Professional Documents
Culture Documents
Tray - CAD Tutorial
Tray - CAD Tutorial
Tray - CAD Tutorial
Click on Define.
.
Draw horizontal and vertical centerlines through
coordinate system. These centerlines are used to ensure
symmetry of the section.
Click
, and draw the rectangle as shown. Note that
the rectangle should be symmetrical to both centerlines.
Click
Click
Click
Click
Click
and select Standard
Orientation.
Pick the box area under Draft hinges, and select TOP datum plane.
Enter 5 as draft angle.
Be sure the resulted draft larger on the top surface of the base feature see figure
below.
Click on
10
Click
Click on
to
define sketch section for cut.
Pick FRONT as sketching plane, accept default and click Sketch button.
11
Click Close.
Pick
to
12
Click
. Then Click
13
Click
14
Click
Click
15
Click
Click
16
Click
Select both sides
protrusion
and
enter the depth of 3
mm see figure on the
left.
Click Placement ->
Define.
Click Sketch.
17
Pick these
edges
Click
, and
pick additional
references as
shown.
Close.
18
Click
. Then Click
19
Click
Pick the bottom surface as sketching plane, accept default, and click Sketch.
20
21
Click
. Then Click
.
22
Click
Make sure that RIGHT datum plane is selected as Reference, and Right
Orientation. Click Sketch.
23
24
Click
25
Then Click
Click
26
Create a Sweep
27
Select Traj.
Tangnt Chain
Pick the outer top edge
of the model.
Done
28
Accept.
Okay.
29
Sketch and dimension the following section. Be sure the line on the left is aligned
with the inclined hidden edge. Also top and bottom horizontal lines of the section are
in the same length see figure below. You might need to add references!
30
Click
ASSIGNMENT
Submit several shaded views (at least TWO views) showing TOP and BOTTOM of the
tray with your report. Be sure to turn the background to WHITE and turn-off ALL
datum features including the spin center.
31