human participation is very
negligible. In our project, the three different height jobs are segregated and
loaded in to their cabin automatically.
SYNOPSIS;
In
this
project,
AUTOMATIC
JOB
SORTING
SYSTEM
WORKING PRINCIPLE;
Before operating this unit set the 5 bar air pressure in the FRL unit. There
are three IR sensors fitted in the platform to check the height of the job and
are connected to microcontroller input. These sensors are used to give
signals to the controller for identifying their height . After getting the signal
from the sensor, the microcontroller switch on the power supply to the
5/3
way double solenoid operated Directional control valve to lift the job and
are stopped at correct cabin with the magnetic sensor. .A magnet is placed
with the platform which activates the magnetic sensor in order to stop the
platform at the required position. The controller also controls another
solenoid valve for actuating the ejecting cylinder to eject the job into cabin.
To start the operation, place the object on the platform and the sensor which
sends the signal to the input of the controller which drives the signal to the
5/3 way solenoid valve .This valve actuate the double acting cylinder which
pushes the platform with the object to be lifted.
To control the speed of the lift two flow control valves are fitted at each port
of the air cylinder.
When the platform unit crosses the magnetic sensor , sends the signal
to the microcontroller
BLOCK DIAGRAM
START/STOP
POWER SUPPLY
(0 TO 24V)
INPUT
MICRO
CONTROLLER
OUTPUT
ADVANTAGES
It requires simple maintenance cares
Segregation of parts are done automatically.
5/2 WAY
SOLENOI
DVALVE
FOR
EJECTING
SYSTEM)
2. It helps in ASRS (AUTOMATIC MATERIAL STROAGE AND
RETRIVAL SYSTEM)
CONCLUSION;
Thus by fabricating this automatic job segregation unit ,
everyone can easy to learn and understand about the