Professional Documents
Culture Documents
Advance Review Weekly Exam 2 Bacolod
Advance Review Weekly Exam 2 Bacolod
Advance Review Weekly Exam 2 Bacolod
Weekly Exam 2
ELEX
Electronics Engineering
2.
3.
Carbon-composition resistors
A. can handle gigantic levels of power.
B. have capacitance or inductance along with resistance.
C. have essentially no capacitance or inductance.*
D. work better for ac than for dc.
What type of resistor, or combination of resistors, would you use as
the meter-sensitivity control in a test instrument, when continuous
adjustment is desired?
A. A set of switchable, fixed resistors
B. A linear-taper potentiometer*
C. An audio-taper potentiometer
D. A wirewound resistor
Suppose a 1-k resistor will dissipate 1.05 W, and you have a good
supply of 1-W resistors of various ohmic values. If theres room for
20 percent resistance error, the cheapest solution is to use
A. four 1-k, 1-W resistors in series-parallel.
B. a pair of 2.2-k, 1-W resistors in parallel.*
C. a set of three 3.3-k, 1-W resistors in parallel.
D. a single 1-k, 1-W resistor, because all manufacturers allow for a
10 percent margin of safety when rating resistors for their powerhandling capability.
4.
5.
6.
7.
A carbon-film resistor is color coded with red, violet, black, and gold
stripes. What are its resistance and tolerance?
A. 27 5%*
C. 270 10%
B. 270 5%
D. 27 10%
8.
9.
14. An air capacitor has two parallel plates 10cm and 0.5 cm apart.
When a dielectric slab of area 10cm2 and thickness 0.4 cm was
inserted between the plates, one of the plates has to be moved by
0.4 cm to restore the capacitance. What is the dielectric constant of
the slab?
RF Review Center : MANILA-CEBU-BAGUIO (0932-175-1218)
A. 3
B. 5*
C. 4
D. 6
Page 1
CERTC
Weekly Exam 2
ELEX
Electronics Engineering
A. 5 -30*
B. 1.78 -27.8
C.7.18 -27.8
D. 3.45 39
Page 2
CERTC
ELEX
Weekly Exam 2
Electronics Engineering
C. Reluctance
D. Magnetizing force*
87. Calculate the flux density that will be produced by the field intensity
of 2000 a. t/m for a permeability of 126 x 10^-6 T/A.t/m
A. 0.252 G
C. 0.252 T*
B. 0.252 x 10^-2 T
D. 0.252 x 10^-2 G
88. A point charge, Q=30nC is located at the origin in Cartesian
coordinates. Find the electric flux density D at (1,3-4) m.
A. 12.7pC/m^2
C. 19.8 pC/m^2 *
B. 18.5pC/m^2
D. 15.6 pC/m^2
89. Ten identical charges of 500uC each are spaced equally around a
circle of radius 2. Find the force on a charge of -20uC located on the
axis, 2m from the plane of circle.
A. -97.5 an N
C. 79.5 an N
B. 97.5 an N
D. -79.5 an N*
90. What is the SI base unit of EMF?
A.
m2 kg s3 A1 *
B.
m kg s
C.
D.
mkg s2
2
3 2
m kg s A
Page 3
CERTC
Weekly Exam 2
ELEX
Electronics Engineering
B. 1232
D. 7890
C. 50 ohms
D. 60 ohms
94. Which circuit fault do the meter readings in the given figure
indicate?
A. R1
B. R3
C. R2
D. R4*
resistor is shorted.
B. The 4.7 k
resistor is shorted.
C. The 2.2 k
resistor is shorted.
D. The 3.3 k
resistor is shorted.*
99. If there are 28 branches and 6 nodes in a certain circuit, how many
independent loops or mesh loops can be made the circuit?
A. 22
C. 24
B. 23*
D. 25
100. The circuit below is referred to as a bridge circuit and is used
extensively in electronic and scientific instruments. Calculate the
current I and the voltage Vabwhen Rx=0 ohms.
A.
B.
45.5 mA
44.4 mA
C. 43.3 mA
D. 42.2 mA *
God Bless!
A. 220
C. 6,899
Page 4